2023 Ford Maverick Hybrid

The contact owns a 2023 Ford Maverick. The contact stated that while starting the vehicle, the contact observed a loud exploding noise coming from the speakers. Additionally, the contact stated that when the vehicle was turned off, she observed a loud crackling noise emanating from the radio. The contact stated that several lights on the instrument panel flashed on and off. The contact sustained ear injuries. Medical attention was not sought. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 7,000.

For no reason the truck would not start. No electric signal at all inside the truck either. Also the ignition and steering were locked. Called Ford to send out someone to jump the truck. It then started right away. Also took to the Ford dealer to have them check it out. They could find nothing wrong. I also have had a problem with the truck not starting after driving it and then parking it. The battery will not respond, igniton will not work, not able to shift it at all. Completely locked up. I have to try starting the truck another couple of times for the green READY to come on. This is concerning as I do not understand why the truck locks up. This has happened on at least four occasions since I purchased this truck at the end of June 2023

I had 2 recalls fixed about 3 weeks ago. Today I was driving & my Maverick malfunctioned. (Maybe it's what they call Limp mode.) Many alerts & icons started flashing, I was prompted to pull over & call a dealer. I pulled over, was able to take some pics but some icons were no longer showing. I tried restarting the vehicle after a couple mins = same thing. I shut if off waited a few minutes & it worked. Well, check engine is still lit & some of the safety features won't turn on. I have copilot 360, lane keeping, etc, but most of those features are still affected. I called the dealer & am waiting for a call back. Many other Maverick hybrid owners have told me this happened after their recall fix. I wish I didn't get the recalls fixed.

I was driving down the road at roughly 45 mph when all of the sudden my car went into neutral I was no longer able to accelerate. I was in the middle of a four-lane road with a traffic light coming up in cars coming from the opposite direction. I happen to be very lucky and right next to the Ford dealership when this happened, but this could be a major safety issue as others would not be so fortunate when vehicle was thrown into neutral. All the dash lights came on the check engine light came on. Wrench icon popped up on the instrument cluster as my car began to slow down as I pulled over once I got to roughly 5 mph the parking break engaged and came to a screeching halt. I was not able to disengage the parking break and could not move the vehicle into the drive position anymore. As stated before I was right next to the Ford dealership when this happened so I walked over and talked to the service center, they didn’t see any errors on my vehicle so I walked back to it started it up and the only remaining light was the check engine light and I was able to drive it over to the Ford dealership at which point the gentleman said he was able to see the errors. I have done a lot of reading online and this is called limp mode but is doing nothing to acknowledge this or proactively fix this on vehicles. From my understanding, this issue does not happen until after there are recalls done on the vehicle. I took my car into the shop at 9200 miles. Had it serviced for an oil change at which point Ford did two service recalls and now I’m experiencing this issue

On [XXX] at approx. 9:30PM I was traveling on [XXX] in Garland, TX, at 70mph when my vehicle experienced a sudden loss of power, with speed immediately dropping to about 35-40mph. Cluster showed prompts saying 1) cannot use selected gear at this speed (light under "D" was flashing), 2) pre-collision not available; 3) Airbags sensor bad; 4) power-train warning; and, several others before telling me engine needed service. When I tried to accelerate it would go no faster than 25mph. When I applied the brakes and released them it would then accelerate to 35-40mph on its own. Engine light started flashing. When able to do so I pulled over and turned vehicle off. I started it back up and engine light stayed lit, but it continued to experience loss of power and go no faster than 25mph. Again, when I applied the brakes and released them it would accelerate to 35-40mph all on its own. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I had just driven roughly 30 freeway miles on my way home and the truck suddenly flashes a barrage of errors, ESC fails, gear selection at low speed message, hill assist disable, pre-collision assist disabled, ABS light is on, MIL is on, service wrench is on, and drive mode selection is disabled. My truck lost all response to gas pedal, slows down and then slams on the parking brake at like 1-2 mph. I shut it down, started it back up. I had no gas pedal input. The truck self-accelerates up to 30-35 mph. I don't know at which speed it would've stopped accelerating because because the speed limit was only 30 mph. I ended up just riding the brakes to keep the speed down for 3/4 mile so I could get home. I went to reverse into my space at home and the truck was self accelerating in reverse as well. Normally it just rolls back slowly, but this truck was really moving. I abandoned the idea of backing in because I was scared it would just drive itself into the wall. I will not go back out on the roads in Los Angeles driving this vehicle until this is fixed, I would knowingly be putting my life and others lives in serious danger. I was fortunate that I had read about this happening in the past few weeks to several other Maverick owners who have had this problem, so I was aware of what was happening when it started and was only going about 30 mph and there wasn't much traffic around because it was a rainy night. This would've been horrifying if I were on the freeway or in moving traffic, which has happened to others. According to what I've found on the internet, this issue it is a result of some bad software installed in a recent recall. I had the recall done on [XXX] when I had an oil change. Not sure if this is appropriate but this is a reddit thread from a month ago with a bunch of other drivers that have had this happen: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Received multiple error messages while driving including: -Pre-collision assist not available -Service engine soon -Powertrain malfunction/reduced power -Drive mode selection disabled. The “D” on the gear shift was also flashing. I slowed down and the parking brake automatically engaged while still driving, which caused the truck to stop hard. I was able to drive it to a parking lot, but it felt like it was in between gears. I turned the truck off in the parking lot for a few minutes, and then successfully started it and made it to the dealership with warning lights on. This likely would have caused a wreck if it happened on a busy road at higher speeds. It sounds like many Maverick owners are experiencing this same issue after the last recall. I don’t feel safe driving my vehicle until this is resolved.

On the freeway all of sudden the “D” icon on the gear selected started flashing and then I started to receive multiple check engine light error messages one after the other, including: •Gear Selected Will Engage at Low Speed •Powertrain malfunction/reduced power •Pre-collision assist not available •Service engine soon warning •Service AdvanceTrac •Hill assist not available The truck then proceeded to switch into neutral all on its own and upon me trying to move the gear selector back into drive the car had zero power when applying the gas. I had to try to avoid traffic to get to the emergency lane with zero power just coasting to the side of the highway. Based on other Ford Maverick owners' testimony it seems Ford Maverick Hybrids getting a recall update to their Powertrain Control Module are then experiencing unpredictable and recurring instances of their truck suddenly having these check engine and random shutdown issues. It seems this has happened to dozens of owners, often at high speeds in the middle of the interstate. It begins with a sudden cascade of alerts (like 5 different malfunctions and systems shutting down). My Ford Maverick was towed and is currently being inspected at the Ford dealer.

Vehicle was traveling at 35 MPH. Vehicle shuddered and lost propulsion. Dash displayed following message: "Gear Selected will Engage at Low Speed" The "D" indicator on the shift knob was flashing. Vehicle was able to be pulled to side of road at very low speed. The following error messages were displayed in sequence: "Hill Start Assist Not Available" Pre-Collision Assist Not Available" "Service AdvanceTrac" Additionally, the following error light were iluminated: Check Engine Service Engine Soon Tranction Control Off 12 volt battery error Vehicle was turned off and restarted. The same error messages were displayed. Ford dealer was contacted to schedule a service visit. After a five minute wait, vehicle was able to start and drive, though performance was not as it had been. This morning, error lights remain on