1999 Ford Ford Truck

PREMATURE PERFORATED CORROSION OF ENTIRE STEEL BRAKE LINE OF MY 1999 FORD EXPEDITION EDDIE BAUER 5.4L 4WD WAS DISCOVERED AFTER MY BRAKE WARNING LIGHT WENT ON WITHOUT ANY PERCEIVED PROBLEM WITH BRAKING NOTED. INSPECTION OF THE BRAKES BY A NON-DEALER VENDOR REVEALED A WELL MAINTAINED BRAKE SYSTEM EXCEPT FOR SEVERE CORROSION OF THE ENTIRE BRAKE LINE SYSTEM WITH A LEAK ABOVE THE GAS TANK SUSPECTED. NO REPAIRS WERE STARTED AND THE VEHICLE WAS IMMEDIATELY DELIVERED TO THE DEALER (AL PACKER FORD). THE DEALER REPORTED THAT THE BRAKE LINE HAD CORRODED THROUGH CLOSE TO THE MASTER CYLINDER AND WAS LEAKING BRAKE FLUID DOWN THE ENTIRE LENGTH OF THE BRAKE LINE. CUSTOMER HAS AUTHORIZED REPLACEMENT OF THE ENTIRE CORROSION RIDDEN BRAKE LINE SETUP AT AN ESTIMATED COST OF $700.00 + THAT SO FAR IS NOT COVERED BY FORD. THE DEALER HAS BEEN INSTUCTED TO HOLD ALL REMOVED PARTS FOR INSPECTION. REVIEW OF REPORTS SUBMITTED BY OTHERS RE BRAKE LINE CORROSION AND BRAKE FAILURE EVENTS AND REPORT OF THIS EVENT TO FORD FOR CONSIDERATION FOR COVERAGE AS A MANUFACTURER DEFECT IN MATERIAL (INFERIOR STEEL BRAKE-LINE SUSCEPTIBLE TO RUST PERFORATING CORROSION) DID NOT GENERATE AN OFFER FOR COVERAGE OR TECHNICAL BULLETIN ADVISING THESE COMPONENTS BE CLOSELY INSPECTED FOR THIS POTENTIALLY LIFE-THREATENING AND UNEXPECTED SOURCE OF BRAKE FAILURE AS WELL AS A POTENTIAL RISK FOR UNEXPECTED VEHICLE FIRE. I REQUEST A TECHNICAL BULLETIN AND/OR RECALL FOR INSPECTION FOR CORROSION OF BRAKELINES ON ALL FORD EXPEDITIONS. HOPEFULLY WE MAY SAVE SOME-ONE'S LIFE FROM TRAGEDY. *TR

RE: FORD MOTOR COMPANY TRUCK WINDSHIELDS NOT SEALED PROPERLY WHILE DRIVING IN A HARD RAIN, I HAVE A 99 FORD EXPEDITION AND IT SOMEHOW HAD WATER LEAK INTO THE FUSE PANEL SHORTING IT OUT, ALSO SHORTED OUT THE GEM AND THE PCM. THERE WAS AN ELECTRICAL BURNING SMELL, SMOKE FROM DASH. THERE WERE NO FLAMES, HOWEVER SOMETHING WAS BURNING SOMEWHERE. TRUCK QUIT RUNNING. BROKE DOWN 165 MILES AWAY FROM HOME. FIRST WE TRIED A "NEW" BATTERY, TRIED JUMPING IT NOTHING WORKED. WE HAD IT TOWED TO THE CLOSEST FORD DEALER - LAKE FORD IN LEWISTOWN, PA. THEY SAY IT NEEDS A NEW FUSE PANEL, GEM, PCM OVER $800 AND THIS DOESN'T EVEN GUARANTEE A RUNNING VEHICLE. ALSO THEY SAY THAT EVEN IF THE VEHICLE DOES START THERE WILL BE NO AIRBAGS! OR RADIO (THEY WERE SHORTED INTERNALLY). THE SAFETY ISSUE I'D LIKE TO REPORT IS THAT WHEN THIS HAPPENS THE TRUCK CUTS OUT INSTANTLY. THE FIRST TIME THIS HAPPENED APPROX. 6 MOS. BEFORE THIS INCIDENT . AGAIN DRIVING IN A HARD RAIN I WAS PULLING OUT INTO ONCOMING TRAFFIC. LUCKILY I DIDN'T PULL ALL THE WAY OUT IN FRONT OF THE TRAFFIC BEFORE MY TRUCK JUST QUIT RUNNING. HAD TO PUSH IT OFF THE ROAD AND A JUMP GOT IT STARTED THIS TIME. AT THIS TIME I HAD NO IDEA WHAT CAUSED THIS. SINCE THEN I TALKED TO OTHERS WHO HAVE HAD THE SAME EXACT PROBLEM. THEY SAID FORD KNOWS EXACTLY WHAT IT IS AND THEY EVEN HAVE A NAME FOR IT - THEY CALL IT "WATER INTRUSION". I URGE YOU TO HAVE THE FORD MOTOR COMPANY PUT IN A RECALL ON THIS BEFORE SOMEONE GETS KILLED OUT THERE!. *NM

