Engine. Review the 394 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 310 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 134 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

37 crash reports8 fire reports24 injury reports

Suspension complaints

5 reports

Clear category filter

100,000 miles · May 9, 2024

Power TrainSuspension

Read full complaint

The contact owns a 2017 Ford Fusion. The contact stated that after shifting from park(P) into drive(D), the gear shifter erroneously shifted back to park(P). The vehicle was taken to the local dealer who diagnosed that the shifter cable bushing was faulty and needed to be replaced. The shifter cable bushing was replaced, and the vehicle was repaired; however, the failure reoccurred. Additionally, while operating the vehicle, the steering wheel abruptly jerked to the left. The vehicle was taken to the local dealer who determined that the front ball joints were faulty and needed to be replaced. No further information was available. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The approximate failure mileage was 100,000.

NHTSA ODI #11587886

Mileage unknown · Jun 14, 2021

EngineSuspensionUnknown Or Other

Shift linkage keep detaching from the the transmission causing the transmission too slip. It detaches often it’s been going on for 2 months now. I called Ford dealership to see have they heard of this problem and they answer was no. It might be a recall on this vehicle.

NHTSA ODI #11420862

44,543 miles · Jan 21, 2021

SteeringSuspensionWheels

TURNING INTO MY NEIGHBORHOOD AT ABOUT 10-15 MPH THE LEFT WHEEL AND HUB FELL OFF CAUSING THE CAR TO CRASH INTO THE PAVEMENT. THIS CAUSED ALOT OF DAMAGE TO THE FRONT BUMPER AND FENDERS. AND THE LINKAGE TO THE RIGHT WHEEL. FORD SAID IT WAS BECAUSE I HIT SOMETHING BUT I DID NOT HIT ANYTHING AND MY CAR STOPPED DEAD IN THE MIDDLE OF T…

Read full complaint

NHTSA ODI #11389280

2,300 miles · Aug 16, 2019

EnginePower TrainSuspension

Read full complaint

I HAVE THE 2017 FUSION SPORT 2.7L TWIN TURBO AND I PURCHASED IT NEW. ON MORE THAN 30 OCCASIONS AND AT DIFFERENT SPEEDS THE VEHICLE LOSES ALL POWER WITHOUT WARNING. I HAVE HAD IT TO 2 DIFFERENT DEALERS WHO SAID THERE ARE NO CODES STORED INDICATING THIS HAPPENED AND SINCE THEY WEREN'T ABLE TO REPRODUCE THE ISSUE THAT THERE WAS NOTHING THEY COULD DO TO HELP. I FILED A COMPLAINT WITH FORD CORPORATE BUT THEY CLOSED MY CLAIM SINCE THEY HAD NO INDICATION THIS WAS OCCURING. I HAVE SEEN SEVERAL COMPLAINTS ABOUT THIS EXACT ISSUE BUT YET THEY CONTINUE TO DENY THE PROBLEM. ON A FEW OCCASIONS I WAS ON THE HIGHWAY RUNNING 70 MILES AN HOUR. HOW MANY PEOPLE HAVE TO DIE FOR THIS TO BE ACKNOWLEDGED? THE NHSTA NEEDS TO MAKE FORD STEP UP AND TAKE CARE OF THE PROBLEM. EVERY TIME THIS HAS HAPPENED THE CAR ALSO PUT ITSELF IN PARK BEFORE CAR WAS AT A COMPLETE STOP WHICH CAUSED A HARD JOLT TO THE TRANSMISSION. THIS IS GOING TO DAMAGE THE TRANSMISSION AMONG OTHER THINGS OVER TIME. I PAID $40,000 FOR THIS CAR AND DESERVE TO FEEL SAFE WHILE DRIVING IT ON THE ROAD. WHAT IF THIS WAS HAPPENING TO YOUR FAMILY WOULD YOU JUST IGNORE IT AND MAKE YOUR FAMILY KEEP DRIVING THE VEHICLE KNOWING AT ANYTIME IT COULD LOSE POWER AND CAUSE YOU TO WRECK? HOW COME NOTHING IS BEING DONE ABOUT THIS? MAKE THEM BUY MY CAR OR FIX THE ISSUE SO I DON'T HAVE TO PUT MY LIFE IN DANGER IN ORDER TO GET WORK. I AM A NURSE I SHOULD BE ABLE TO FEEL SAFE DRIVING TO WORK. THIS HAS NOT HAPPENED ONE TIME BUT WE'LL OVER 25-40 TIMES SINCE PURCHASE.

