NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,761 reports65,000 miles · Nov 12, 2008
Electrical System
THIS IS THE 2ND TIME MY IGNITION IN MY 2001 FORD FOCUS HAS HAD TO BE REPLACED. I CALLED THE DEALERSHIP THEY ACKNOWLEDGED THIS IS A RECURRING PROBLEM WITH FORD FOCUSES. I HAVE BEEN STRANDED WITH OUT RESOURCES AND THIS HAPPENS AT RANDOM WITH NO WARNING. THE COST OF TOWING, PARTS, AND LABOR COST AROUND 500.00. I FIND THIS VERY F…
Read full complaint
THIS IS THE 2ND TIME MY IGNITION IN MY 2001 FORD FOCUS HAS HAD TO BE REPLACED. I CALLED THE DEALERSHIP THEY ACKNOWLEDGED THIS IS A RECURRING PROBLEM WITH FORD FOCUSES. I HAVE BEEN STRANDED WITH OUT RESOURCES AND THIS HAPPENS AT RANDOM WITH NO WARNING. THE COST OF TOWING, PARTS, AND LABOR COST AROUND 500.00. I FIND THIS VERY FRUSTRATING THAT FORD WILL NOT RECALL THE IGNITION SWITCH, FULL WELL KNOWING THIS IS A PROBLEM. I FIND THIS TO BE A SAFETY ISSUE, NOT KNOWING IF YOU ARE GOING TO BE STRANDED IN THE MIDDLE OF NO WHERE. IT IS A FINANCIAL BURDEN AS WELL AS AN INCONVENIENCE, THAT AFTER BEING FIXED ONCE SHOULD NOT OCCUR AGAIN WITH IN 2 YEARS, MY CAR ONLY HAS 66,000 MILES ON IT. *TR
NHTSA ODI #10248538
116,200 miles · Nov 4, 2008
Electrical SystemFuel System, OtherLatches/locks/linkages
MY DAUGHTER WAS DRIVING ON THE FREEWAY WHEN HER CAR JUST DIED, WHILE DRIVING. IT STARTED UP AGAIN IMMEDIATELY, BUT IT HAS HAPPENED SEVERAL TIMES IN THE LAST MONTH. I WENT ONLINE TO VIEW RECALLS, AND IT STATED THAT 2001 FORD FOCUS HAD A RECALL ON THIS ISSUE. I ALSO FOUND 2 OTHER ITEMS THAT ARE HAPPENING TO THIS VEHICLE THAT WE…
Read full complaint
MY DAUGHTER WAS DRIVING ON THE FREEWAY WHEN HER CAR JUST DIED, WHILE DRIVING. IT STARTED UP AGAIN IMMEDIATELY, BUT IT HAS HAPPENED SEVERAL TIMES IN THE LAST MONTH. I WENT ONLINE TO VIEW RECALLS, AND IT STATED THAT 2001 FORD FOCUS HAD A RECALL ON THIS ISSUE. I ALSO FOUND 2 OTHER ITEMS THAT ARE HAPPENING TO THIS VEHICLE THAT WERE ALSO RECALLS. I MADE AN APPOINTMENT WITH THE DEALER TO HAVE THESE RECALLS FIXED, BUT WHEN THEY PULLED UP THE VIN NUMBER, THEY SAID THAT THERE WERE NO RECALLS FOR THIS PARTICULAR CAR. THE OTHER RECALL I FOUND WAS THE ELECTRICAL SYSTEM, AND BATTERY FAILURE. I HAVE ALREADY BURNED UP ONE BATTERY BECAUSE OF THIS ISSUE. THE RECALL STATES THAT THE CABES OVERHEAT AND MAY MELT. THIS VEHICLE DID THIS AS WELL. THE OTHER RECALL IS WHERE THE LATCH ON THE BACK DOOR BEGINS TO NOT LATCH PROPERLY, CAUSING THE DOOR TO COME OPEN WHILE DRIVING. THE BACK DOOR WILL NOT LATCH PROPERLY ON THIS VEHICLE EITHER AND AT TIMES WE HAVE TO OPEN AND CLOSE IT SEVERAL TIMES IN ORDER TO GET IT TO LATCH. THESE 3 RECALLS ARE ALL THINGS