DRIVING NORMALLY WHEN LOAD SOUND CAME OUT FROM UNDER HOOD. ACCELERATING SLIGHTLY TO GET OFF OF THE ROAD SOUNDED LIKE BACK FIRING. EXPEDITION WAS TOWED TO MECHANICS. TOW TRUCK OPERATOR ALSO MENTIONED THAT HE HIMSELF HAD TOWED BETWEEN 15 AND 20 EXPEDITIONS DUE TO THIS SPARK PLUG PROBLEM AND WE LIVE IN A SMALL COMMUNITY. AFTER EXAMINING, MECHANIC EXPLAINED THAT ONE HALF OF THE HEAD NEEDED TO BE REPLACED DUE TO THE SPARK PLUG COMING OUT OF THE HEAD AND STRIPING THE THREADS ON ITS WAY OUT. HE CALLED FELLOW MECHANIC THAT WORKS AT FORD WHO TOLD HIM HE HAS REPLACED MANY FORDS WITH THE EXACT SAME PROBLEM. THREADS ARE NOT ADEQUATE FOR HOLDING SPARK PLUG IN HEAD. OTHER DAMAGE WAS DONE UNDER THE HOOD DUE TO EJECTION OF PLUG. CHANCES ARE GOOD THAT THE EXACT SAME PROBLEM COULD HAPPEN TO THE OTHER SIDE A DIRECT QUOTE FROM MY MECHANIC. *JB

VEHICLE EXPERIENCES CONTINUED PROBLEMS WITH SUSPENSION STABILITY AND CONTROL, SEVERAL REPLACEMENTS OF SUSPENSION/STEERING COMPONENTS...TIE ROD/S BENT/BROKEN CAUSEING TO LOSE CONTROL AT LOW SPEED (THANK GOD I WASNT GOING FASTER AT THE TIME) WHEELS FLOPPED ON ITS SIDES CONTINUED 4 WHEEL ALIGNMENT AND REPLACEMENT OF SEVERAL FRONT END,ARMS, JOINTS, TIE RODS, FRONT END REPAIRS COSTING $1500... PLUS...VEHICAL SWAYS ALL OVER THE ROAD AND PULLS RIGHT AND THEN PULLS LEFT WITH A LOT OF PLAY IN STEERING WHEEL AFTER SEVERAL 4/WHEEL ALIGNMENTS. I HAVE HAD THE VEHICAL INTO COURTSEY FORD MATTYDALE NY SEVERAL TIMES NOW TO FIX FRONT END PROBLEMS \ THIS IS A VERY DANGEROUS SITUATION AND SHOULD BE DEFINITELY A RECALL ON THE FORD EXPIDITIONS. FUTHERMORE, ALL WHEEL DRIVE / 4 WHEEL DRIVE OFTEN IS LOCKED INTO 4 WHEEL WILL NOT COME OUT OF 4 WHEEL DRIVE. ***ALSO, DIGITAL DASH SHORT OR LOSS OF USE LIGHTS ON DASH GOING OUT INCLUDING ODOMETER OFTEN GO OUT AND THE TURN BACK ON I HAVE SEEN SEVERAL COMPLAINTS REGARDING ALL OF THE ABOVE...FOR THE 99 FORD EXPIDITIONS. *** THE BRAKE PEDAL ALSO LOCKS UP IF/WHEN THE TIRE SPIN OR ENGINE REVVS UP YOU TRY TO APPLY THE BREAKS HOWEVER, THE BREAK PEDAL WILL NOT MOVE IT'S LOCKED AND WILL NOT MOVE UNLIT TIRES STOP SPINNING OR ENG. STOPS REVVING...ANTI-LOCK PROBLEM???*AK

THERE WAS A SUPER CHARGER INTER COOLER LEAK IN 1999, FORD TRUCK. IT WAS SPILLING COOLANT DIRECTLY INTO THE MOTOR INTAKE. THIS WAS A SAFETY/EMISSIONS PROBLEM WITH COOLANT CLOGGING THE O2 SENSOR AND CATALYTIC CONVERTER. CONSUMER BOUGHT A USED VEHICLE, AND RECALL REPAIRS WERE NOT DONE. FORD CONTRACT NOR AFTERMARKET SERVICE CONTRACT COVERED THIS PROBLEM. *AK