Exterior Lighting. Review the 159 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Engine complaints

14 reports

Clear category filter

Mileage unknown · Oct 13, 2025

Engine

Read full complaint

2024 GMC Canyon Elevation trim 4x4 with 31,000 miles on it always had maintenance every 5k interval. I noticed an upper radiator hose leak significant enough to require a decent amount of coolant and decided to take it in to GMC to get it repaired. Mind you this repair is almost $1,000 to get repaired with the hose itself only costing $148. It's disappointing to have such a new truck and have these kinds of problems and upon research there seems to be several others with the same problem relating to an O ring in the upper radiator hose. Considering the truck is routinely serviced more frequently than required I see this as an issue for someone to run out of coolant and possibly be stranded on the side of the road if gone unnoticed and needs to be properly addressed asap.

NHTSA ODI #11693216

Mileage unknown · Jul 10, 2025

Engine

Read full complaint

Propulsion of vehicle. Truck lost power as I was trying to pull into traffic at an intersection. Yes, it was confirmed by the dealer; truck was returned after 3 incidents. GM has been inspected the truck. Yes: check engine light immediately came on, and a comment then stated onscreen: "caution. Your vehicle has lost power and is operating at a reduced capacity". First occasion, truck was approx 6 months old. Second was 1 month later. Third and dangerous incident occurred June 11th 2025. Dealer keeps saying the truck is OK. Failure to propel keeps happening. Service supervisor tells me truck needs a new module, but GM won't approve it. Truck is still at the dealer, and issue has been escalated twice. Truck still at dealer.

NHTSA ODI #11672439

Mileage unknown · Feb 7, 2025

EngineUnknown Or Other

Read full complaint

Vehicle whole system was non existent. No interior lighting, no door chime when opened, no response. Mechanic took a look and found alternator not good. It’s not charging the battery and advised me to tow it to warranty repair shop. Advised me if I were driving and vehicle died I would not have power or control of vehicle and cause serious injury or death. Lucky I was parked at home and attempted to start vehicle to leave home. No repairs done yet, vehicle is still at home waiting for an appointment.

NHTSA ODI #11641415

Mileage unknown · Oct 30, 2024

Electrical SystemEngineExterior Lighting

Read full complaint

Where to begin... As I bought my first truck, literally within 10 days after buying the GMC Canyon 2024, the car is shaking uncontrollably on the highway... 35 MPH max speed, extremely dangerous situation, 8 AM on a busy Watterson Expressway in Louisville, KY. I was so scared I was going to crash and potentially get hurt or worse. They told me "they had never seen this happen to a Canyon before" which is obviously a lie. The car was serviced for 21 calendar days, and now my lights are spotty and I can't drive my car at night. I got this truck [XXX]. There was no communication on when it was to be ready. There are issues with a lot of minor things as well like the navigation systems. I have logged every call with the Dealership, Courtesy Buick GMC in Louisville as well as summarized every point of contact, and with very spotty responses and the manager, Frank, wont respond to my emails and was extremely uncooperative as I asked to trade it in as I was genuinely concerned about my safety and he told me absolutely not. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11622769

Official recalls

25V856000 · Air Bags: Air Bag/restraint Control Module:software; Air Bags:frontal:passenger Side:inflator Module

Dec 11, 2025

General Motors, LLC (GM) is recalling certain 2024–2026 GMC Canyon AT4X AEV vehicles. Incorrect sensing and diagnostic module (SDM) software may cause a second stage passenger air bag deployment when only a first stage is intended. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 208, “Occupant Crash Protection."

Consequence & remedy

Consequence: An air bag that deploys improperly increases the risk of injury in a crash.

Remedy: Dealers will update the SDM software, free of charge. Owner notification letters were mailed January 30, 2026. Owners may contact GMC customer service at 1-800-462-8782. GM's number for this recall is N252533510. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 11, 2025.

Additional source detail variants (2)

Air Bags:frontal:passenger Side:inflator Module

Consequence: An air bag that deploys improperly increases the risk of injury in a crash.

Remedy: Dealers will update the SDM software, free of charge. Owner notification letters were mailed January 30, 2026. Owners may contact GMC customer service at 1-800-462-8782. GM's number for this recall is N252533510. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 11, 2025.