THAT HAVE HAPPENED ON 2001 FORD FOCUS VEHICLES, WHICH OUR VEHICLE IS, BUT BECAUSE OUR VIN # DOESN'T MATCH THE RECALLS, THEY REFUSE TO FIX THEM. THESE ARE TRUE SAFETY ISSUES. MY DAUGHTER COULD BE KILLED BECAUSE OF THESE ISSUES. HOW CAN I HAVE MY VEHICLE ADDED TO THESE RECALLS? I AM EXTREMELY UPSET AND CONCERNED THAT THESE ITEMS WILL NOT BE ADDRESSES WHEN FORD KNOWS THAT THEY ARE A PROBLEM ON OTHER 2001 FOCUS VEHICLES. I WILL SUE SHOULD SOMETHING HAPPEN TO MY DAUGHTER DUE TO THIS ISSUE AND FORDS UNWILLINGNESS TO CORRECT THE PROBLEMS. *TR
NHTSA ODI #10247661
108,596 miles · Oct 28, 2008
Fuel System, Gasoline
MY VEHICLE, 2001 FORD FOCUS, DISPLAYS ALL THE SYMPTOMS REGARDING A FAULTY FUEL PUMP FUEL DELIVERY MODULE. AT ONE-QUARTER TANK, THE ENGINE WILL STALL ON RIGHT TURNS. DURING EXTENDED DRIVING, THE VEHICLE WILL SURGE AND STUTTER EVENTUALLY STALLING, AND DURING IDLING, THE VEHICLE WILL DROP POWER REQUIRING CONSTANT PRESSURE ON THE A…
Read full complaint
MY VEHICLE, 2001 FORD FOCUS, DISPLAYS ALL THE SYMPTOMS REGARDING A FAULTY FUEL PUMP FUEL DELIVERY MODULE. AT ONE-QUARTER TANK, THE ENGINE WILL STALL ON RIGHT TURNS. DURING EXTENDED DRIVING, THE VEHICLE WILL SURGE AND STUTTER EVENTUALLY STALLING, AND DURING IDLING, THE VEHICLE WILL DROP POWER REQUIRING CONSTANT PRESSURE ON THE ACCELERATOR. I TOOK THE VEHICLE IN FOR SERVICE ON FEB 7, 2007 AND WAS TOLD THAT MY VEHICLE CAME OFF THE ASSEMBLY LINE THREE MONTHS TOO LATE TO HAVE FALLEN UNDER THE EXTENDED WARRANTY. I AM FURIOUS THAT FORD WOULD PROVIDE A 10YR EXTENDED WARRANTY ON IT'S VEHICLES - REGARDLESS OF MILEAGE, BUT WOULD EXCLUDE MODELS THAT HAVE VIN NUMBERS JUST OUTSIDE THE WINDOW OF "KNOWN OCCURRENCE OF PROBLEM". THE VEHICLE HAD STALLED ON A MAJOR HIGHWAY (US95 IN LAS VEGAS CLARK COUNTY), AND FORTUNATELY NO ONE WAS HURT. THE VEHICLE HAD OVER $1300 OF SERVICE COMPLETED DURING THIS INCIDENT, BUT THE ISSUE HAS NOW RE-OCCURRED. SYMPTOMS BEGAN IN LATE SEPTEMBER, AND HAVE GOTTEN PROGRESSIVELY WORSE. I DO NOT FEEL SAFE DRIVING LONG DISTANCES, AS THE VEHICLE HAS BEGUN STALLING AROUND CORNERS AND DURING IDLING. I CURRENTLY CAN NOT AFFORD PAYMENTS ON A NEW VEHICLE, AND WANT FORD TO HONOR ITS PLEDGE FOR SAFETY BY ADMITTING MORE VEHICLES UNDER ITS EXTENDED SERVICE WARRANTY. FORD'S TECHNICAL SERVICE BULLETIN REGARDING THIS DEFECT IS 03N01 AND FORD CLAIMS THAT OVER 671, 000 VEHICLES ARE AFFECTED. I SUSPECT VERY FEW 2001 FOCUSES ARE STILL ON THE ROAD, AND FEWER EVER RECEIVED NOTICE REGARDING THIS "RECALL". I FIND IT HARD TO DEFEND THEIR PATRONIZING POSITION THAT "(THEY'RE) SORRY, BUT THERE IS NOTHING THAT CAN BE DONE". I HAVE SPENT THOUSANDS OF DOLLARS TO KEEP THIS VEHICLE ROAD WORTHY, I AND I REFUSE TO SPEND ONE PENNY MORE. FOR A VEHICLE MODEL THAT HAS HAD SO MANY FLAWS, I AM APPALLED AT THE LACK OF SUPPORT ACTUALLY PROVIDED. I WILL NOTE, THAT FORD WAS VERY HELPFUL IN REPLACING THE IGNITION ASSEMBLY-THREE TIMES. THANKS RECALL ID FROM NHTSA: 03V482000 FORD TSB 03N01. *TR
