2023 Ford Maverick Hybrid

Received multiple error messages while driving including: -Pre-collision assist not available -Service engine soon -Powertrain malfunction/reduced power -Drive mode selection disabled. The “D” on the gear shift was also flashing. I slowed down and the parking brake automatically engaged while still driving, which caused the truck to stop hard. I was able to drive it to a parking lot, but it felt like it was in between gears. I turned the truck off in the parking lot for a few minutes, and then successfully started it and made it to the dealership with warning lights on. This likely would have caused a wreck if it happened on a busy road at higher speeds. It sounds like many Maverick owners are experiencing this same issue after the last recall. I don’t feel safe driving my vehicle until this is resolved.

The brake system in Hybrid model Ford Mavericks is unreliable and inconsistent in the way it applies the brakes at slow speeds, causing the driver to over or under apply the brakes and making the vehicle unsafe and unpredictable. My 2023 model braked normally for the first 6 months of ownership and then started to grab at slow speeds when attempting to use the brakes. When coming to a stop it will grab suddenly. It is extremely challenging to drive in stop and go traffic. Ford has issued a software fix, TSB23-2060, the second one they've issued. Neither fix has solved the issue. I often under apply the brakes in anticipation of the brakes grabbing and then have to overapply at the last moment to compensate. It really is unsafe and needs to be fixed. I hope the NHTSA can force the issue.

Brakes surge shortly after startup causing vehicle to lunge forward multiple times when at a stop. Has happened multiple times since getting vehicle new with less than 4500 miles. No warning lights has not been inspected by dealership but many other people have mentioned this happens to them frequently on Ford Maverick truck forums.

On the middle of the road when driving, of a sudden, powertrain malfunction, pre-collision not available message pop up and the service light, check engine light also started blinking on the dashboard. Gas pedal was unresponsive and the truck coasted, was not able to drive,and I was luckily able to merge over into the shoulder. Started the truck a few times and the issue persisted. Could move forward with the battery but still no input from the gas pedal. I towed the truck and is with the dealer. But i am really scared to drive it again. I was lucky to be on the slow speed zone road and was able to get out to the shoulder. However, I might have been hit and killed if it happens in the highways. Very scary moment. Ford should take some safety responsibility more carefully.

Vehicle was going down the highway around 70 mph and suddenly warning message appeared on display that the select drive has been disengaged and the brake light ( lower right of instrument panel ! Red brake illuminated and the engine stop propelling engine and started to brake and slow down. Had to coast to the shoulder and car was not running and brakes were still applied even I was not applying the brakes . This is the second time it acquired. Second time was after Ford dealership had again done an ecm update and said the issue was resolved.

[XXX] car malfunctioned in same ways it has been before. Car was going 76 on the highway, no cruise control, when a message about the gear shifting pops up and the accelerator stops working. Car begins to slow, and we pull over onto side of the highway. After getting down to about 40 parking break pops on and messages begin flashing through on the display saying: AdvanceTrac Off, Collision Assist Off, Parking Break On, Service System Soon, and all the warning lights such as check engine and slippery surface come on as well. Turned car off and waiting 5 minutes, then got back on highway. Car repeated this exact same process again after driving 3 more minutes going 76 with no cruise control. Here is a link to a video taken the first time this happened on this day: [XXX] Car had been taken to have this exact issue repaired the previous week and held over night on [XXX]. This is the second time that the car has been taken to be repaired for this issue. The first time I was told it is a computer melt down. The second I was told that the recalls that they fixed they did not fix entirely, and that it should be fine now. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

[XXX] car malfunctioned. First said that the gear was working incorrectly, then accelerator stopped working and Drive light on gear shifter started blinking. I pulled over to the shoulder and the brakes continued to work, and all the messages in my video came up. I started on cruise control going 78 then once I got to [XXX] my parking break came on. Once stopped I tried to go back into drive, which didn't work. The car would not go forward, almost as if it was attached to something. I turned the car on and off several times trying to get the parking break off. After I believe the third time I turned off the car, I left it off for about a full minute before turning it back on. The lights on the car went off except the check engine light, and the emergency brake light, though it finally let me turn the break off and switch into drive. I drove the last 4 minutes home without incident. This links to a video I took after I got onto the side of the highway showing what was happening on my display. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I took my ford Maverick to dealer for the recalls for three recalls: 24c01,23c41 & 23e09. About 1 hr later driving on highway the engine lost all power, gearshift knob was flashing; warnings started flashing , hill start assist not available, service soon, pre collision assist not available, service power trac( I think) , check engine light came on & a wrench illuminated on dash. Went from 55-60 mph to a crawl in a few seconds. Fortunately was able to pull off-road. As soon as I touched brake pedal the emergency brake applied automatically & I slammed to a halt. After about 5 minutes & turning ignition on & off a few times everything worked again. Check engine light remained on but turn off the next day. I called dealership and they had no idea. Said to bring in again. This occurred on 3/6/24 and again on 3/10/24, both times identical situation. Both times I was fortunate no one behind me and room to get pull on shoulder. I posted this on the Maverick forum online only to discover it is happening to many people that have had the recalls done. Some their engines stopped on the freeway, going from 70 to a crawl in seconds. One person mentioned they almost got nailed by an 18 wheeler rig. I called the dealership to let them know what I found out online and they had no idea or how to correct. Whatever the recall did ( seems to be the recall associated with emissions - from online discussions) ford needs to correct. This type situation is an accident waiting to happen and putting lives in danger.

Brakes grab unpredictably when slowing to a stop. When car has slowed from higher speeds down to less than 6 mph, the brakes suddenly grab, stopping the vehicle without warning. The degree of grabbing is never the same twice, happens almost every time I stop. It is especially bad after vehicle has been parked for a period of time, and is noticeably worse in moist conditions. I feel that this condition can cause a car behind me to possibly hit me. My FORD dealer has had service tech drive it and confirm this is occurring, but they have thus far been unable to apply a fix.