2003 Ford Focus

TL*- CONTACT STATED WHILE DRIVING THE 2003 FORD FOCUS LX HE SAW SMOKE COMING FROM UNDERNEATH THE HOOD. THE CONTACT PULLED TO THE SIDE OF THE ROAD AND NOTICED THAT THE VEHICLE WAS ON FIRE. THE FIRE DEPARTMENT STATED THAT THE FIRE COULD HAVE STARTED FROM SOME FAULTY WIRE UNDERNEATH THE HOOD. THE CONTACT COULD PROVIDE PICTURES IF NEEDED. THE FAILURE MILEAGE AND CURRENT MILEAGE WERE BOTH 54,000.*AK

TL*- THE CONTACT OWNS A 2003 FOR FOCUS WITH A CURRENT AND FAILURE ODOMETER READING OF 38,000 MILES. THE CONTACT STATED WHILE DRIVING AT ABOUT 35 MPH UNDER DRY CONDITIONS THE INSTRUMENT PANEL FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER, THEY REPAIRED THE PROBLEM. BUT, WHEN SHE CONTACTED THE MANUFACTURER, THEY STATED THAT THEY WOULD NOT ASSIST HER WITH THIS PROBLEM. WHEN THE CONTACT HAD THE VEHICLE AT DEALER FOR SERVICE THE MECHANIC FOUND THAT THE THIRD BRAKE LIGHT ASSEMBLE MELTED, CAUSING THE BRAKE LIGHT TO FAIL. *AK

A FORD FOCUS WAGON 2003. WHEN I TRYING TO START THE VEHICLE THE IGNITION SWITCH CYLINDER LOCKEDE, WOULD NOT ENGAGE. THE KEY WOULD NOT TURN WHEN INSERTED IN THE LOCK & ICOULD NOT TURN ON THE CAR. THE VEHICLEWAS JUST OVER THREE YEARS OLD. *AK THIS PROBLEM HAPPENED TWO DAYS IN A ROW. CALLED FORD & THEY SAID THERE IS NO RECALL. I SEARCHED GOOGLE FOR ''FORD FOCUS IGNITION LOCKS''. PLEASE NOTE THE FOLLOWING RESULTS COPIED FROM THIS GOOGLE SEARCH ''RESULTS 1 - 10 OF ABOUT 455,000 FOR FORD FOCUS IGNITION LOCKS . (0.39 SECONDS)''. I WAS CONCERNED THAT A FAULTY IGNITION WOULD BE USED IF FORD REPLACED IT SO I CALLED A LOCAL LOCKSMITH. THE OWNER WAS VERY FAMILIAR WITH THE PROBLEM & HAS REPLACED A NUMBER OF FORD VEHICLE IGNITION LOCKS. I HAD THE LOCKSMITH REPLACED MY FOCUS IGNITION. THE COST WAS $240.75. I AM 59 YEARS OLD. MY FAMILY HAS OWNED NUMEROUS CARS & TRUCKS. I HAVE NEVER HAD TO REPLACE AN IGNITION KEY SWITCH IN ANY OTHER VEHICLE ESPECIALLY ONE JUST OVER THREE YEARS OLD. IRONICALLY TO ADD TO MY FRUSTRATION, I JUST PAID OFF THE 36 MONTH CAR LOAN ON THIS FOCUS. ALSO, SENT A LETTER TO FORD MOTOR COMPANY ABOUT THIS PROBLEM TO ATTN: ALAN MULALLY, PRESIDENT & CEO PLUS CC'ED TO WILLIAM CLAY FORD, JR., EXECUTIVE CHAIRMAN & NHTSA HEADQUARTERS, 400 SEVENTH STREET, SW, WASHINGTON, DC 20590 (SENDING VIA MAIL & EMAIL TO NHTSA)

