2021 Forest River Cherokee

Tire size was ST 205 / 75 R 15. This tire experienced a significant belt separation failure that I fortunately noticed before departing our campsite. While doing a walk around inspection before departure, I noticed a severe tread deformity in the front passenger side tire on our camper. The tires were cold and the ambient air temperature was in the low 60's. Before removing the tire and wheel from the trailer, I checked the tire pressure on all 4 tires, and all were within 2 psi of the recommended 65 psi cold pressure, including the failing tire. I removed the wheel and tire assembly and deflated it for safety, and then took it to a local tires shop to replace the tire. They diagnosed it as belt separation and further stated that it would have likely failed with a blowout within a few miles if I hadn't caught it. The tire had an estimated 15,000 miles on it at the time, but had been professionally repaired for a screw puncture approximately 7,000 miles earlier.

ST 225/75R15 One driver side tire blew in May/2025 which caused extensive damage to the RV floor and sidewall. I replaced and did not file a claim. My family was in the tow vehicle when the blowout occurred. Debris was thrown across the highway and I had no room on the side of the highway to change the tire. Police called. Yesterday July 14/2025, the spare tire blew up all on its own while at a campground. It was on the back of the camper not being used. The spare tire cover was destroyed. Neighbors thought a propane tank exploded. Anybody walking by could have been seriously injured. I did a search and found a recall for these tires.

Castle Rock ST225/75r15 Was traveling with a 2021 Forest River RV and had a rapid loss of tire pressure and complete tread separation. Tires were at the proper pressure and driving below the speed rating of 70 mph. Incident occurred about an hour into trip, but less than 15 minutes after a stop and check of tires. Even a flat or picking up something in the road should not cause a full scale tread separation. These are just poorly made tires. No symptoms of problems, just a cheap tire.

Shortly after buying the camper used in April of 2024 on the way home I had a tire blow out going about 60-65 miles. Date code of tire is 1520. The tire tread looked good and confirmed correct amount of tire psi before leaving the dealership with salesman. While camper was parked, resting on 2x6 boards, not sitting directly on the ground. Where the tire was touching the board the tread completely split open. Date code also 1520.

This is a summary of 2 passenger side tire failures: First tire failure: On August 29, 2023 I packed up my Forest River Cherokee Black Label travel trailer in Perry, FL and relocated it to Tallahassee, FL. On the way to Tallahassee on Highway 27 maybe a mile east of Capps, Fl noticed some tire debris behind me in side mirrors. My girlfriend was following me, called and alerted me something appeared to be wrong and tire and other debris was coming off the bottom right side of the coach. I was unable to pull over immediately due to traffic safety concerns and lack of side lane for parking. I was able to park at Hwy 19 to I-10 exit at Capps, where assessed the situation. The tire and rim was totally destroyed along with parts of the wheel well and skirt. I was able to install the spare wheel and continue to Tallahassee. Prior to moving the coach, I verified air pressure in all tires based on the side wall ratings using tire gauge and portable air compressor. My speed was between 45mph and 55mph. Second tire failure: This happened at Camping World repair shop around September 28, 2023. Tire failure was on the same side as the previous one, right side of coach. I was told the tire spontaneously exploded without any signs of tire failure prior. As far as I know, there were no changes in air pressure or modifications to the wheel. The wheel had been removed and inspected prior during axle maintenance. I was told immediately after the the incident, they reduced air pressures on the remaining wheels for safety concerns. Tires had no more than 2,000 miles and regularly checked inflation, travelling and parked. I bought the coach new in 2022 and never noticed any tire rot, bulging or other or damage. I’m not confident remaining tires or replacements using Castle Rock products are safe and I am having all 4 tires replaced with brand new steel belted "G" rated tires fro reputable MFG. These incidents have cost me thousands of dollars in repairs. I contacted L