1997 Ford Taurus Sho

TL*THE CONTACT OWNS A 1997 FORD SHO TAURUS. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH IN REVERSE WHEN THE FRONT COIL SPRING BROKE AND SHREDDED THE TIRE. THE CONTACT STATED THAT A RECALL FOR THE 1998 TO 2001 FORD TAURUS IS DIRECTLY RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS 139000. UPDATED 02/02/10. *LJ UPDATED 02/05/10.*JB

VEHICLE DESCRIPTION: 1997 FORD TAURUS SHO FORD (FMC) HAS ACKNOWLEDGED IN WRITING THAT THE PROBLEM IS MANUFACTURER RELATED, WHICH STEMS FROM THE YAMAHA MANUFACTURED ENGINE USED IN SHO MODELS. THE VEHICLE WOULD ROUGH IDLE AFTER 20 MINS. ON THE ROAD, SHAKE AGGRESSIVELY, THEN SHUT-OFF FOR DAYS AT A TIME IN UNPREDICTABILITY. AN AUTHORIZED FMC REPAIR CENTER (MLM) SPENT OVER 3-MOS, CONCURRENTLY, WORKING ON THE VEHICLE TO NO AVAIL. SEE 03/01. THE VEHICLE FUNCTIONED IN THIS MANNER FROM 11/00 (MM/YY) THROUGH 04/03, AT WHICH TIME I WAS LEFT WITH NO OTHER FISCALLY-VIABLE OPTION BUT TO ARRANGE TO HAVE THE VEHICLE RETURNED TO FMC- FMC WOULD TAKE NO RESPONSIBILITY AND PLACE A 7YEAR "REPOSSESSION" STAIN ON WHAT USED TO BE A GREAT CREDIT SCORE. TIMELINE: BETWEEN 11/00 (MM/YY) AND 01/01, CONTINUED CALLS WERE PUT INTO FMC REGARDING MY "SHO" VEHICLE. THE CAR WOULD SHAKE AGGRESSIVELY, THEN SHUTDOWN IN MID-TRAVEL. 01/01: I WAS TOLD TO TAKE THE VEHICLE TO MLM. AFTER DESCRIBING THE ISSUE, I WAS TOLD IT WOULD COST $2,200 TO SERVICE THE PROBLEM(S). 03/01: THE ISSUES WITH THE VEHICLE WERE SO SEVERE; MLM REQUESTED THAT FMC SEND OUT A "FIELD SERVICE ENGINEER" TO ASSIST THEM. AFTER A WEEK FMC ADMITTED, WHICH WAS DOCUMENTED BY MLM IN WRITING, THAT FMC HAS HAD "SIMILAR PROBLEMS" WITH "OTHER SHOS IN THE FIELD" AND HAD "NO POSITIVE FIX FOR THEM." THIS SUGGESTS THAT FMC KNEW OF THE SHO'S PROBLEMS AND HAVE PURPOSEFULLY FAILED/REJECTED TO AID THE VICTIMS AFFECTED. WHILE OPERATING THE VEHICLE, MY PASSENGERS AND I WOULD BE PLACED AT TRAGIC AND UNNECESSARY RISKS, AS THE VEHICLE WOULD SHUT-DOWN W/O WARNING- LOCKING UP THE STEERING AND CAUSING ME TO ENGAGE IN "ERRATIC" (AT TIMES) AND "PRECAUTIONARY DRIVING MANEUVERS" WHILE ON PUBLIC ROADS IN ORDER TO REGAIN SOME CONTROL OF THE VEHICLE AND SAFELY STEER TO THE SIDE OF THE ROAD OR HIGHWAY. THIS PROVES MALICIOUS INTENT AND DECEPTIVE PRACTICES PERPETRATED BY FMC. IT ALSO PROVES A FORMED PATTERN. WB *TR

THERE WAS A CHAIN LIKE TICKING NOISE COMING FROM THE ENGINE, I AS A TECHNICIAN OBSERVED IT TO BE A CAMSHAFT GETTING READY TO FAIL, WHEN IT FAILED MY PREGNANT WIFE WAS DRIVING LUCKILY ON A SIDE ROAD WHERE THE VEHICLE HAD LOST ALL POWER AND MAKING IT NEARLY IMPOSSIBLE TO STEER, NOW THE 1997 SHO JUST SITS B/C I CAN NOT AFFORD THE EXPENSIVE REPAIRS! ESPECIALLY WITH A BABY ON THE WAY. *JB

