2023 Ford Maverick Hybrid

On occasion, at slow speeds, typically when coming to a slow stop (such as at a stop sign or light), the vehicle's brakes appear to "grab", car "shutters", feels as if car's brakes are locking or vehicle is about to turn off. I am the original owner of this vehicle, less than 7,000 miles, this problem has happened approximately 10 times. This problem could have resulted in a dangerous situation, the last time this happened someone was crossing in front of me at a crosswalk and I was not sure vehicle was going to stop.

The contact owns a 2023 Ford Maverick. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the local dealer, where the PCM was reset. The vehicle was repaired. While driving at unknown speeds, the brake pedal was depressed, and the vehicle began to shake. The vehicle was taken back to the same local dealer, and the contact was informed that the ABS was engaged. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to another dealer. The contact stated that the failure was related to TSB: 22-2493 (Service Brakes). The failure mileage was approximately 800.

Driving on highway when all warning lights came on the dash, including the messages: AdvanceTrac Off Collision Assist Off Parking Break On Service System Soon. My brakes and accelerator stopped working, and the car immediately started slowing down. I started pulling over but didn't even make it all the way out of the lane. I changed gears, but could not go Forward, emergency brake was on but wouldn't let me turn it off. It did let me put my hazards on. I kept attempting to change gears, and eventually the emergency brake went off and I could shift into drive and pull out of the highway lane. The truck was towed to the shop, and they told me on the phone there was an open recall on the emergency brake. They have not figured out the problem or been able to replicate the issue.

The brakes on my 2023 Ford Maverick (Hybrid) are very grabby at low speeds, usually just before coming to a stop. They are also very noisy especially after a hard rain. I have experienced one incident where the brakes did not want to stop the truck until after a long pause. When I stop, my passengers will lunge forward. I do not have confidence that the brakes will perform as required in an emergency situation. I realize that this has been an ongoing problem with the 2022 and 2023 hybrid models.

Brakes tend to "grab" and aggressively stop the truck at or below 6 miles per hour. It feels like the emergency forward braking system is activating to avoid an accident. But there isn't anything in front of the vehicle. This seems to occur more often during first 15 minutes of driving after startup in the morning (especially when it's cold outside) while vehicle is utilizing motor and braking to recharge batteries. During this timeframe, the brake "grabbing" is more frequent and more pronounced (powerful and sudden). It's like two systems are "fighting" against one-another. But the brake grabbing isn't just occurring during the first 15 minutes of driving. It still occurs occasionally regardless of the time driving the vehicle. I've attempted to "conform" and "adapt" my braking to address the brake grabbing tendency. But the issue isn't doesn't always occur with each braking and the manner in which the braking system brakes thus making it almost impossible for me to "train" my braking to address or overcome the braking characteristics of the hybrid Maverick. I've had to accept that regardless of how I brake, the vehicle is going to "grab" occasionally.

I have an issue where my Ford Maverick sometimes, randomly will be nudging, surging, or pulsing forward (I'm not sure how to describe it) despite your foot being on the brake. It occurs most often on cold mornings, when you first start the truck, have your foot on the brake and shift from park to drive, before you release the brake (take your foot off the pedal) you notice the truck is going: bump bump bump bump bump, like a forward nudge push forward. Even though this has mostly occurred first thing in the morning it has occurred at other times while stopped at a red light, stopped in front of a pedestrian crosswalk, and stopped in front of school + children. It's really concerning the despite having your foot on the brake the truck is still trying to lurch forward.

I have had this issue since I got my Ford Maverick. The brakes are very abrupt and grabby at slow speeds and it makes the vehicle extremely difficult and unsafe to operate in pick up lanes, parking lots, stop and go traffic and many more situations. I had a service appointment where ford updated modules in the truck however, still have the problem where trying to use the brakes on this truck, is always a very abrupt bump to a stop. When you're gradually & smoothly decelerating to a stop, near the last moment you get a very abrupt bump, lurch forward, jerk to a stop. It's as if the hybrid truck does not transition from regenerative braking to pad on rotor well.

Brakes of 2023 Ford Maverick Hybrid are grabby when attempting to slow down to below 6-10 mph , especially when the roads are wet. Even with slight wetness on the ground, the brakes behave like this, leading to unpredictable stops and jumping of vehicle in common scenarios such as drive-thrus, stop-and-go traffic, and parking lots. Local Ford dealer attempted to replicate the issue when it was sunny and dry and was unable to do so. As such, they refuse to do any further testing and are saying that "this is how the hybrids are". I will visit the dealer again when it is rainy.