2023 Ford Maverick Hybrid

AUTOMATIC REVVING INCIDENT 1 DATE: November 25, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Slight rain, around 37º F VEHICLE STATUS: In Park, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. ICE engine immediately turned on and revved all the way, as if the accelerator pedal was pressed down all the way. Pedal was NOT under floor mats. Immediately turned key to off position, let sit for a moment. Turned key to on position again and issue seemed to be resolved. No check engine lights or other codes were showing on the dash cluster. AUTOMATIC REVVING INCIDENT 2 & 3 DATE: December 2, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Clear, around 27º F VEHICLE STATUS: In drive, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. Heat was on. Immediately turned dial to “D,” and engine proceeded to again rev all the way up. However, this time, full power was transferred to wheels, causing vehicle to attempt to lunge forward. Luckily, I was on an icy patch of the road, and the tires spun instead of gaining traction. I immediately slammed the brakes and turned the car off. Waited about 2 minutes and then turned key to on position, and the exact same thing happened again. No check engine lights or other codes were showing on the dash cluster. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was driving normally at speed. The truck suddenly lost power. The gas pedal was unresponsive. It took a moment to realize what had happened since the truck showed no indication of an issue. No warnings showed on the dash, the radio was playing as normal. Pressing the gas pedal did nothing. Brakes worked. I was on a road where was I luckily was able to coast into a parking lot and stop safely. I shut off the vehicle and immediately turned it back on. Everything started normally and the vehicle drove normally from that point.

Started Vehicle, pulled out of a parking spot and I slowly approached an intersection, the engine accelerated at a high rpm/rate without touching the gas pedal, I immediately firmly applied brakes, the card was jerking and shaking hard working against brakes, I immediately turned car off. It could have easily ran into a car or person, being that I was on a city street with pedestrians crossing and car traffic. When I restarted, it did not want to move at all. I then restarted it a second time and it drove normal. No lights or warnings appeared. It was at Ford dealer getting all recalls repaired about 2 weeks ago and were completed to my knowledge. This just happened today [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle was travelling on freeway at freeway speeds suddenly without notable cause the vehicle electrical stopped, giving multiple warning in succession, cutting speed rapidly to 35 mph, with no acceleration pedal response and an automatic speed of 35 on battery power with the ability to break, but with no control of speed and only regulated by break pedal. Pulled vehicle to side of road and put in park, parking break automatically engaged. Vehicle had alarms on all automatic systems being off. Turning vehicle on and off did not effect response. After checking engine visually, was able to turn vehicle on with no alarms or issues. This has happened in both my Mavericks and almost led to a fatal collision in the 2022 Maverick.

FOURTH INCIDENT: On [XXX] 2024, at approximately [XXX], I was traveling about 40-mph and slowing for a stop light. Just before coming to a complete stop, at about 5-mph this vehicle suddenly shifted into park on its own. At the same time numerous & various warning prompts appeared on the screen and ALL the warning signs on the instrument cluster became illuminated. As with the three (3) previous incidents, after shifting into drive and taking my foot off the brake the vehicle accelerated all on its own without my placing foot on gas pedal. Unlike previous times, additional warning prompts came up on the screen, e.g. "Hill Assist Parking Unavailable" and "Auto Hold System Fault". Also, after parking, turning vehicle off, locking doors and waiting 30+ minutes, the vehicle did not reset itself like before. Previously after sitting and not running when started it operated properly but with just the engine light on. On May 26, 2024, I had a scheduled recall for the brake lights. I asked my dealer (AutoNation Ford, Frisco (Texas)) to look at video I had taken and a possible fix under Recall 24S33, which I had found on the internet. The dealer service rep refused to look at anything and received to service this particular complaint. Instead, they sent me back onto the highway with a vehicle that can suddenly lose power and accelerate on its own, thereby creating a risk of a crash and injury or death to others or myself. 1st time [XXX], Complaint #11583215 2nd time [XXX], Complaint #11590922 3rd time [XXX], Complaint #11592069 4th, or current incident [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Without warning the truck will stop itself and the parking brake will engage. The service engine light will come one along with the service power train malfunction lights and the pre collision assist not available light. When the truck has been put back into gear it will accelerate on its own but only up to 35 MPH no matter how much gas is applied. This is the second time this has happened both were identical. After sitting overnight with the truck off the issue goes away temporarily but will come back with no warning. Vehicle may be inspected. Ford has already looked at the issue once and is scheduled to look at it again. If this had happened while on the highway, I could have been in a serious wreck that could have been fatal.

