IllustrationHEAD LAMP COVERS TURNED YELLOW. AS TIME HAS PASS HEADLIGHTS GAVE POOR VISIBILITY. CONSUMER HAD TO TRAVEL WITH BRIGHT LIGHTS TO GAIN VISIBILITY. PLEASE PROVIDE FURTHER INFORMATION.*AK
1993 Ford Thunderbird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Thunderbird years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 14 of 423 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports7 fire reports6 injury reports
Exterior Lighting complaints
119 reportsHEADLIGHT REFLECTORS BURNED OUT. DEALER ADVISED THAT ENTIRE LIGHTING SYSTEM WILL HAVE TO BE REPLACED. DEFECT CAUSES BAD VISION AT NIGHT. *AK
DASH HEADLIGHT SWITCH WAS REPLACED IN JUNE OF 2000 DUE TO RECALL BY FORD. APPROXIMATELY 1 YEAR LATER REPLACEMENT SWITCH FAILED FOR SAME REASON ORIGINAL SWITCH WAS RECALLED FOR. BURNED CONTACTS WERE FOUND ON THE BACK OF THE REPLACEMENT SWITCH. SEEMS AS IF SWITCH USED FOR REPLACEMENT IS NO BETTER THAN ORIGINAL SWITCH RECALLED.
LENS ASSEMBLY FOR LOW BEAM HEADLIGHTS HAS DETERIORATED, TURNING CLOUDLY YELLOW, THIS HAS RESTRICTED THE LIGHT FROM THE LOW BEAM PER NIGHT DRIVING, WHICH IS A SERIOUS LOSS OF VISIBILITY . MY DEALER WILL NOT PASS THE CAR UPON INSPECTION DUE TO THE LOSS OF LIGHT . THE HEADLIGHT ASSEMBLY UNITS NEED TO BE REPLACED AT ONCE. *AK
HEADLIGHT SWITCH HAD TO BE REPLACED. LIGHTS ARE VERY DIM. *AK
LOW BEAM LIGHTS ARE INOPERABLE. DEALER HAS REPLACED HEADLIGHT FUNCTION SWITCH, HOWEVER PROBLEM HAS NOT BEEN CORRECTED.*AK
RECALL 99 V 275 00/HEADLIGHTS: IN FEBRUARY 1998 CONSUMER HAD REPAIRS DONE. IN 1999, A MANUFACTURER'S RECALL NOTICE WAS RECEIVED, AND A REIMBURSEMENT WAS GIVEN. PRESENTLY, PROBLEM HAS REOCCURRED. DEALER AND MANUFACTURER WERE NOTIFIED OF PROBLEM, AND REFUSED TO HELP IN THIS MATTER. FEEL FREE TO PROVIDE ANY FURTHER DETAILS …
Read full complaint
RECALL 99 V 275 00/HEADLIGHTS: IN FEBRUARY 1998 CONSUMER HAD REPAIRS DONE. IN 1999, A MANUFACTURER'S RECALL NOTICE WAS RECEIVED, AND A REIMBURSEMENT WAS GIVEN. PRESENTLY, PROBLEM HAS REOCCURRED. DEALER AND MANUFACTURER WERE NOTIFIED OF PROBLEM, AND REFUSED TO HELP IN THIS MATTER. FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
THE CONSUMER DOES NOT WANT TO TAKE THE VEHICLE TO THE DEALER FOR RECALL REPAIR 99V-275 BECAUSE OF PROBLEMS EXPERIENCED WITH THE DEALER ON PREVIOUS OCCASION, THE CONSUMER WANTS PERMISSION TO TAKE THE VEHICLE TO A MECHANIC. NLM
CONSUMER RECEIVED HEADLIGHT RECALL 99V275000/ MANUFACTURER'S RECALL 99S30 . HEADLIGHTS ARE BLINKING OFF/ON, STILL HEADLIGHTS HAVE TO BE USED JUST TO SEE SOMETIMES. CONSUMER HASN'T TAKEN VEHICLE BACK BECAUSE OF THE TREATMENT AT DEALERSHIP. BUT, CONSUMER WILL CONTACT MANUFACTURER TO RECTIFY PROBLEM.*AK
MULTI-FUNCTION SWITCH SHORTED AND CAUGHT ON FIRE . VEHICLE IS INCLUDED UNDER RECALL FOR HEADLIGHT SWITCH; HOWEVER THIS PART IS NOT INCLUDED UNDER REMEDY OF RECALL.
Official recalls
399V275000 · Exterior Lighting:headlights:switch
Oct 12, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING.
Consequence & remedy
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED.
97V159000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Sep 22, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE.
Consequence & remedy
Consequence: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.
96V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA99005 · Headlight Switch
Opened Jan 20, 1999 · Closed Dec 14, 1999
Status: closed (inferred from source dates) · Exterior Lighting
SUBJECT VEHICLES HAVE A HEADLIGHT SWITCH WITH AN INTERNAL, BIMETAL CIRCUIT BREAKER THAT CAN OPEN DUE TO OVERHEATING DURING HEADLING OPERATION.
RQ98015 · Headlight Circuit Breaker
Opened Sep 29, 1998 · Closed Jan 22, 1999
Status: closed (inferred from source dates) · Exterior Lighting:headlights:switch
HEADLIGHT SWITCH WITH AN ITERNAL, BIMETAL CIRCUIT BREALER THAT MAY OPEN DUE TO OVERHEATING DURING HEADLIGHT OPERATION
RQ97011 · Fuel Line Jumper
Opened Sep 25, 1997 · Closed Nov 16, 1998
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
TO DETERMINE THE SCOPE OF THE ALLEGED FUEL LINE FAILURES OUTSIDE OF THE RECALL GEOGRAPHIC REGION AND IF THE RECALL SHOULD BE EXPANDED NATIONALLY