NHTSA ODI #11244337

15 miles · Nov 9, 2017

Power TrainSteeringSuspensionCrashInjury

Read full complaint

TL* THE CONTACT OWNS A 2017 FORD FUSION. WHILE DRIVING 60 MPH, THE VEHICLE PULLED TO THE LEFT AND SWAYED. THERE WERE NO WARNING INDICATORS ILLUMINATED. BEFORE MAKING AN APPOINTMENT WITH SHEEHY FORD OF MARLOW HEIGHTS (5000 AUTH RD, MARLOW HEIGHTS, MD 20746 (301) 423-4950), THE VEHICLE STARTED PULLING TO THE RIGHT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIRES NEEDED AIR. ANOTHER TECHNICIAN DIAGNOSED THE VEHICLE AND REVEALED THAT THE FRONT CAMBER AND REAR TOE FAILED. THE REPAIRS NEEDED WERE UNKNOWN AND THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS ALSO TAKEN FOR A TEST DRIVE, BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT TO MAKE AN APPOINTMENT WITH THE LOCAL DEALER. THE CONTACT STATED THAT THE GEAR SHIFT ALSO STARTED TO SHIFT INADVERTENTLY FROM DRIVE TO NEUTRAL. THE VEHICLE WAS TAKEN BACK TO SHEEHY FORD OF MARLOW, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED ONCE AGAIN AND INFORMED THE CONTACT TO MAKE AN APPOINTMENT. ON NOVEMBER 1, 2017, WHILE DRIVING 25 MPH, THE VEHICLE SHIFTED TO THE RIGHT, STRUCK TWO OTHER VEHICLES, FLIPPED OVER, AND LANDED ON ITS ROOF. ALL OF THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED BRUISES ALL OVER THE BODY AND INJURIES TO THE NECK, BACK, LEFT HIP, BOTH SHOULDERS, AND BOTH KNEES. THE CONTACT WAS TRANSPORTED BY AMBULANCE TO A LOCAL HOSPITAL. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW LOT AND WAS AWAITING INSPECTION FROM THE INSURANCE COMPANY. THE MANUFACTURER WAS NOTIFIED AND A CASE WAS OPENED. THE INITIAL FAILURE MILEAGE WAS APPROXIMATELY 15 AND THE CRASH OCCURRED AT APPROXIMATELY 3,200 MILES.

NHTSA ODI #11044825

Official recalls

23V162000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

Mar 10, 2023

Ford Motor Company (Ford) is recalling certain 2013-2018 Fusion and Lincoln MKZ vehicles. The front brake hoses may rupture and leak brake fluid.

Consequence & remedy

Consequence: A brake fluid leak will increase brake pedal travel and extend the distance needed to stop the vehicle, increasing the risk of a crash.

Remedy: Dealers will replace the front brake hoses, free of charge. Owner notification letters were mailed June 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S12.

18V167000 · Steering: Steering Wheel/handle Bar

Mar 12, 2018

Ford Motor Company (Ford) is recalling certain 2014-2018 Lincoln MKZ and Ford Fusion vehicles. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while driving.

Consequence & remedy

Consequence: A steering wheel detachment can cause a loss of steering control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the steering wheel bolt with a longer bolt, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S08.

17V427000 · Power Train:automatic Transmission:torque Converter

Jul 6, 2017

Ford Motor Company (Ford) is recalling certain 2017 Lincoln MKZ and Ford Edge and Fusion vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.

Consequence & remedy

Consequence: If the torque converter weld studs fail, the torque converter will not be connected to the engine flexplate and the vehicle will lose the ability to move, increasing the risk of a crash.

