Electrical System. Review the 183 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

34 crash reports13 fire reports24 injury reports

Structure complaints

14 reports

Clear category filter

Mileage unknown · Dec 15, 2006

Electrical SystemEngine And Engine CoolingExterior Lighting

Read full complaint

2004 FOCUS BELT TENSIONER BROKE AND BATTERY FAILED. *TS THE FRONT DOOR HAD TO BE ALIGNED AND THE DOOR SEAL WAS REPLACED. THE THROTTLE CABLE HAD TO BE RE-ROUTED DUE TO THE CABLE BINDING. THE FRONT WHEEL BEARINGS WERE REPLACED. THE LEFT REAR MOTOR ASSEMBLY WAS REPLACED, THE 3RD BRAKE LIGHT LENS AND RIGHT SIDE CV AXLE WAS REPLACED. THE TRANSMISSION STARTED SHIFTING ERRATICALLY. THE CONSUMER ATTEMPTED TO MAKE A TURN, AND THE TRANSMISSION WOULD SHIFT FROM 1ST TO 2ND GEAR UNTIL THE ENGINE REVVED UP PAST 6000 RPM. THE CONSUMER WAS TOLD THERE WAS A PROBLEM WITH THE SERVO PISTONS. THE TRANSMISSION WAS EVENTUALLY REPAIRED. THE BATTERY FAILED 5 TIMES. *JB

NHTSA ODI #10177475

30,900 miles · Oct 24, 2005

Service Brakes, HydraulicStructureVehicle Speed Control

DT: THE CONSUMER STATED THAT WHILE DRIVING, THE CRUISE CONTROL ACTIVATED BY ITSELF AND CAUSED THE VEHICLE TO ACCELERATE. THE ACCELERATION WAS RAPID IN NATURE. THE CONTACT WAS NOT ATTEMPTING TO USE THE CRUISE CONTROL AT THAT TIME, SHE WAS APPROACHING A STOP SIGN. THE VEHICLE HAS NOT BEEN TO DEALER OR A MECHANIC FOR A DIAGNOS…

Read full complaint

NHTSA ODI #10140610

Mileage unknown · Sep 20, 2004

Structure

THE REAR DOORS ARE INTERMITTENTLY INOPERABLE. THEY SOMETIMES JAM AND WILL NOT OPEN, AND THEN THERE ARE TIMES THE WON'T SHUT. HOWEVER, THERE HAVE BEEN TIMES WHILE DRIVING THAT DOOR WILL JUST OPEN ON IT OWN.*AK

NHTSA ODI #10092721

350 miles · Aug 4, 2004

StructureInjury

THE CIGARETTE LIGHTER AFTER BEING PUSHED IN GETTING HOT POPPED OUT OF THE HOLDER AND LANDED EITHER ON THE OCCUPANT'S LAP OR ON THE CARPETING. WHEN THIS WAS SHOWN TO THE RENTAL COMPANY, AND A DEMONSTRATION WAS DONE, THE LIGHTER BURNED THE REPRESENTATIVE'S LEGS. THIS WAS A BUDGET RENTAL VEHICLE.*AK

NHTSA ODI #10087148

Official recalls

05V030000 · Latches/locks/linkages:doors:latch

Feb 1, 2005

CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.

Consequence & remedy

Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.

Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ10001 · Fleet Vehicle Recall Completion Audit

Opened Nov 18, 2010 · Closed Dec 28, 2015

Status: closed (inferred from source dates) · Unknown Or Other

On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.