THE SERVICE ENGINE LIGHT STAYS ON HAS BEEN ON FOR FEW MONTHS. CAR SEEMS TO RUN OK BUT CAN NOT GET CAR INSPECTED BECAUSE OF THE SERVICE ENGINE LIGHT. TOOK THE CAR TO AUTO ZONE THEY DID A DIAGNOSIS AND SAID THERE WHERE TWO CODES THAT CAME UP AS A FAILURE. I READ ON YOUR WEB SITE THAT THERE HAD BEEN A RECALL IN DEC. 2001 ON THE DIAGNOSTIC SYSTEM UPGRADE. *JB

ON DECEMBER 21, 2004 MY 1997 FORD TAURUS SHO BEGAN MAKING A TICKING NOISE. TWO DAYS (AND ABOUT 20 MILES) LATER, THE LEFT EXHAUST CAMSHAFT SPROCKET FAILED, CAUSING THE CAR TO STALL AND NOT RESTART. AS A RESULT OF THE SPROCKET SLIPPING, THE NO. 5 CYLINDER'S PISTON WAS CRACKED DUE TO COMING IN CONTACT WITH AN OPEN VALVE (THIS IS AN INTERFERENCE ENGINE). 15,000 MILES AGO, THE LEFT INTAKE CAMSHAFT SPROCKET FAILED, RESULTING IN A $2900.00 REPAIR BILL FROM A FORD DEALERSHIP. UNABLE TO AFFORD THE COST OF SUCH A REPAIR AT THIS TIME (NOT TO MENTION UNWILLING TO DEAL WITH THE SAME FORD CUSTOMER SERVICE THAT WANTED ME TO BELIEVE THAT THIS HARDLY EVER HAPPENS AND THAT I MUST HAVE DONE SOMETHING TO CAUSE IT THE FIRST TIME), I OPTED TO ATTEMPT THE PROCEDURE MYSELF. AFTER FINDING AND REMOVING THE FAULTY CAMSHAFT, I THOUGHT MY PROBLEMS WERE SOLVED UNTIL I CHANGED THE SPARK PLUGS. THE NO. 5 CYLINDER PLUG WAS COVERED IN OIL, WHICH MEANS THERE IS A BAD PISTON/RING, AND MOST LIKELY VALVES. I AM CONSIDERING MY OPTIONS TO REPAIR OR PART THE CAR OUT NOW. I BELIEVE THIS NEEDS TO BE ADDRESSED IMMEDIATELY BY FORD DUE TO THE SAFETY ISSUES THAT WILL ARISE WHEN THIS HAPPENS TO SOMEONE ON A FREEWAY. THE LOSS OF POWER BRAKES AND STEERING THAT ARE ASSOCIATED WITH A STALLED ENGINE COULD MAKE IT DIFFICULT TO MANEUVER THROUGH TRAFFIC TO A "SAFE" SPOT ON THE SHOULDER. THERE IS QUITE A BIT OF INFORMATION ON THIS ISSUE AT WWW.V8SHO.COM (IT'S INTERESTING TO SEE SO MANY REGISTERED FAILURES WITHOUT THE ACKNOWLEDGEMENT OF A PROBLEM BY FORD). *JB

VEHICLE QUIT RUNNING IN THE MIDDLE OF TRAFFIC. ENGINE LIGHT CAME ON AND VEHICLE SHUT DOWN JUST AVOIDING AN ACCIDENT ON A BUSY 55MPH HIGHWAY. COULD HAVE CAUSED A MAJOR ACCIDENT FOR MY 17 YEAR OLD INEXPERIENCED DRIVER. PUSHED VEHICLE OUT OF TRAFFIC, AND HAD VEHICLE TOWED TO MY REPAIR SHOP. VEHICLE HAD JUST OVER 100,000 MILES. WAS TOLD VEHICLE WAS ONLY RUNNING ON 5 OF 8 CYLINDERS. AFTER EXTENSIVE DIAGNOSIS, IT WAS DETERMINED TO THAT THE ENGINE CAM GEAR BROKE LOOSE THAT OPENS UP THE VALVE TO THE NUMBER 1 CYLINDER. MAJOR DAMAGE TO THE HEAD AND THE EXHAUST VALVES. SPENT ALMOST 3000.00 DOLLARS TO HAVE ALL REPAIRS MADE TO THE MOTOR. SOMEONE COULD HAVE BEEN SERIOUSLY HURT WHEN THE CAR ABRUPTLY SHUTS OFF IN THE MIDDLE OF TRAFFIC. PLEASE HAVE FORD ISSUE A RECALL FOR DEFECTIVE CAMS WITHIN THE 3.4L V8 SHOWS BEFORE SOMEONE GET SERIOUSLY HURT. *LA