THE KEY STUCK IN THE IGNITION SWITCH ON MY 2003 FOCUS PZEV. WHEN IT FINALLY RELEASED IT WOULD NO LONGER TURN. I HAD THE VEIHICLE TOWED BY AAA AND HAD A AAA LOCKSMITH COME TO REPAIR THE IGNITION WHICH I WAS TOLD IS NOT COVERED UNDER MY WARRENTY, AT A COST OF $300. THE LOCKSMITH SAID IT IS A COMMON PROBLEM ON THE FOCUS. ONE MONTH LATER THE LOCKSMITH HAD TO COME BACK OUT TO REPAIR IT AGAIN. A YEAR LATER I MUST TURN THE KEY BACK A NOTCH TO REMOVE IT FROM THE IGNITION. IT WILL COST ME ANOTHER $300 TO HAVE THE REPAIR REPEATED. THE LOCKSMITH SAYS THAT THE PROBLEM IS WITH THE PART ITSELF AND WILL CONTINUE TO HAPPEN.

I'VE HAD MY 2003 FORD FOCUS WAGON IN TWICE FOR REPAIR OF THE IGNITION LOCK. THE FIRST TIME I HAD THE PROBLEM THE STEERING WHEEL WOULDN'T RELEASE AS THE KEY WOULDN'T FIT INTO THE IGNITION. TOOK IT TO THE DEALER AND THEY REMOVED THE LOCK CYLINDER. IT WAS CLEANED AND LUBED AND OPERATING NORMALLY ON 26 JANUARY 2007. ABOUT A MONTH LATER I WAS HAVING THE SAME PROBLEM. THIS TIME I HAD TO HAVE IT TOWED TO THE DEALER. THIS CAR ONLY HAS 13,000 MILES ON IT! THEY HAD TO DRILL OUT THE IGNITION LOCK CYLINDER AND REPLACE IT. I HOPE THIS TIME IT WILL LAST LONGER THAN A MONTH! THIS WAS A VERY COSTLY SERVICE! $267.00 FOR LABOR AND $99.91 FOR THE PART! I HAVEN'T SEEN ANY RECALLS ON THIS YET BUT IF THEY DO HAVE ONE I'M HOPING TO GET MY MONEY BACK AS THIS HAS BEEN A VERY COSTLY SERVICE TO ME - ALMOST $600.00 TOTAL FOR BOTH INSTANCES! *JB

TL*- THE CONTACT STATED THAT WHEN DRIVING THE 2003 FORD FOCUS THE VEHICLE SHIFTED INTO NEUTRAL, THEN SHIFTED BACK INTO DRIVE. THIS WOULD LAST ANYWHERE FROM A FEW SECONDS TO A COUPLE OF MINUTES. THE CONTACT STATED THAT THE DASHBOARD LIGHTS AND RADIO WOULD FLICKER ON AND OFF, AS WELL AS THE LIGHTING SYSTEM, INCLUDING THE HEADLIGHTS. THE CONTACT STATED THAT THE DOORS WILL ALSO LOCK AND SHE WASUNABLE TO EXIT THE VEHICLE. WHEN THIS HAPPENED SHE ATTEMPTED TO GET OUT OF THE VEHICLE BY MANUALLY HITTING THE UNLOCK SWITCH. THE VEHICLE LOCKS FINALLY OPENED AFTER APPROXIMATELY TWENTY MINUTES. THE MECHANIC ADVISED THE CONTACT TO HAVE ELECTRICAL SYSTEM REPROGRAMMED, WHICH WAS DONE IN NOVEMBER 2006, BUT SHE CONTINUED TO HAVE THE SAME PROBLEMS. THE VEHICLE STALLED WHEN EXITING THE INTERSTATE WHILE DRIVING AT 45 MPH. THERE WERE NO WARNING LIGHTS BEFORE THE VEHICLE LOST POWER. THE CONTACT WAS UNABLE TO RESTART VEHICLE, AND HAD VEHICLE TOWED TO A MECHANIC. THE MECHANIC INFORMED CONTACT HE DID NOT KNOW WHY THE VEHICLE LOST POWER. THE VEHICLE CURRENTLY HAD 57000 MILES. *AK UPDATED 03/30/07. *JB

