2002 Ford Thunderbird

The contact owns a 2002 Ford Thunderbird. The contact stated that while driving approximately 15 MPH and making a left turn, the power steering suddenly failed and the steering wheel would not turn in either direction, before the vehicle suddenly stalled. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure but no assistance was offered. The failure mileage was 70,000.

1ST HAD TO HAVE 8 COILS REPLACED ,2002 NOT COVERED ON RECALL, BUT 2003 AND AFTER WERE. YESTERDAY HAD TO HAVE IT TOWED TO A FORD DEALER, CAR WOULD NOT START. AFTER A DIAGNOSIS, FOUND THE FUEL PUMP NEEDED REPLACED AND FUEL FILTER. THE COST WAS $1500.00. THERE WERE 4 OTHER T-BIRDS THERE PLUS MINE WITH THE SAME PROBLEM. WHAT NEXT? DO I NEED A TOW TRUCK TO FOLLOW ME ALL THE TIME.

TL* THE CONTACT OWNS A 2002 FORD THUNDERBIRD. WHILE DRIVING 60 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE VEHICLE BEGAN IDLING ROUGHLY. THE VEHICLE WAS TAKEN TO AN AUTO PARTS STORE WHERE THE EMPLOYEE FOUND THAT CYLINDERS 3, 4, AND 7 WERE MISFIRING, AS WELL AS A RANDOM MISFIRE. THE CONTACT OPENED THE SPARK PLUG WELL AND OPENED THE COIL PACK. THE CONTACT DISCOVERED THAT THE SPARK PLUG AND COIL PACK WERE COVERED IN OIL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT LATER SPOKE TO A DEALER WHO STATED THAT THEY WOULD COME PICK UP THE VEHICLE IF THE CONTACT DECIDED TO HAVE IT SERVICED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THEY COULD NOT ASSIST SINCE THERE WAS NO RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 31,000.

TL* THE CONTACT OWNS A 2002 FORD THUNDERBIRD. WHILE DRIVING ON THE HIGHWAY, THE VEHICLE LUNGED FORWARD AND STOPPED ACCELERATING. THE VEHICLE INDEPENDENTLY BEGAN TO OPERATE NORMALLY AFTERWARDS; HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED THAT THE VEHICLE WOULD NOT OPERATE PAST APPROXIMATELY 35 MPH. AFTER THE FAILURE RECURRED, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE COIL ON PLUG WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE TECHNICIAN DIAGNOSED THAT ALL EIGHT VEHICLE COIL ON PLUGS NEEDED TO BE REPLACED EVENTUALLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 30,000.

TL* THE CONTACT OWNS A 2002 FORD THUNDERBIRD. WHILE DRIVING AT 60 MPH, THE VEHICLE BEGAN TO DRIVE ABNORMALLY WHILE THE MISFIRED WARNING LIGHT ILLUMINATED. THE CONTACT COULD NOT DESCRIBE THE FAILURE IN GREAT DETAIL. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE VALVE COVER GASKET AND COIL PACK FAILED AND NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED TWICE, BUT THE FAILURE WAS PERSISTENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000.

TL* THE CONTACT OWNS A 2002 FORD THUNDERBIRD. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE NUMBER 8 COIL AND SPARK PLUG NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.

