2017 Ford Fusion

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed and depressing the brake pedal, the vehicle failed to respond as needed. The contact stated that she depressed the brake pedal down to the floorboard and the vehicle responded. A message indicating that the brake fluid level was low was displayed. The contact stated that she had been adding brake fluid to the vehicle more frequently. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. Parts distribution disconnect.

My car started smoking out of nowhere, smoke was coming out of the tail pipe. My cars check engine light begin to blink. The whole entire car begin to shake. It was making a rattling sound, the car begin to slow down on its own, even though I was pressing the gas. It wouldn’t go any faster than 65 miles an hour as the car begin to shake and make a loud rattling noise. My AC went out all of a sudden this was two hours after getting it serviced.

The contact owns a 2017 Ford Fusion. The contact stated that while driving at 75 MPH, the temperature gauge began to indicate that the vehicle was overheating. The contact was able to pull to the shoulder of the road, and after a visual inspection of the engine compartment, it was observed that the coolant overflow container was empty, yet upon removing the container cap, coolant suddenly flowed back into the container, filling it. The overheating warning light was illuminated on the instrument panel. Later, the contact stated that, after starting the vehicle, she observed smoke emanating from the engine compartment and, upon visual inspection, noticed a small fire within the engine compartment that she was able to extinguish alone. No fire or police report was filed, and the vehicle suffered insignificant damage. The vehicle was taken to an independent mechanic, who diagnosed a failure with the CPV valve. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who replaced both the fuel injector and thermostat, but again, the failure reoccurred. After investigating the failure, the contact related it to Ford's TSB 19-2346 (Engine and Engine Cooling), but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA hotline for assistance. The failure mileage was 115,000.

The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the transmission warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that coolant had leaked into the engine and the engine short block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that a Customer Service Satisfaction letter was mailed; however, the program had expired. The failure mileage was approximately 130,000.

The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the vehicle had not yet been taken to a dealer. The contact stated while driving at approximately 30 MPH, as she started slowing for a traffic signal, as she depressed the brake pedal it went to the floorboards. The contact stated no warning light was illuminated. The contact stated that she was close enough to her residence that she drove onto the driveway, however the vehicle crashed into the side of her garage. The vehicle's front driver's side fender was scratched. The contact was not hurt. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced a failure. The failure mileage was approximately 123,000. Parts distribution disconnect.

The contact owns a 2017 Ford Fusion. The contact stated while driving approximately 40 MPH and attempting to slow the vehicle while descending a slight grade in the road, the brake pedal was depressed and went to the floorboard. The vehicle failed to slow as needed. The contact steered the vehicle off the roadway and used a grassy hill on the side of the road to stop the vehicle. The vehicle was safely stopped and shifted into park. The contact stated that the "Service Required" warning light was illuminated. The contact had the vehicle towed to a dealer where it was diagnosed and determined that the brake pads and hoses needed to be replaced. The vehicle had been repaired. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) and related the brake failure to the recall. The manufacturer had not been informed of the failure. The failure mileage was approximately 99,000.

The contact owns a 2017 Ford Fusion. The contact stated that upon start of the vehicle, the vehicle failed to move forward as the shift sys fault service required message was displayed on the instrument panel. Due to the failure, the vehicle was towed to a dealer where the contact was informed that the shifter cable bushing was defective and needed to be replaced. The contact's husband linked the failure to NHTSA Campaign Number: 22V413000 (Power Train). The manufacturer had been notified of the failure and was informed that the vehicle was not under recall. The vehicle had been repaired. The failure mileage was 101,413.