I HAVE OWNED 3 FORD FOCUS: ONE 2000 AND TWO 2003. ALL THREE VEHICLES HAVE HAD AN IGNITION CYLINDER FAILURE WHICH COST IN EXCESS OF $300 EACH TIME. THE KEY WILL NOT TURN IN THE IGNITION AND THIS HAPPENS WITHOUT WARNING. ON THREE OCCASIONS I HAVE BEEN STRANDED AND HAD TO CALL AAA TO GET BE TO A GARAGE FOR REPAIR. I HAVE CITED ONLY THE MOST RECENT INCIDENT IN THIS COMPLAINT. THIS IS A KNOWN PROBLEM AND I FAIL TO SEE WHY A RECALL WAS NEVER ISSUED. FORD SHOULD BE HELD ACCOUNTABLE. *NM

I HAVE A 2003 FORD FOCUS. THE FAULT IS THAT WHEN I PUT THE KEY IN THE IGNITION, THE KEY WILL NOT TURN AT ALL. IT IS LOCKED IN PLACE. IT HAPPENED ONCE THIS SUMMER ON THIS CAR AND ON A 2002 FOCUS I SOLD TO A FRIEND WHOM WORKS WITH ME. I CALLED THE FORD DEALERSHIP TO SEE IF THEY HAVE SEEN THIS PROBLEM, WHICH THEY HAD. THEY TOLD ME I COULD TAP IT WITH A RUBBER HAMMER TO GET IT TO UNLOCK. SURE THING, IT DID. I CHECKED FOR RECALLS, WHICH NONE WERE FOUND. I CHECKED FOR TSB'S, SURE ENOUGH, THERE ARE NUMEROUS REPORTS OF THIS PROBLEM. THIS APPEARD TO BE A MAJOR DEFECT. I BELIEVE THIS COULD BE A SERIOUS SAFETY PROBLEM IF FOR INSTANCE SOMEONE WENT FOR A DRIVE DURING THE WINTER IN THE REMOTE MOUNTAINS AND STOPED TO GOT FOR A WALK. UPON RETURN, THE DEFECTIVE IGNITION WOULDN'T WORK AND THEY'RE STRANDED. FORD DIDN'T APPEAR TO WANT TO LISTEN TO MY COMPLAINTS. LOOK AT THE TSB'S AND YOU'LL REALLY GET A GOOD PICTURE OF THE VOLUME OF IGNATION PROBLEMS.

MY KEY STOPPED WORKING, OR WOULD ONLY WORK INTERMITTENTLY FOR THE PAST MONTH. I STARTED CARRYING MY SPARE KEY AT ALL TIMES SO I WOULDN'T GET STRANDED. I FINALLY HAD A 2ND KEY MADE ($125 AT DEALERSHIP). THE NEW KEY FAILED TO WORK LATER THE SAME DAY. MORE INTERMITTENT IGNITION PROBLEMS FOR NEXT 2 WEEKS. THIS PAST SATURDAY BOTH KEYS FAILED. WHEN I COULD FINALLY GET THE CAR TO START I CAME HOME AND STARTED RESEARCHING ON WEB. FOUND THIS IS A WIDESPREAD WELL-KNOWN PROBLEM. HAVE APPT. AT DEALERSHIP TOMORROW FOR TOTAL IGNITION REPLACEMENT, MY TIME, MY DIME. IT WILL BE A FEW HUNDRED DOLLARS. I ALREADY WORK A FULL TIME AND PART-TIME JOB TO MAKE ENDS MEET. I CANNOT AFFORD THIS. I CAN'T AFFORD TO BE STRANDED SOMEPLACE IN THE MIDDLE OF THE NIGHT, EITHER. FORD DAMNED WELL KNOWS ABOUT THIS, AND JUST IGNORES THEIR CUSTOMERS. THIS IS THE 5TH FORD I'VE OWNED IN 20 YEARS. IT WILL BE MY LAST. *JB