IllustrationWHILE DRIVING ON THE HIGHWAY WHITE SMOKE CAME FROM UNDER THE HOOD, AND CONSUMER WAS NOT ABLE TO SEE. CONSUMER WAS TOLD THAT IS WAS A BLOWN HEAD GASKET. *AK *ML
1993 Ford Thunderbird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Thunderbird years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 14 of 423 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports7 fire reports6 injury reports
What owners actually said
423 reportsNO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
WHILE DRIVING AT NIGHT PUSHED THE DIMMER SWITCH TO PUT ON BRIGHT LIGHTS, AND HEADLIGHTS WENT TOTALLY OFF. CONSUMER DID NOT HAVE ANY LIGHT. *AK
NO SUMMARY LISTED FRO ABOVE VEHICLE. *AK
NEWER VEHICLES WITH SIMILAR ENGINES HAVE HAD WARRANTY EXTENSIONS TO COVER THIS REPAIR. WHY IS THIS MAKE/MODEL WITH SAME ENGINE NOT BEING COVERED? *AK
HEADGASKET BLEW, CAUSING VISIBILILTY PROBLEM.FORD REFUSES TO INCLUDE THUNDERBIRDS IN ITS HEADGASKET RECALL.*AK
CONSUMER RECEIVED RECALL NOTICE 99V275000/ HEADLIGHTS, AND FOUND OUT FROM DEALER THAT PART NEEDED TO BE REPLACED WASN'T COVERED UNDER RECALL. CONSUMER HAS REPAIRED THE PROBLEM ONCE BEFORE OUT OF HIS OWN POCKET. *AK
RECALL 99V275/ HEADLIGHT SWITCH. DEALER HAS REPAIRED VEHICLE UNDER RECALL AND REMEDY HAS FAILED. THE DEALER HAS REINSPECTED VEHICLE, AND WILL REPAIR IT AGAIN AT THE OWNER'S EXPENSE. MANUFACTURER HAS BEEN NOTIFIED. *AK
AUTOMATIC SHOULDER BELT ON DRIVER'S SIDE WAS STUCK IN OPEN POSITION. PROBLEM WAS REPORTED TO THE MANUFACTURER. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
BLOWN HEAD GASKETS TWO TIMES. 1ST TIME AT 57K - 2ND TIME AT 105K. *AK
Official recalls
399V275000 · Exterior Lighting:headlights:switch
Oct 12, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING.
Consequence & remedy
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED.
97V159000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Sep 22, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE.
Consequence & remedy
Consequence: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.
96V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA99005 · Headlight Switch
Opened Jan 20, 1999 · Closed Dec 14, 1999
Status: closed (inferred from source dates) · Exterior Lighting
SUBJECT VEHICLES HAVE A HEADLIGHT SWITCH WITH AN INTERNAL, BIMETAL CIRCUIT BREAKER THAT CAN OPEN DUE TO OVERHEATING DURING HEADLING OPERATION.
RQ98015 · Headlight Circuit Breaker
Opened Sep 29, 1998 · Closed Jan 22, 1999
Status: closed (inferred from source dates) · Exterior Lighting:headlights:switch
HEADLIGHT SWITCH WITH AN ITERNAL, BIMETAL CIRCUIT BREALER THAT MAY OPEN DUE TO OVERHEATING DURING HEADLIGHT OPERATION
RQ97011 · Fuel Line Jumper
Opened Sep 25, 1997 · Closed Nov 16, 1998
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
TO DETERMINE THE SCOPE OF THE ALLEGED FUEL LINE FAILURES OUTSIDE OF THE RECALL GEOGRAPHIC REGION AND IF THE RECALL SHOULD BE EXPANDED NATIONALLY