TL* THE CONTACT OWNS A 2006 FORD FREESTYLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH AND APPROACHING A TRAFFIC STOP, THE VEHICLE SURGED FORWARD ABNORMALLY. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 124,000. THE…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD FREESTYLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH AND APPROACHING A TRAFFIC STOP, THE VEHICLE SURGED FORWARD ABNORMALLY. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 124,000. THE CURRENT MILEAGE WAS APPROXIMATELY 125,500. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10480889
79,000 miles · Oct 15, 2012
Fuel/propulsion SystemVehicle Speed Control
MY CAR WAS PARKED AND IDLING WITH THE AIR CONDITIONING ON (HUSBAND WAS IN THE PASSENGER'S SEAT, AND KIDS IN THE BACK AND IT WAS VERY HOT), I GOT INTO THE CAR, PUT IT IN TO REVERSE WITH MY FOOT ON THE BRAKE AND IT SURGED BACKWARDS GOING VERY FAST. IT ALMOST HIT A LADY BUT I WAS ABLE TO SLAM DOWN HARD ON THE BRAKES AND STOP IT. I …
Read full complaint
MY CAR WAS PARKED AND IDLING WITH THE AIR CONDITIONING ON (HUSBAND WAS IN THE PASSENGER'S SEAT, AND KIDS IN THE BACK AND IT WAS VERY HOT), I GOT INTO THE CAR, PUT IT IN TO REVERSE WITH MY FOOT ON THE BRAKE AND IT SURGED BACKWARDS GOING VERY FAST. IT ALMOST HIT A LADY BUT I WAS ABLE TO SLAM DOWN HARD ON THE BRAKES AND STOP IT. I THEN DROVE IT LIMPING ALONG BECAUSE IT WOULDN'T' SHIFT, TO THE NEAREST DEALER. THERE THEY REPLACED THE THROTTLE BODY AND SOME FLUIDS AND CHARGED ME 1000.00. IT HASN'T HAPPENED SINCE BUT NOW THAT I KNOW IT IS A COMMON PROBLEM AND CAN REOCCUR, I AM LOOKING FOR ANOTHER VEHICLE TO REPLACE THIS ONE. *TR
NHTSA ODI #10480112
86,000 miles · Sep 24, 2012
Vehicle Speed Control
I WAS PULLING IN TO WALMART PARKING LOT PULLED UP BEHIND A PARKED VEHICLE I WAS ALMOST STOPPED WHEN MY CAR ACCELERATED IT WAS ALMOST LIKE SOME ONE PUSHED MY GAS PEDAL TO THE FLOOR I HAD TO JUMP ON THE BRAKE PEDAL WITH BOTH FEET THEN THE CAR STALLED AND WHEN I RESTARTED THE CAR I HAD NO POWER I HAD TO SHUT THE CAR OFF THEN RESTAR…
Read full complaint
I WAS PULLING IN TO WALMART PARKING LOT PULLED UP BEHIND A PARKED VEHICLE I WAS ALMOST STOPPED WHEN MY CAR ACCELERATED IT WAS ALMOST LIKE SOME ONE PUSHED MY GAS PEDAL TO THE FLOOR I HAD TO JUMP ON THE BRAKE PEDAL WITH BOTH FEET THEN THE CAR STALLED AND WHEN I RESTARTED THE CAR I HAD NO POWER I HAD TO SHUT THE CAR OFF THEN RESTARTED IT AGAIN THEN IT WAS FINE. *TR
NHTSA ODI #10476864
60,000 miles · Sep 22, 2012
Vehicle Speed ControlCrash
WHILE STOPPED IN A LINE OF TRAFFIC TO GET INTO A PARKING LOT FOR A NFL FOOTBALL GAME, WHILE HAVING MY FOOT ON THE BRAKE THE VEHICLE REVVED UP AND LUNGED FORWARD BUMPING INTO THE CAR IN FRONT OF ME. AFTER PULLING OVER AND TAKING EACH OTHERS INFORMATION, AFTER GETTING BACK INTO THE CAR AND DRIVING TO PARKING SPACE THE CAR SURGED A…
Read full complaint
WHILE STOPPED IN A LINE OF TRAFFIC TO GET INTO A PARKING LOT FOR A NFL FOOTBALL GAME, WHILE HAVING MY FOOT ON THE BRAKE THE VEHICLE REVVED UP AND LUNGED FORWARD BUMPING INTO THE CAR IN FRONT OF ME. AFTER PULLING OVER AND TAKING EACH OTHERS INFORMATION, AFTER GETTING BACK INTO THE CAR AND DRIVING TO PARKING SPACE THE CAR SURGED AND LUNGED FORWARD WHEN TURNING THE WHEEL TO ENTER PARKING SPACE. *TR
