2023 Ford Maverick Hybrid

The welds broke on the front driver side door. Door has a creaking sound and the door has visibly growing stress crack near the door check arm. I took it to the dealer and here' s their repair comments. "B. CUSTOMER STATES DRIVERS SIDE DOOR CREAKS WHEN OPENING AND CLOSING. X MUST GO TO BODY SHOP DOOR WELDS ARE BROKEN (DOOR)" It seems to be the same issue as Ford's customer satisfaction program 23B56 "inspect front door check-arm reinforcement spot welds", for the Ford Excape, coming from the same factory as the Maverick, but the Maverick didn't get a customer satisfaction program for this issue.

Truck started to shake when accelerating past 50 mph. The shaking would stop once the speed limit was reached and you let off the accelerator. Web search results showed 2022, 2023 & 2024 Ford Maverick hybrids are known for CV axle failures with those symptoms. Vehicle was around 48,000 miles. Dealership replaced both CV axles under the 5 year/60,000 mile warranty.

At around 27K miles the two front CV axles began to fail. I brought it to the Ford dealership and they confirmed that both needed to be replaced. It was a $1600 repair. There have been a lot of complaints from Ford Maverick owners who have had CV axle failures at very low miles on their vehicles. These parts typically last 100K to 150K miles and it's not unusual for them to last the lifetime of the vehicle. There is no reason both front CV axles should be failing with 27K miles on a vehicle. This should be covered by a recall.

The truck was being towed behind a motor home, while making a normal left turn from a complete stop the truck began swing wildly from side to side (death wobble). After stopping I found a dash warning "Steering Assist Fault, Service Required" and "Drive Mode Not Available". At that time the truck steering was very difficult to turn, the truck was not drivable. This is the second time this has happened. In June 2024 the exact same thing happened. Ford replaced the steering assembly (twice, the first part was defective) under warranty. I believe this to be a safety hazard. I tow the truck behind the motor home in order to have reliable transportation when I arrive to a destination and also to provide a safe way to get help if some incident occurs while on the road (motor home break down) or for an emergency at the destination. Both steering assist incidents occurred when I was in a remote area with no cell service or internet service. Had there been any kind of medical emergency it could have had unwelcome results.

The Ford Maverick has a known issue with "grabby brakes." I recently took my vehicle in for service and was advised the vehicle had an outstanding service bulletin to solve this problem. The repair given by Ford is ineffectual. There is a potential problems, even at low speeds, for sudden braking and collisions. This is ongoing at every stop and experienced by other Maverick owners.

12 volt electrical system no power. Dealer changed battery cable wiring harness. Received vehicle back. One week later vehicle exhibited no 12 volt power. Informed that it could be the Thinkware dash cam. Which was purchased from Ford and Ford dealer installed. Now informed that it could be the dash cam itself. The dash cam was installed via the OBD port which is always powered. This will drain the 12 volt battery unless vehicle is driven for extended periods. Ford is aware of the issue but no remedy for over 3 weeks. I have told the Ford dealer to have the dash cam installed so that when the ignition is on the dash cam is also powered on and off when the ignition switch is turned off. Using this method negates the parking mode on the dash cam. Another issue is when the drivers side door is opened the interior lights do not activate. Ford notified. Problem not resolved. Low 12 volt battery issue?

This vehicle has chronic clicking when turning , when taken to a mechnanic i was informed the CV Axles both were torn and that it was a common issue for the 22 ford mavericks and they issue replacements for free. However when it comes to this they don’t cover it. The issue is still present and left untreated could be a dangerous issue.

Receiving daily Battery Saver Mode notices telling me some remote features including lock/unlock may temporarily be unavailable. Not to use my AC and go for longer rides, which I have done with no change. My interior lights are not coming on. My radio powers off and on while driving. Constant clicking and noises come from the vehicle when turned off. Difficulties starting the vehicle at times. Feel power losses when driving and accelerating, feel like I could be rear ended when this happens. In doing some online research, I am clearly not alone in this issue, when I contacted Ford and the dealership they both acted as if this is not a current issue and I would have to it inspected by a Ford dealership with no guarantee that the inspection would be covered. I found a recall 24S24 that sounds like my exact issue, yet they say it's not been authorized for my vehicle.