NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
228 reportsMileage unknown · Jan 15, 2020
EngineFuel/propulsion System
WHILE DRIVING THE VEHICLE A STRONG ODOR OF GAS ENTERING THE CABIN. FILL VEHICLE UP AND LARGE AMOUNT OF GAS POURS ON THE GROUND FROM UNDER THE VEHICLE. CLOSER INSPECTION REVEALS THE PART THAT ATTACHES TO THE GAS TANK IS BROKEN OFF CAUSING VAPORS TO ESCAPE AND NOT PROVIDING A SEAL TO CONTAIN THE SMELL. WHILE DRIVING ON THE INT…
Read full complaint
WHILE DRIVING THE VEHICLE A STRONG ODOR OF GAS ENTERING THE CABIN. FILL VEHICLE UP AND LARGE AMOUNT OF GAS POURS ON THE GROUND FROM UNDER THE VEHICLE. CLOSER INSPECTION REVEALS THE PART THAT ATTACHES TO THE GAS TANK IS BROKEN OFF CAUSING VAPORS TO ESCAPE AND NOT PROVIDING A SEAL TO CONTAIN THE SMELL. WHILE DRIVING ON THE INTERSTATE AT NORMAL OPERATING SPEED VEHICLE LOSES OIL PRESSURE CAUSING IT TO DROP TO 0 AND MESSAGE APPEARS TO STOP ENGINE. BOTH INCIDENTS ARE SAFETY HAZARDS AND CAN CAUSE SERIOUS LIFE AN DEATH INCIDENTS IF ISSUES ARE NOT ADDRESSED BY THE CORPORATION. THIS OCCUR ON INTERSTATE 66 IN WASHINGTON, DC. IMMEDIATE RECALL OF ALL VEHICLES FROM GMC NEEEDS TO BE INITIATED.
NHTSA ODI #11299450
188,000 miles · Apr 4, 2019
Electrical SystemEngineVehicle Speed Control
I WAS DRIVING DOWN THE ROAD WHEN THE CAR SHUT DOWN EVERYTHING I WAS SCARED BECAUSE I HAD TRAFFIC RIGHT BEHIND ME GOING 45MPH AND THEN THEY CAR WOULD NOT RUN AGAIN. I WAS RIGHT IN THE MIDDLE OF AN INTER SECTION AT HALL ROAD AND 59 IT WAS THE SCARIEST THING THAT HAS HAPPENED TO ME. I BOUGHT THIS VEHICLE AS A USED AUTO AND I'M NOT …
Read full complaint
I WAS DRIVING DOWN THE ROAD WHEN THE CAR SHUT DOWN EVERYTHING I WAS SCARED BECAUSE I HAD TRAFFIC RIGHT BEHIND ME GOING 45MPH AND THEN THEY CAR WOULD NOT RUN AGAIN. I WAS RIGHT IN THE MIDDLE OF AN INTER SECTION AT HALL ROAD AND 59 IT WAS THE SCARIEST THING THAT HAS HAPPENED TO ME. I BOUGHT THIS VEHICLE AS A USED AUTO AND I'M NOT SURE IF THE EMMISSION SYSTEM EVER GOT CHANGED AND THIS HAPPENED ONCE BEFORE AND THE DEALER SAID NOT TO DRIVE WITH MY HOUSE KEYS ATTACHED. I HAD TO GET THE AUTO TOWED HOME.
NHTSA ODI #11193870
181,000 miles · Nov 23, 2018
Fuel/propulsion System
WHEN IN PARK POSITION HEAVY GAS FUMES COMING FROM A LEAK AT THE TOP OF THE TANK. YOU CAN VISUALLY SEE THE GAS STAINS ON THE SIDES AND BOTTOM OF TANK.WHEN ROLLING TO A STOP THE FUMES RETURN.I'M GETTING HEADACHES AND BURNING OF MY EYES AND THROAT.I CHECKED MY VIN FOR RECALLS, THE PARTS INVOLVED ARE #14423C FUEL TANK INLET CHECK V…
Read full complaint
WHEN IN PARK POSITION HEAVY GAS FUMES COMING FROM A LEAK AT THE TOP OF THE TANK. YOU CAN VISUALLY SEE THE GAS STAINS ON THE SIDES AND BOTTOM OF TANK.WHEN ROLLING TO A STOP THE FUMES RETURN.I'M GETTING HEADACHES AND BURNING OF MY EYES AND THROAT.I CHECKED MY VIN FOR RECALLS, THE PARTS INVOLVED ARE #14423C FUEL TANK INLET CHECK VALVE FRACTURE,AND #07076A FUEL TANK MODULAR RESERVOIR ASSEMBLY CORROSION #12166 FUEL FILLER NECK..I'M AFRAID EVERY TIME I DRIVE IT THAT I COULD BE BODILY HARMED AT ANY GIVEN MOMENT, A SPARK,SOMEONE FLICKING A CIGARETTE,A ACCIDENT, ANYTHING THAT WOULD TRIGGER A SPARK.