NHTSA ODI #10476735
107,000 miles · Sep 21, 2012
Vehicle Speed Control
VEHICLE LUNGES WHILE AT ZERO OR LOW SPEEDS SOMETIMES ALMOST CAUSING A COLLISION WITH OTHER VEHICLES OR STATIONARY ITEMS. *TR
NHTSA ODI #10476682
56,000 miles · Sep 14, 2012
Vehicle Speed Control
I WAS BACKING UP IN THE DRIVE WAY AND THE CAR ACCELERATED ON IT'S OWN THE ENGINE RPGS WENT TO 4000 WITHOUT ME PRESSING THE GAS. THE CALL CONTINUED TO ACCELERATE UNTIL I PRESSED BRAKES AND IT STALLED. *TR
NHTSA ODI #10475471
Mileage unknown · Sep 14, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2006 FORD FREESTYLE. THE CONTACT STATED THAT THE VEHICLE WOULD CONTINUE TO ABNORMALLY ACCELERATE WHEN THE ACCELERATOR PEDAL WAS RELEASED. THE CONTACT ALSO STATED THAT A WRENCH WARNING LIGHT ILLUMINATED AFTER THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD FREESTYLE. THE CONTACT STATED THAT THE VEHICLE WOULD CONTINUE TO ABNORMALLY ACCELERATE WHEN THE ACCELERATOR PEDAL WAS RELEASED. THE CONTACT ALSO STATED THAT A WRENCH WARNING LIGHT ILLUMINATED AFTER THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 102,385.
NHTSA ODI #10475376
17,800 miles · Sep 13, 2012
Vehicle Speed Control
THE CAR LUNGES AT LOW SPEEDS (AROUND 5 MPH), WHEN IN BOTH DRIVE GEAR AND REVERSE. IT HAPPENS EVERY TIME THE CAR IS PUT IN AND OUT OF GEAR. NO CHECK ENGINE LIGHT IS DISPLAYED. *TR
NHTSA ODI #10475354
93,800 miles · Sep 10, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2006 FORD FREESTYLE. THE CONTACT STATED THAT WHILE STOPPED WITH THE BRAKES APPLIED, THE ENGINE RPMS INCREASED TO 3,000 AS THE VEHICLE LUNGED FORWARD ABNORMALLY. THE VEHICLE THEN STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MI…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD FREESTYLE. THE CONTACT STATED THAT WHILE STOPPED WITH THE BRAKES APPLIED, THE ENGINE RPMS INCREASED TO 3,000 AS THE VEHICLE LUNGED FORWARD ABNORMALLY. THE VEHICLE THEN STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 93,800. THE CURRENT MILEAGE WAS 94,000.
NHTSA ODI #10474460
Mileage unknown · Sep 5, 2012
Engine And Engine CoolingVehicle Speed Control
MY CAR ACCELERATES SOMETIMES WHILE MY FOOT IS ON THE BRAKE PEDAL. IT FEELS LIKE IT IS JUMPING FORWARD OR SOMETHING. ALSO WHEN I TURN ON MY AIR CONDITION MY CAR, IF IN MOTION, WILL START TO JUMP FORWARD EVEN THOUGH YOU HAVE YOUR FOOT ON THE BRAKE. IT EVEN CUT OFF ON ME SEVERAL TIMES WITH THE AIR CONDITIONING ON. I NOW JUST DRIVE …
Read full complaint
MY CAR ACCELERATES SOMETIMES WHILE MY FOOT IS ON THE BRAKE PEDAL. IT FEELS LIKE IT IS JUMPING FORWARD OR SOMETHING. ALSO WHEN I TURN ON MY AIR CONDITION MY CAR, IF IN MOTION, WILL START TO JUMP FORWARD EVEN THOUGH YOU HAVE YOUR FOOT ON THE BRAKE. IT EVEN CUT OFF ON ME SEVERAL TIMES WITH THE AIR CONDITIONING ON. I NOW JUST DRIVE WITHOUT AIR AT ALL BECAUSE I AM SCARED THAT MY CAR WILL JUST STOP ON ME. ALSO MY AIR ONLY WORKS ON THE HIGHEST LEVEL. *TR
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
2006 Ford Freestyle Problems, Complaints & Recalls | Skip That Year
Illustration