2023 Ford Maverick Hybrid

Driving on highway when all warning lights came on the dash, including the messages: AdvanceTrac Off Collision Assist Off Parking Break On Service System Soon. My brakes and accelerator stopped working, and the car immediately started slowing down. I started pulling over but didn't even make it all the way out of the lane. I changed gears, but could not go Forward, emergency brake was on but wouldn't let me turn it off. It did let me put my hazards on. I kept attempting to change gears, and eventually the emergency brake went off and I could shift into drive and pull out of the highway lane. The truck was towed to the shop, and they told me on the phone there was an open recall on the emergency brake. They have not figured out the problem or been able to replicate the issue.

The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. VIN tool confirms parts not available.

The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. VIN tool confirms parts not available.

The contact owns a 2023 Ford Maverick. The contact stated that upon turning off the vehicle, the vehicle immediately entered Deep Sleep mode. The contact stated that after entering Sleep Mode, the electronics in the vehicle failed to function properly. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 1,700.

The contact called on behalf of his company that owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I experienced violent vibration of the front end of this vehicle that started 4 months after purchased from factory delivery to dealership. Tires in front went bald at 5000 miles and over the next 3 months vibration in front end worsened, causing excess wear on the second set of tires. Ford Motor Company was unable to get the defective axles replaced due to poor supply and lack of properly diagnosing the issue initially. I belong to a Ford Maverick Club and this issue is widespread with the 2022 and 2023 models with some dealerships telling customers that there is no danger in driving with the defective CV Joints in the front end and others being instructed not to drive until they can be replaced. Neither of the two dealerships that inspected my car were aware of this widespread issue with the front end CV joint defect. I waited 2 months for the axles to arrive at the dealership and needed to replace all four tires when the new axles were installed. My vehicle was only 11 months old with less than 15,000 miles.

The brakes on my 2023 Ford Maverick (Hybrid) are very grabby at low speeds, usually just before coming to a stop. They are also very noisy especially after a hard rain. I have experienced one incident where the brakes did not want to stop the truck until after a long pause. When I stop, my passengers will lunge forward. I do not have confidence that the brakes will perform as required in an emergency situation. I realize that this has been an ongoing problem with the 2022 and 2023 hybrid models.

Brakes tend to "grab" and aggressively stop the truck at or below 6 miles per hour. It feels like the emergency forward braking system is activating to avoid an accident. But there isn't anything in front of the vehicle. This seems to occur more often during first 15 minutes of driving after startup in the morning (especially when it's cold outside) while vehicle is utilizing motor and braking to recharge batteries. During this timeframe, the brake "grabbing" is more frequent and more pronounced (powerful and sudden). It's like two systems are "fighting" against one-another. But the brake grabbing isn't just occurring during the first 15 minutes of driving. It still occurs occasionally regardless of the time driving the vehicle. I've attempted to "conform" and "adapt" my braking to address the brake grabbing tendency. But the issue isn't doesn't always occur with each braking and the manner in which the braking system brakes thus making it almost impossible for me to "train" my braking to address or overcome the braking characteristics of the hybrid Maverick. I've had to accept that regardless of how I brake, the vehicle is going to "grab" occasionally.

Turned the corner to accelerate at normal speed up a slight incline, and gas pedal stopped working. Typically when accelerating up a hill, the gauge on the left will move past the green "battery" section and the engine will kick on, but this time nothing happened. The vehicle slowed to a stop, and I put in park, then put in drive again and it worked seemingly fine. No check engine or any other warning lights were on. This issue has been experienced by several people in the Ford Maverick Hybrid online forum, so I'm not alone. I'm concerned that if this happens when turning onto a road, or merging onto a highway, it could be very dangerous.