NHTSA ODI #11153309
110,000 miles · Sep 4, 2018
Fuel/propulsion System
TL* THE CONTACT OWNS A 2003 GMC ENVOY XL. THE CONTACT NOTICED A STRONG FUEL ODOR INSIDE THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO MANFREDI CHEVROLET (2519 HYLAN BLVD, STATEN ISLAND, NY 10306, (347) 979-0291) PER AN UNKNOWN RECALL REGARDING THE FUEL TANK. THE CONTACT WAS INFORMED THAT THE FAILURE WAS NOT RELATED TO THE RECALL.…
Read full complaint
TL* THE CONTACT OWNS A 2003 GMC ENVOY XL. THE CONTACT NOTICED A STRONG FUEL ODOR INSIDE THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO MANFREDI CHEVROLET (2519 HYLAN BLVD, STATEN ISLAND, NY 10306, (347) 979-0291) PER AN UNKNOWN RECALL REGARDING THE FUEL TANK. THE CONTACT WAS INFORMED THAT THE FAILURE WAS NOT RELATED TO THE RECALL. THE CONTACT THEN TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL TANK WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.
NHTSA ODI #11124365
145,000 miles · Jun 26, 2018
Electrical SystemEngineExterior Lighting
WHILE DRIVING ON THE HIGHWAY AT 65 MPH, THE THIRD ROW FLOOR GOT REALLY HOT AND MY CHILDREN WERE SAYING THEIR FEET WERE REALLY HOT AND WE SMELLED SOMETHING LIKE PLASTIC MELTING AND MY 15 YEAR OLD COUSINS BOOT MELTED AND THE CARPET MELTED AND YOU CAN SEE METAL. ONCE WE ARRIVED HOME THE BLINKER STAYED ON AND DID NOT SHUT OFF UNTIL …
Read full complaint
WHILE DRIVING ON THE HIGHWAY AT 65 MPH, THE THIRD ROW FLOOR GOT REALLY HOT AND MY CHILDREN WERE SAYING THEIR FEET WERE REALLY HOT AND WE SMELLED SOMETHING LIKE PLASTIC MELTING AND MY 15 YEAR OLD COUSINS BOOT MELTED AND THE CARPET MELTED AND YOU CAN SEE METAL. ONCE WE ARRIVED HOME THE BLINKER STAYED ON AND DID NOT SHUT OFF UNTIL THE BATTERY DIED. JUST BEFORE THIS HAPPED THE VEHICLE LOST POWER AND MY HUSBAND HAD TO PUT HIS FOOT ON THE GAS ALL THE WAY.
NHTSA ODI #11104092
90,000 miles · Feb 8, 2018
StructureSuspension
WE PURCHASED OUR 2003 GMC ENVOY XL SLE 8 CYLINDER BRAND NEW AT ALDEN BUICK IN FAIRHAVEN, MASS IN JULY 2003; FOR THE PAST 3 YEARS WE HAD IT SERVICED AT ROBERTSSON'S GMC 2680 CRANBERRY HIGHWAY, WAREHAM, MASS.02571,508-291-0044. WE HAD IT RECONDITIONED AT THIS DEALERSHIP LAST YEAR, SPENDING $4000.00; WE HAD IT INSPECTED AT THIS DEA…
Read full complaint
WE PURCHASED OUR 2003 GMC ENVOY XL SLE 8 CYLINDER BRAND NEW AT ALDEN BUICK IN FAIRHAVEN, MASS IN JULY 2003; FOR THE PAST 3 YEARS WE HAD IT SERVICED AT ROBERTSSON'S GMC 2680 CRANBERRY HIGHWAY, WAREHAM, MASS.02571,508-291-0044. WE HAD IT RECONDITIONED AT THIS DEALERSHIP LAST YEAR, SPENDING $4000.00; WE HAD IT INSPECTED AT THIS DEALERSHIP WITH THE MASSACHUSETTS VEHICLE CHECK; IT PASSED THE FRONT END CHECK AND FRAME CHECK ON 8/4/17. I WAS DRIVING THE VEHICLE IN LATE DECEMBER, AND HIT SEVERAL DEEP POTHOLES CAUSED BY AN ICE STORM; SHORTLY THEREAFTER I LOST STEERING CONTROL OF THE VEHICLE. I HAD IT TOWED TO ALDEN BUICK/GMC IN FAIRHAVEN, MASS. TO BE TOLD THAT THE ENTIRE FRAME HAD COLLAPSED DUE TO EXTENSIVE CORROSION AND RUST. I HAD IT TOWED TO ROBERTSON'S GMC IN WAREHAM AND FILED A CLAIM WITH COMMERCE INS. CO. TO HOPEFULLY COVER THE DAMAGE TO THE FRAME; COMMERCE DENIED THE CLAIM STATING"THE FRAME ASSEMBLY WAS SEVERELY