2003 FORD FOCUS. CONSUMER WRITES IN REGARDS TO INADEQUATE STRUCTURAL STEEL. *LD THE CONSUMER STATED THE STEEL ON THE CONTROL ARMS WERE POORLY MANUFACTURED. WHILE DRIVING THE VEHICLE, IT SUDDENLY DEAD STOPPED, TURNED RIGHT, MAKING A CRACKING NOISE. THE CONTROL ARM HAD SNAPPED AND DUG INTO THE TAR, BRAKING THE TIE ROD AND CREAS…
Read full complaint
2003 FORD FOCUS. CONSUMER WRITES IN REGARDS TO INADEQUATE STRUCTURAL STEEL. *LD THE CONSUMER STATED THE STEEL ON THE CONTROL ARMS WERE POORLY MANUFACTURED. WHILE DRIVING THE VEHICLE, IT SUDDENLY DEAD STOPPED, TURNED RIGHT, MAKING A CRACKING NOISE. THE CONTROL ARM HAD SNAPPED AND DUG INTO THE TAR, BRAKING THE TIE ROD AND CREASING THE BREAKLINE. *JS
NHTSA ODI #11311272
109,000 miles · Sep 12, 2018
SteeringStructureSuspension
I WAS LEAVING A PARKING LOT DOING NO MORE THAN 5 MPH WHEN THE CAR MADE A SUDDEN JERKING MOTION. HAD THE CAR TOWED TO A GARAGE. THE DAMAGES WERE SEVERE RUST, SUB FRAME ROTTED, RIGHT FRONT AXLE BROKEN, RIGHT FRONT CONTROL ARM BROKEN, SWAY BAR BENT. THE TOW DRIVER SAID THE WHEELS COULD HAVE FALLEN OFF MY CAR AND I COULD HAVE BEEN S…
Read full complaint
I WAS LEAVING A PARKING LOT DOING NO MORE THAN 5 MPH WHEN THE CAR MADE A SUDDEN JERKING MOTION. HAD THE CAR TOWED TO A GARAGE. THE DAMAGES WERE SEVERE RUST, SUB FRAME ROTTED, RIGHT FRONT AXLE BROKEN, RIGHT FRONT CONTROL ARM BROKEN, SWAY BAR BENT. THE TOW DRIVER SAID THE WHEELS COULD HAVE FALLEN OFF MY CAR AND I COULD HAVE BEEN SERIOUSLY INJURED OR KILLED BECAUSE OF THE THING THAT WENT WRONG. I PUT MYSELF AND MY FAMILY IN DANGER WITH THIS DEATH TRAP. SUPPOSEDLY THIS CAR WAS INSPECTED FEBRUARY 2018. WITH EVERYTHING THAT WENT WRONG WITH IT AND THE DAMAGES, I DONT SEE HOW IT COULD HAVE BEEN. I BELIEVE THERE TO BE FRAUD INVOLVED AND BELIEVE THIS MATTER SHOULD BE INVESTIGATED FURTHER FOR PUTTING LIVES IN DANGER. I PAID $3,000 FOR THIS CAR IN THE MIDDLE OF FEB. 2018. IT IS NOW AUGUST AND IT HAD INCURRED $3,000 IN DAMAGES. I SOLD THE CAR FOR SALVAGE AT $125
NHTSA ODI #11128842
60,780 miles · Aug 9, 2018
SuspensionCrash
SKIDS TO SIDE AND SPINS ON WET ROAD EVEN IF THE TIRES ARE GOOD EVEN AT 30MPH. TOO MUCH SIDE WAYS SHIFT ON LITTLE BUMPY ROADS.
NHTSA ODI #11118867
127,000 miles · May 2, 2017
Suspension
TL* THE CONTACT OWNS A 2003 FORD FOCUS. WHILE DRIVING 65 MPH, THE CONTACT DROVE OVER A BRIDGE EXPANSION JOINT AND THE VEHICLE FISHTAILED. THE CONTACT STATED THAT THE VEHICLE BECAME ALMOST UNCONTROLLABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE REAR SHOCKS NEEDED TO BE R…
Read full complaint
TL* THE CONTACT OWNS A 2003 FORD FOCUS. WHILE DRIVING 65 MPH, THE CONTACT DROVE OVER A BRIDGE EXPANSION JOINT AND THE VEHICLE FISHTAILED. THE CONTACT STATED THAT THE VEHICLE BECAME ALMOST UNCONTROLLABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE REAR SHOCKS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 127,000.
