Vehicle Speed Control. Review the 602 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 484 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

42 crash reports10 fire reports10 injury reports

Seats complaints

3 reports

Clear category filter

60,000 miles · Jan 23, 2017

Electrical SystemSeatsStructure

Read full complaint

THE DRIVER SIDE PASSENGER DOOR SEAL IS FAULTY, LETTING WATER GET INTO THE DOOR CAUSING IT TO FREEZE AND RUST. THE ELECTRICAL FOR THE DRIVER HEATED SEAT KEEPS MALFUNCTIONING CAUSING IT TO KEEP BREAKING. THE LEVERS THAT FLIP THE SECOND AND THIRD ROW SEATING HAVE BECOME FAULTY AND WILL NO LONGER WORK. LASTLY, THE ALL-WHEEL DRIVE COMPONENT ON MY VEHICLE STOPPED WORKING WHILE I WAS DRIVING. IT WAS DURING THE WINTER AND THE ROADS WERE ICY SO IT CAUSED ME TO HAVE LESS TRACTION AND FISH TAIL. *TR

NHTSA ODI #10947119

70,000 miles · Aug 19, 2011

Seats

THE SEAT LOCKS IN PLACE S O THAT IT CANNOT BE RAISED. THEREFORE, NO ONE CAN SIT IN THE THIRD ROW OF SEATS.

NHTSA ODI #10421709

3,000 miles · Nov 16, 2006

Seats

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS ON ROUGH ROAD CONDITIONS, THE FRONT DRIVER SIDE HEAD REST RESTRAINT MOVED UP AND DOWN WITHOUT WARNING. THE VEHICLE WAS INSPECTED BY A DEALER WHO WAS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS ALERTED.

NHTSA ODI #10173641

Official recalls

06V383000 · Latches/locks/linkages:doors:latch

Oct 5, 2006

ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.

Consequence & remedy

Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.

Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE11018 · Idle Instability

Opened May 11, 2011 · Closed Feb 7, 2013

Status: closed (inferred from source dates) · Vehicle Speed Control

On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in