ROTTED AND THIS EXTENSIVE ROT ALLOWED THE RIGHT FRONT CONTROL ARM TO BREAK AWAYFROM THE MOUNTING POINT ON THE FRAME RAIL. GMC ISSUED A TECHNICAL SERVICE BULLETIN STATING THAT SOME ENVOY MODELS SUFFERED FROM EXTENSIVE FRAME CORROSION. WHY DID ROBERTSON'S GMC PASS THE VEHICLE ON THE SAFETY CHECK, AND WHY WAS I NOT INFORMED OF THE VEHICLE'S FRAME CORROSION BEFORE I SPENT THE $4000.00 RECONDITIONING IT? WHY IS FRAME CHECK AND FRONT END CHECK LISTED AS PASS ON MY VEHICLE WHEN THIS CORROSION AND RUST WAS PRESENT AT TIME OF INSSPECTION? FORTUNATELY NEITHER I NOR ANY OF MY FAMILY MEMBERS WERE INJURED WHILE DRIVING/RIDING IN THIS VEHICLE.
NHTSA ODI #11071689
90,000 miles · Jul 19, 2017
Fuel/propulsion System
TL* THE CONTACT OWNS A 2003 GMC ENVOY XL. THE CONTACT STATED THAT THE FILLER PIPE WAS FRACTURED AND CAUSED THE BLADDER TO LEAK. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE BLADDER AND FILLER NECK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2003 GMC ENVOY XL. THE CONTACT STATED THAT THE FILLER PIPE WAS FRACTURED AND CAUSED THE BLADDER TO LEAK. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE BLADDER AND FILLER NECK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
NHTSA ODI #11006421
Mileage unknown · Jul 17, 2017
Structure
THE REAR PASSENGER DOOR STOP CLOSING ....THE LATCH IS BROKEN ...THEY HAD A RECALL ON THIS IN 2005 BUT CLAIM IT'S CLOSE NOW WHAT CAN I DO?
NHTSA ODI #11006030
98,000 miles · Mar 27, 2017
Fuel/propulsion System
TL* THE CONTACT OWNS A 2003 GMC ENVOY XL. WHILE DRIVING 30 MPH, THE FUEL GAUGE FLUCTUATED AND FAILED TO PROPERLY DISPLAY THE AMOUNT OF FUEL IN THE TANK. THE LACK OF FUEL CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXI…
Read full complaint
TL* THE CONTACT OWNS A 2003 GMC ENVOY XL. WHILE DRIVING 30 MPH, THE FUEL GAUGE FLUCTUATED AND FAILED TO PROPERLY DISPLAY THE AMOUNT OF FUEL IN THE TANK. THE LACK OF FUEL CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
NHTSA ODI #10968654
138,000 miles · Dec 9, 2016
Air BagsCrashInjury
WHEN THE DRIVER SLID ON ICE AND CRASHED INTO A TREE, THE AIRBAG DID NOT DEPLOY AND THE DRIVER WAS INJURED
NHTSA ODI #10934028
Official recalls
3Oct 27, 2005
CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA.
Consequence & remedy
Consequence: IF THE DOOR IS NOT LATCHED PROPERLY AND IT GOES UNNOTICED, IT MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN UNBELTED OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.
Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence & remedy
Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE07014 · Fuel Tank Leak
Opened Mar 13, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE07013 · Fuel Pump Module Leaks Gasoline
Opened Mar 12, 2007 · Closed Jul 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI HAS UPGRADED THIS PE TO ENGINEERING ANALYSIS (EA07-009) TO FURTHER ASSESS THIS ISSUE.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04001 · Fuel Spillage During Refueling
Opened Jan 5, 2004 · Closed May 7, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Fuel System, Gasoline:storage
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Illustration