THIS IS THE RECALL. MY CAR DID EXACTLY THIS. MY CAR IS A 93 THUNDERBIRD SUPER COUPE WITH FACTORY FOG LIGHTS AND THE WIRING HARNESS CONNECTOR IS BURNT AND NEEDS REPLACED. HEADLIGHTS WENT OUT AFTER FLICKERING. RECALLS FOR THE 1993 FORD THUNDERBIRD ELECTRICAL & LIGHTS: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH CAMPAIGN NUMBER: 99V27…
Read full complaint
THIS IS THE RECALL. MY CAR DID EXACTLY THIS. MY CAR IS A 93 THUNDERBIRD SUPER COUPE WITH FACTORY FOG LIGHTS AND THE WIRING HARNESS CONNECTOR IS BURNT AND NEEDS REPLACED. HEADLIGHTS WENT OUT AFTER FLICKERING. RECALLS FOR THE 1993 FORD THUNDERBIRD ELECTRICAL & LIGHTS: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH CAMPAIGN NUMBER: 99V275000 DATES MANUFACTURED: 06/1991 TO 09/1993 NUMBER OF VEHICLES AFFECTED: 164,731 MODEL YEARS AFFECTED: 1992, 1993 DATE OWNER NOTIFIED: 11/1999 DEFECT SUMMARY: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING. CONSEQUENCE SUMMARY: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH. CORRECTIVE SUMMARY: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED. RECALL NOTES: FORD RECALL NO. 99S30.OWNER NOTIFICATION BEGAN NOVEMBER 15, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236). *TR
NHTSA ODI #10327593
Mileage unknown · Oct 17, 2008
Exterior Lighting
1993 FORD THUNDERBIRD WITH HEADLIGHTS THAT FAIL WHILE DRIVING AT NIGHT. FAILURE STARTS WITH FLICKERING AND BLINKING CAUSING LOSS OF VISIBILITY. *TR
NHTSA ODI #10245758
Mileage unknown · Nov 30, 2005
Exterior Lighting
DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 99V275000 CONCERNING THE HEADLIGHTS:SWITCH. THIS VEHICLE HAD THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT WAS NOT INCLUDED IN THE RECALL DUE TO VIN. THE CONSUMER FIRST EXPERIENCED THIS PROBLEM IN LATE 1997, AND HAD IT REPAIRED AT THE HER EXPENSE. THE HEADLIGHTS F…
Read full complaint
DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 99V275000 CONCERNING THE HEADLIGHTS:SWITCH. THIS VEHICLE HAD THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT WAS NOT INCLUDED IN THE RECALL DUE TO VIN. THE CONSUMER FIRST EXPERIENCED THIS PROBLEM IN LATE 1997, AND HAD IT REPAIRED AT THE HER EXPENSE. THE HEADLIGHTS FAILED A SECOND TIME THE DEALERSHIP STATED THE SWITCH NEEDED TO BE REPLACED AGAIN.*AK UPDATED 01/11/06. *JB
NHTSA ODI #10144017
Mileage unknown · Jan 11, 2005
Exterior Lighting
WHILE DRIVING SMOKE STARTED TO COME OUT OF THE STEERING COLUMN, AND THE HEADLIGHT STOPPED WORKING. CONSUMER STATES IT IS THE VERY SAME PROBLEM AS RECALL NUMBER 99V275000/HEADLIGHTS.*AK
NHTSA ODI #10107160
120,000 miles · Jul 6, 2004
Exterior Lighting
WHILE DRIVING AT NIGHT HEAD LIGHTS FLASHED ON AND OFF. DEALER STATED THEATHEAD LIGHT SWITCH MALFUNCTIONED. *AK
NHTSA ODI #10081373
112,000 miles · Apr 29, 2004
Exterior LightingUnknown Or Other
WHILE DRIVING AT NIGHT, HEADLIGHTS SUDDENLY WENT OUT. SMOKE BEGAN TO COME FROM THE STEERING COLUMN NEAR THE SIGNAL LIGHT. CONSUMER PULLED OVER, THEN SMOKE CLEARED, BUT THE DRIVER HAD TO HOLD THE HIGH BEAM SWITCH WHILE DRIVING. *AK *LA
NHTSA ODI #10061601
Mileage unknown · Jul 14, 2003
Exterior Lighting
CONSUMER STATES THAT HEADLIGHTS ARE NOT WORKING PROPERLY. DEALER NOTIFIED. *AK
NHTSA ODI #10027212
140,786 miles · Jun 3, 2003
Exterior Lighting
THE VEHICLE HEAD LAMPS FLICKERED PRIOR TO RECALL NOTICE (99S30). THE CONSUMER REQUEST REIMBURSEMENT FOR THE REPLACED SWITCH. *MR *SCC *NLM
NHTSA ODI #10021557
Mileage unknown · Nov 19, 2002
Exterior Lighting
WHILE TRAVELING ON THE HIGHWAY WITHOUT PRIOR WARNING. THE HEADLIGHT WILL GO OFF AND THE FOG LIGHT WILL STAY ON. PLEASE FILL IN ADDITIONAL INFORMATION. DEALER IS AWARE OF THE PROBLEM.TS
NHTSA ODI #8023011
Mileage unknown · Aug 26, 2002
Exterior Lighting
WHILE SWITCHING TO HIGH BEAM, HIGH AND LOW BEAMS GO OUT. *AK *SCC
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING.
Consequence & remedy
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE.
Consequence & remedy
Consequence: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.
Illustration