NHTSA ODI #10983051
34,000 miles · Nov 4, 2016
Electrical SystemService BrakesSteering
THE SUB FRAME BROKE WHILE DRIVING THE CAR. ENTIRE SUB FRAME HAD TO BE REPLACED. ALMOST CAUSED AN ACCIDENT. STRUTS HAD TO BE REPLACED. CALIPER AND ROTOR HAD TO BE REPLACED. CONTROL ARM HAD TO BE REPLACED. JUST REPLACED THE IGNITION SWITCH TUMBLERS AFTER THE SWITCH LOCKED UP AND REFUSED TO WORK. THERE ARE NO RECALLS LISTED FOR TH…
Read full complaint
THE SUB FRAME BROKE WHILE DRIVING THE CAR. ENTIRE SUB FRAME HAD TO BE REPLACED. ALMOST CAUSED AN ACCIDENT. STRUTS HAD TO BE REPLACED. CALIPER AND ROTOR HAD TO BE REPLACED. CONTROL ARM HAD TO BE REPLACED. JUST REPLACED THE IGNITION SWITCH TUMBLERS AFTER THE SWITCH LOCKED UP AND REFUSED TO WORK. THERE ARE NO RECALLS LISTED FOR THIS CAR. SERVICE MANAGER SAID THAT FOCUS ARE NOTORIOUS FOR THESE PROBLEMS. CAR HAS 34,000 MILES ON IT. THE BRAKE LINE RUNNING FROM THE FRONT OF THE CAR TO THE REAR RUSTED OUT CAUSING A LOSE OF BRAKES. THE CAR IS DANGEROUS. *TR
NHTSA ODI #10924347
150,000 miles · Apr 18, 2016
Suspension
REAR SUB FRAME CROSSMEMBER RUSTED AWAY AND BROKEN CAUSING REAR OF CAR TO BANG AND TWIST WHILE DRIVING.
NHTSA ODI #10859996
98,400 miles · Mar 23, 2015
Suspension
BREAK IN FRONT DRIVER-SIDE SUSPENSION COIL WHILE BACKING UP. *TR
NHTSA ODI #10701253
151,000 miles · Nov 11, 2014
Suspension
I TOOK MY CAR TO HAVE A OIL CHANGE, AND MY MECHANIC SAW THAT THE LEFT SIDE REAR SUSPENSION CROSS STABILIZER BAR IS RUSTED AND THE BOLTS ARE RUSTED. HE SAID TO CALL FORD THERE SHOULD BE A RECALL. THERE IS NOT SO I CALLED FORD AND THEY JUST FILED A COMPLAINT.I CAN NOT TAKE MY CAR ON THE INTERSTATE OR GO OVER 40 MPH IF I DID MY MEC…
Read full complaint
I TOOK MY CAR TO HAVE A OIL CHANGE, AND MY MECHANIC SAW THAT THE LEFT SIDE REAR SUSPENSION CROSS STABILIZER BAR IS RUSTED AND THE BOLTS ARE RUSTED. HE SAID TO CALL FORD THERE SHOULD BE A RECALL. THERE IS NOT SO I CALLED FORD AND THEY JUST FILED A COMPLAINT.I CAN NOT TAKE MY CAR ON THE INTERSTATE OR GO OVER 40 MPH IF I DID MY MECHANIC SAID IF THE RIGHT SIDE BROKE OFF THE CAR WOULD FLIP. MY CONCERN IS DOES SOMETHING HAVE TO HAPPEN FIRST I TRANSPORT MY GRAND KIDS BUT I CAN'T GO OVER 40. CAN YOU HELP ME WITH THIS. *TR
NHTSA ODI #10654150
86,000 miles · Jan 13, 2014
SteeringSuspension
WHEN DRIVING ON SNOW OR WET ROADWAYS THE HANDLING BECOMES VERY UNSTABLE AT SPEEDS OVER 35 MPH WITH THE REAR OF THE VEHICLE WANTING TO VEER/PITCH SIDEWAYS CAUSING THE DRIVER TO HAVE TO QUICKLY OVERSTEER TO AVOID ONCOMING TRAFFIC. VEHICLE HAS 85,000 MILES, NEW GOODYEAR TIRES. THIS CAR IS NOT SAFE TO DRIVE IN THESE CONDITIONS AND I…
Read full complaint
WHEN DRIVING ON SNOW OR WET ROADWAYS THE HANDLING BECOMES VERY UNSTABLE AT SPEEDS OVER 35 MPH WITH THE REAR OF THE VEHICLE WANTING TO VEER/PITCH SIDEWAYS CAUSING THE DRIVER TO HAVE TO QUICKLY OVERSTEER TO AVOID ONCOMING TRAFFIC. VEHICLE HAS 85,000 MILES, NEW GOODYEAR TIRES. THIS CAR IS NOT SAFE TO DRIVE IN THESE CONDITIONS AND IS GETTING MORE UNSTABLE EVEN ON DRY SURFACES MAKING THE VEHICLE FEEL LIKE IT'S FOLLOWING EVERY GROOVE IN THE ROADWAY. NUMEROUS COMPLAINTS SEEM TO BE EVERYWHERE ON THE INTERNET. HOW MANY ACCIDENTS/INJURIES/DEATHS IS REQUIRED BEFORE FORD IS MADE TO TAKE THIS SERIOUSLY AND STOP PUTTING SUB STANDARD PARTS ON THEIR CARS? *TR
NHTSA ODI #10559666
132,000 miles · May 29, 2013
Suspension
RIGHT FRONT COIL SPRING BROKE. WHILE CHECKING CONSUMER REVIEWS ON AN AUTO PARTS WEBSITE FOR A REPLACEMENT, OTHERS HAVE HAD THE SAME SPRING FAILURE. *TR
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
2003 Ford Focus Problems, Complaints & Recalls | Skip That Year
Illustration