Air Bags: Air Bag/restraint Control Module:software

Consequence: An air bag that deploys improperly increases the risk of injury in a crash.

24V673000 · Exterior Lighting:headlights

Sep 12, 2024

General Motors, LLC (GM) is recalling certain 2024 GMC Canyon vehicles. The headlights may flicker while driving and while the vehicle is in park. As such, these vehicles fail to comply with the requirements of Federal Motor Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: Headlights flickering can reduce visibility, increasing the risk of a crash.

Remedy: Dealers will replace a module in the headlight, free of charge. Owner notification letters were mailed October 10, 2024. Owners can contact GMC customer service at 1-800-462-8782. GM's number for this recall is N242468880.

24V491000 · Fuel System, Gasoline:delivery:fuel Pump:mounting Plate/flange; Fuel System, Gasoline:storage:tank Assembly

Jun 28, 2024

General Motors, LLC (GM) is recalling certain 2024 Chevrolet Colorado and GMC Canyon vehicles. The lock ring that secures the fuel pump to the fuel tank assembly may not have been fully locked during assembly, which can result in a fuel leak during a crash.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect and fully lock the fuel tank lock ring as necessary, free of charge. Owner notification letters are expected to be mailed August 13, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC Customer Call Center at (888) 988-7267. GM's number for this recall is N242451330.

Additional source detail variants (2)

Fuel System, Gasoline:delivery:fuel Pump:mounting Plate/flange

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect and fully lock the fuel tank lock ring as necessary, free of charge. Owner notification letters are expected to be mailed August 13, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC Customer Call Center at (888) 988-7267. GM's number for this recall is N242451330.

Fuel System, Gasoline:storage:tank Assembly

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA26006 · Electronic Brake Module Component Failure

Opened Aug 21, 2026 · No close date supplied

Status: open (inferred from source dates) · Service Brakes

On April 11, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24011 after receiving complaints concerning a loss of brake assist in 2023 MY Cadillac Lyriq vehicles. These complaints allege a hard brake pedal, followed by a “Brake System Failure” message at start up or while driving. GM shared records regarding several internal investigations for loss of brake assist due to alleged spindle fractures in the eBoost system. GM has stated that in the event of a spindle fracture, anti-lock brakes (ABS), stability control, and traction control remain functional until the vehicle comes to a complete stop. At this point, ABS, brake assist, stability control, and traction control functions are lost. The loss of these functions causes the vehicle to set one of three Diagnostic Trouble Codes (DTCs) based on failed performance criteria for the Electronic Brake Control Module (EBCM). These DTCs, in turn, activate several driver alerts: an audible chime, a visual “Service Brake System” message in the display, and multiple illuminated Malfunction Indicator Lights (MILs) for the ABS, Traction Control, and Brakes informing the driver of loss of functionality. The vehicle speed will also be limited to 70 KPH (43 MPH). Since opening PE24011, ODI has continued to receive reports of loss of brake assist. Some of these reports describe symptoms inconsistent with GM’s description of a spindle failure. These reports allege an immediate loss of brake assist functionality as opposed to the loss occurring after the vehicle comes to a complete stop. The sudden loss of brake assist during a braking event could result in extended braking distance, which increases the risk of a crash or injury. ODI believes further analysis is necessary to assess the potential for failures in GM’s eBoost system to resulting in safety-related outcomes. At this time, ODI is aware of the following vehicles that are equipped with this eBoost system: 2023-2026 MY Cadillac Lyriq, Chevrolet Colorado, and GMC Canyon; 2024-2026 MY Buick Enclave, Envision; Chevrolet Blazer EV, Equinox EV, Traverse; Cruise Origin; and GMC Acadia; 2025-2026 MY Cadillac Celestiq and Optiq. ODI is also aware of 2024-2026 MY Acura ZDX and 2024-2026 MY Honda Prologue vehicles that were built with this system. The Acura and Honda vehicles were manufactured by GM in a joint venture with Honda, and will be included in the Engineering Analysis as peer vehicles. ODI is opening this Engineering Analysis to further assess the safety-related consequences of a failed eBoost system. In addition, ODI is expanding the scope of the investigation to encompass all GM vehicles that share this eBoost system. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.