2023 Ford Maverick Hybrid

Yesterday, May 22nd, my 2023 Hybrid Maverick stalled while I was in the middle lane. Fortunately I was able to quickly get over to the shoulder but had absolutely no power. The D-drive gear position light was blinking orange light. Warning message came up on the dash, saying the vehicle won't operate in that gear. I looked down and the shift wheel was in the drive position, but the orange light was not lit on the shifter. I then got error messages, Service Engine Soon Warning, Powertrain Malfunction/Reduced Power Warning, Pre-Collision Assist Not Available Warning. This was really rattling, to have a modern vehicle, with only 20,000 miles stop operating in heavy traffic. It is the second time, this incident happens. The last time was on March 25th.

We on the interstate cruising @ 75. Lost all drive power, flashed something about a lower gear while I was making my way to the shoulder. When I got down to about 10 mph, the parking brake activated. When we came to a stop, it went into park, but the "P" was flashing. I couldn't disengage the brake or put it into gear . I turned it off and back on and was able to shift into drive and release the brake. It would move at this point, but it very slowly. We limped to the next exit. I turned it off and topped the tank off( had half tank) Then it started and was able to drive the other 170 miles home. CEL stayed on. Our concern is that this will happen again, cause an accident and injure or kill my family.

I was on a freeway cruising around 85 mph when all of a sudden my truck lost power and went into limp mode. I had 3 dash warnings about powertrain malfunction, front end collision being unavailable, and something about engaging gear at low speeds. This has happened once before. Same three messages. The vehicle loses power and speed FAST. Luckily both times I was able to pull over and turn the vehicle off and back on and it just has a check engine light and drives normal again. I have had one software recall completed on my truck and I have 17,000 miles.

While driving, the vehicle will suddenly flash a message about gear selection being unavailable until speed is reduced, followed by error messages about collision-assist disabled, ESC disabled, hill-start assist disabled, and service messages. Check engine light and service lights also come on. No response to throttle inputs, once vehicle decelerates to around 1-2 mph electronic parking brake is automatically applied leading to an abrupt stop. Parking brake can then be removed and vehicle put back into drive, however all drive mode selection is disabled and again there is no response to throttle inputs - truck will accelerate on its own up to above 30 mph (do not know top speed as all areas this occurred were 30mph or less, had to ride brakes to maintain speed limit as vehicle was attempting an uncontrolled/uncommanded acceleration). This has happened 3 times, and first occurrence happened after recalls 23E07, 23E09, and 23C41 were completed. Any attempts to clear faults or exit this limp mode condition fail unless the vehicle is turned off and allowed to sit for 5-10 minutes, at which point faults still remain in system however vehicle is no longer in limp mode with functionality now restored to previously disabled systems. Recorded faults from last occurrence on April 05 2024: SOBDMC DTC U1011:86-AF SOBDMC DTC U1028:00-26 PCM DTC U1010:00-AF OBDII DTC U1011-P ABS DTC U0401:00-2F ABS DTC U0131:00-2E ACM DTC U0255:00-28 IPMA DTC U0418:86-AF In my situation all 3 failure events occurred in a low-traffic, low-threat environment. 1st happened when turning onto a 30 mph road and accelerating in low traffic, able to safely pull over. 2nd happened when turning out of my driveway and began to accelerate, again able to safely pull over. 3rd happened when leaving spot in parking lot, able to safely pull over into another spot.

Driving no more than 40 mph, suddenly “gear shift will engage at low speeds” pops up. At this point there is no acceleration. Then when I get to stop at about 1mp it jerks me into an e-brake, immediately prompting “powertrain error”, “check engine”, “hill climb assist not available”, “collision warning not available”. This all started after the last recall was performed. This is now the second time this has done this. I am lucky it did not do this on the highway itself.

I was driving on the interstate and the gear shift light started blinking. Then I started getting warning lights on the dash: - Gear Selected Will Engage at Low Speed - Powertrain malfunction/reduced power - Pre-collision assist not available - Service engine soon warning - Hill assist not available The car then abruptly slowed down to 35 mph and continued driving at 35 mph even when applying gas. The vehicle would slow down when the brake was applied, however releasing the brake, caused the car to accelerate to 35 mph. The vehicle was inspected by a Ford dealership, however it was the next day, after the car had been turned off for multiple hours. The dealership did not find any active codes, so there was no "fix". Abruptly coming to a stop on the interstate is scary and life-threatening. Ford needs to fix this issue as there could have been a catastrophic accident, had other motorists not been paying attention!

I was driving down the road at roughly 45 mph when all of the sudden my car went into neutral I was no longer able to accelerate. I was in the middle of a four-lane road with a traffic light coming up in cars coming from the opposite direction. I happen to be very lucky and right next to the Ford dealership when this happened, but this could be a major safety issue as others would not be so fortunate when vehicle was thrown into neutral. All the dash lights came on the check engine light came on. Wrench icon popped up on the instrument cluster as my car began to slow down as I pulled over once I got to roughly 5 mph the parking break engaged and came to a screeching halt. I was not able to disengage the parking break and could not move the vehicle into the drive position anymore. As stated before I was right next to the Ford dealership when this happened so I walked over and talked to the service center, they didn’t see any errors on my vehicle so I walked back to it started it up and the only remaining light was the check engine light and I was able to drive it over to the Ford dealership at which point the gentleman said he was able to see the errors. I have done a lot of reading online and this is called limp mode but is doing nothing to acknowledge this or proactively fix this on vehicles. From my understanding, this issue does not happen until after there are recalls done on the vehicle. I took my car into the shop at 9200 miles. Had it serviced for an oil change at which point Ford did two service recalls and now I’m experiencing this issue

All of a sudden, in the rain while driving home, suddenly the (Drive) Shift knob light was flashing, warnings started flashing, hill start assist not available, service vehicle soon, pre collision assist not available, service advance Trac, and parking brake applied automatically and total loss of power…. I almost got into an accident in the rain and traffic because the people driving behind me were going fast and my truck just suddenly lost power and I had those cars coming from behind that had to swerve out of my way. I managed to get it pulled off to a side street and turned it off and back on and still had no power and all the lights/warnings were still on. When you press on the gas, it wouldn’t go…. No throttle response. Could not go. Almost in an accident and it could have been worse if this happened with more traffic.