Remedy: Ford or Lincoln will notify owners, and dealers will replace the torque converters, free of charge. The recall began August 25, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S16.

16V874000 · Seats:mid/rear Assembly

Dec 5, 2016

Ford Motor Company (Ford) is recalling certain 2017 Ford Fusion vehicles manufactured September 27, 2016, to September 28, 2016. The left rear seat backs pivot pins may have been improperly welded.

Consequence & remedy

Consequence: During a crash, the improper welds may fail, allowing any stowed luggage to move into the passenger compartment, increasing the risk of injury.

Remedy: Ford will notify owners, and dealers will replace the left hand, second row seat back frame, free of charge. The recall began January 10, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S43.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ22004 · Front Brake Jounce Hose Failures

Opened Aug 8, 2022 · Closed Mar 24, 2023

Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On August 8, 2022, the Office of Defects Investigation (ODI) opened this investigation based on 50 Vehicle Owner Questionnaires (VOQs) alleging front brake jounce hose ruptures on model year (MY) 2013-2018 Ford Fusion and Lincoln MKZ vehicles. A ruptured front brake hose results in a brake fluid leak. As a result, the driver may experience an increase in pedal travel and a reduction in the rate of deceleration, increasing the risk of a crash. It should be noted that the subject vehicles identified fell outside the scope of NHTSA Safety Recall 20V-469, which addressed front brake hoses rupturing on certain MY 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The result causes a brake fluid leak, lengthening the distance needing to stop the vehicle, increasing the risk of a crash.On March 10, 2023, Ford Motor Company (Ford) submitted to NHTSA Safety Recall 23V-162 (Ford Recall 23S12) to address front brake jounce hoses that may rupture. Ford found the rupture occurs from a localized failure of the internal reinforcement braid due to cyclic fatigue through tensile/bending and torsional inputs during suspension and steering articulations. The supplier for the front brake jounce hoses is Hitachi. This recall affects the subject vehicles equipped with non-hybrid engines and the suspect front brake jounce hoses (a total of 1,280,726 vehicles). The recall covers subject vehicles built from February 3, 2012 to July 19, 2017 when the suspect hoses were used in vehicle production. The remedy is for dealerships to replace both front brake jounce hoses with new hoses that have a revised braid material at no cost. The vehicles equipped with hybrid engines are excluded from the recall because the internal hose pressure is much lower due to the regenerative braking provided by the hybrid brake system. No failures of brake hoses on hybrid vehicles have been reported to ODI or Ford.Ford's actions address ODIs concerns at this time. Hybrid vehicles will be monitored for related failures. The agency reserves the right to take further action if warranted by new circumstances.The 103 ODI numbers cited above can be viewed at NHTSA.gov under the following ID numbers:11511014, 11510867, 11510318, 11509030, 11505993, 11504989, 11504400, 11502147, 11502082, 11501820, 11501283, 11498439, 11498296, 11496842, 11496335, 11494931, 11494851, 11494252, 11493001, 11492084, 11492070, 11491444, 11491274, 11488858, 11488027, 11487627, 11487416, 11487233, 11486150, 11484924, 11484526, 11484080, 11483948, 11483926, 11483739, 11483723, 11482773, 11482690, 11481077, 11480788, 11480294, 11480052, 11479338, 11479334, 11479252, 11479247, 11479187, 11479094, 11479048, 11478985, 11478953, 11478729, 11478216, 11476892, 11476282, 11470558, 11468994, 11467109, 11466294, 11462746, 11461217, 11456065, 11455367, 11444848, 11436419, 11436376, 11430685, 11428329, 11425083, 11421026, 11420738, 11420735, 11420298, 11418197, 11403926, 11397549, 11366991, 11366757, 11361016, 11359968, 11354569, 11352165, 11350344, 11348799, 11343929, 11343205, 11331947, 11329020, 11319596, 11310529, 11292271, 11288455, 11254787, 11253479, 11253244, 11234622, 11230669, 11230050, 11228240, 11221111, 11143630, 11129392 and 11120228.