RE:2002 FORD THUNDERBIRD AT 43,237 MILES THE ENGINE SUDDENLY BEGAN RUNNING ROUGH AND MISFIRING.THE PASSENGER AREA IMMEDIATELY BEGAN TO FILL WITH EXHAUST FUMES. THE CHECK ENGINE LIGHT ILLUMINATED BUT DID NOT FLASH TO INDICATE A SERIOUS PROBLEM. UPON LETTING THE TOP DOWN THE VEHICLE WAS SLOWLY DRIVEN TO A NEARBY FORD DEALERSHIP. THE CYLINDER EIGHT COIL AND SPARK PLUG WERE REPLACED WHICH SEEMED TO SOLVE THE PROBLEM. AT 45,280 MILES THE SAME SITUATION OCCURRED AND THE CYLINDER SIX COIL AND SPARK PLUG WERE REPLACED. AT 47,459 MILES THE SAME THING OCCURRED YET AGAIN AND CYLINDER COILS TWO AND THREE WERE REPLACED AS WELL AS FOUR SPARK PLUGS. DESPITE THE COST INVOLVED IN THE NECESSARY REPAIR WORK AND THE FACT THAT ALL OF THE ABOVE INCIDENTS OCCURRED WELL WITHIN THE MILEAGE OF AN EXTENDED WARRANTY I MAINTAINED THROUGH FORD MOTOR COMPANY, THE COMPANY ADVISED THAT THE TIME LIMIT ON MY EXTENDED WARRANTY HAD EXPIRED AND THE COMPANY IS NOT WILLING TO REPLACE THE REMAINING CYLINDER COILS AND SPARK PLUGS. I DO NOT KNOW IF THERE HAVE BEEN CARBON MONOXIDE POISONING AS A RESULT OF THE PASSENGER AREA FILLING WITH EXHAUST FUMES WHEN THE ENGINE BEGINS RUNNING ROUGH. I DO KNOW HOWEVER THAT WHEN AN ENGINE BEGINS MISFIRING, RAW GASOLINE POURS INTO THE COMBUSTION SYSTEM AND COULD CAUSE A FIRE, I ALSO KNOW THAT CARBON MONOXIDE IF NOT DETECTED QUICKLY CAN BE FATAL TO HUMAN BEINGS. I DO NOT BELIEVE THE ABOVE INCIDENTS ARE NECESSARILY A WARRANTY ISSUE. THEY ARE HOWEVER A HEALTH AND SAFETY ISSUE. THIS PROBLEM APPEARS TO BE SYSTEMIC IN NATURE AND RELATED TO DESIGN PROBLEMS OF THE 3.9L V8 ENGINE UTILIZED IN THE 2002 FORD THUNDERBIRD. I RECOMMEND THAT FORD MOTOR COMPANY RECALL THE 2002 FORD THUNDERBIRD AND REPLACE ALL COILS AND SPARK PLUGS WITH RELIABLE PARTS AS I HAVE BEEN ADVISED BY A FORD SERVICE EMPLOYEE THAT THE REPLACEMENT COILS SOMETIMES FAIL AND MUST BE REPLACED A SECOND TIME. *TR

DRIVING 45 TO 50 MPH, ENGINE STARTS CUTTING OUT, RUNNING ROUGH. CHECK ENGINE LIGHT STARTS FLASHING WHICH REQUIRED THE COIL PACK TO BE REPLACED BY FORD. THIS IS A CONSTANT ISSUE WITH THIS MODEL AND YEAR FORD THUNDERBIRD. IT IS AN EXPENSIVE REPAIR AND YET FORD HAS NOT REDESIGNED THE COIL PACK FOR THIS CAR AND THE COIL PACK CONTINUES TO FAIL TIME AND TIME AGAIN. I'M JUST GRATEFUL THAT I WAS NOT ON SOME REMOTE HIGHWAY STRANDED ON THE SIDE OF THE ROAD WHEN THIS HAPPENED OR TRYING TO PASS ANOTHER VEHICLE. I CONSIDER THIS A SAFETY ISSUE. WHY THE 2002 THUNDERBIRD COIL, SPARK PLUGS AND CONNECTORS WERE NOT COVERED UNDER THE RECALL OF THE 2003-5 IS BEYOND ME. FORD DID AN INJUSTICE TO 2002 OWNERS OF THE THUNDERBIRD BY NOT ACCEPTING THAT THEY HAD AN ISSUE WITH THE CAR AND I WOULD LIKE TO SEE THIS ISSUE REMEDIATED. *TR