THIRD REPORT SAME PROBLEM: See NHTSA tracking Number 11583215 & Complaint Number 11590922: On [XXX], I was driving 2-4 mph through an apartment complex drive when vehicle came to a sudden and complete stop and switched into park all on its own. Numerous & various instrument cluster warning lights and prompts were going off. After putting back into drive very little power but would accelerate all on its own up to 35-40mph. I had previously taken this vehicle on [XXX], to the dealer (AutoNation Ford, Frisco, Texas) and they kept vehicle four (4) days. Upon return they told me diagnostics showed no alerts on vehicle, thus no problems. So, nothing was done. A second such incident happened on [XXX]. The next day I again took this vehicle to AutoNation to have the previously scheduled brake light Recall fix. At same time asked them to again look at the vehicle for issues in this complaint. I also offered to show them video of the self-acceleration, warning lights & prompts and a possible Recall #24S33 (powertrain control module) for this issue. Autonation rep said I was there only for scheduled recall and refused to look at videos or other information. Vehicle WAS NOT examined. On [XXX], I was driving 2-4 mph through an apartment complex drive when vehicle came to a sudden and complete stop and switched into park all on its own. Numerous & various instrument cluster warning lights and prompts were going off. After putting back into drive very little power but would accelerate all on its own up to 35-40mph. This vehicle has had four (4) recalls, and now three (3) separate incidents as described above. I believe it is a hazard and the issue complained of now and previously, are of such magnitude that they pose a significant risk of accident potentially causing injury or death to others or myself. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SECOND REPORT SAME PROBLEM: See NHTSA tracking Number 11583215, 04/16/2024. Took to dealer (Autonation Ford, Frisco, Texas) and they kept vehicle four (4) days. Upon return they told me diagnostics showed no alerts on vehicle, thus no problems. So, nothing was done. 05/26/2024 approx. 8:05pm, traveling 50-mph had sudden loss of power and speed. Warning lights and prompts appeared on cluster. Vehicle slowed immediately to 35-40mph and would not accelerate any faster. Sudden slowdown caused vehicle behind (who was following to close) to suddenly brake, almost hitting me. Would slow when brakes applied. When brakes released vehicle would accelerate to 35-40 mph on its own without applying gas pedal. This vehicle has had four (4) recalls, and now two separate incidents as described above. I believe it is a hazard and the issue complained of herein, and previously, are of such magnitude that they pose a significant risk of accident potentially causing injury or death to others or myself.

On Friday, May 17th around 2:00pm I was driving approximately 25mph when I got an abrupt warning and the truck started to drive differently. I don’t think the vehicle was responding to the gas pedal normally. The first warning said something about selected gear engaging at lower speed. Then there was a message about the pre-collision assist not working, hill ascent not working, and something else - reduced powertrain/service engine soon/advancetrac or something like that. As I pulled over and was slowing down, the truck abruptly threw itself into park while going 5-10mph. I turned it off and then back on and put it in drive. The truck began accelerating without my foot on the gas pedal. My truck got all the way up past 20mph before I slowed down. I tried to record this with my phone as there was no traffic. I could not see well what I was filming because I was looking at the road. My safety was put at risk because had this happened on the highway or a road with no shoulder, things could have been a lot more dangerous. It was scary enough going at a lower speed on a street without traffic. I noticed after this happened that I had a third open recall for the powertrain control module. If I would have known I had this recall and how serious it was, I would have brought it in immediately. Ford should have done more to ensure vehicles impacted by this recall were contacted ASAP. I brought my truck in to the Ford dealership first thing this morning and I am waiting to hear back. The service agent was aware of this ‘limp mode’ situation occurring. I believe I was the first Maverick owner to bring a truck in for this issue at my dealership. There were no warnings that this might occur. I went from driving leisurely to having to figure out what all the beeping and flashing alerts were and manage to get to the side of the road in a truck that was not driving/responding normally. Then the truck started accelerating without my foot on the pedal! I have a video of this