NHTSA ODI #10246925
95,000 miles · Oct 28, 2008
Electrical System
TO BEST DESCRIBE WHAT IS HAPPENING YOUR WEBSITE HAS A CAMPAIGN FOR MY COMPLAINT HERE: HTTP://WWW-ODI.NHTSA.DOT.GOV/CARS/PROBLEMS/DEFECT/RESULTS.CFM?ACTION_NUMBER=EA02014&SEARCHTYPE=QUICKSEARCH&SUMMARY=TRUE THE NHTSA CAMPAIGN ID NUMBER IS 02V288000. MY WIFE DRIVES A 2001 FORD FOCUS SE. THE BATTERY CABLES AND BATTERY ARE GO…
Read full complaint
TO BEST DESCRIBE WHAT IS HAPPENING YOUR WEBSITE HAS A CAMPAIGN FOR MY COMPLAINT HERE: HTTP://WWW-ODI.NHTSA.DOT.GOV/CARS/PROBLEMS/DEFECT/RESULTS.CFM?ACTION_NUMBER=EA02014&SEARCHTYPE=QUICKSEARCH&SUMMARY=TRUE THE NHTSA CAMPAIGN ID NUMBER IS 02V288000. MY WIFE DRIVES A 2001 FORD FOCUS SE. THE BATTERY CABLES AND BATTERY ARE GOING THROUGH EXTREME CORROSION THAT REQUIRES ME TO CLEAN THE CONNECTIONS AT LEAST ONCE EVERY 2 WEEKS. THE CORROSION IS ALSO CAUSING HEAT THAT IS MELTING THE CABLES INSULATION. WHEN THE CORROSION GOES UNTREATED, WITHIN 2 WEEKS THE CAR WILL NOT START DUE TO BAD CONNECTION. THE PROBLEM RIGHT NOW IS THAT THE ORIGINAL COMPLAINT WAS IN 2002 AND FORD IS NOT RECOGNIZING THE PROBLEM EVEN AFTER ME TELLING THEM ABOUT THE RECALL INFORMATION I LINKED ABOVE. I HAVE CALLED IN A COMPLAINT ALREADY TO THE NHTSA BUT HAVE NOT HEARD BACK. ANY HELP IN DEALING WITH THIS MATTER IS GREATLY APPRECIATED. THANK YOU. *TR
NHTSA ODI #10246924
68,000 miles · Oct 14, 2008
SteeringCrashInjury
WHILE IN CURVE DRIVING 50 MPH STEERING LOCKED UP, NOT SURE IF CAR CUT OFF BUT I WAS UNABLE TO STRAIGHTEN OUT WHEEL RESULTING IN ACCIDENT WHERE I HIT TELEPHONE CRUSHING PELVIS, AND BREAKING MY LEFT ARM.. I SPENT 37 DAYS IN HOSPITAL AND NOW HAVE PLATES AND SCREWS IN MY PELVIS AND ARM. IT HAS BEEN A MONTH SINCE THE ACCIDENT AND I …
Read full complaint
WHILE IN CURVE DRIVING 50 MPH STEERING LOCKED UP, NOT SURE IF CAR CUT OFF BUT I WAS UNABLE TO STRAIGHTEN OUT WHEEL RESULTING IN ACCIDENT WHERE I HIT TELEPHONE CRUSHING PELVIS, AND BREAKING MY LEFT ARM.. I SPENT 37 DAYS IN HOSPITAL AND NOW HAVE PLATES AND SCREWS IN MY PELVIS AND ARM. IT HAS BEEN A MONTH SINCE THE ACCIDENT AND I AM NOW IN A WHEEL CHAIR FOR 2 MONTHS HEALING TIME BEFORE I CAN START THERAPY TO BEGIN WALKING, AND DOCTORS SAY I WILL HAVE TO HAVE A HIP REPLACEMENT IN THE NEXT 2 TO 5 YEARS. HELP ME PLEASE FORD IS RESPONSIBLE FOR THIS I AM 24 YEARS OLD.. *TR
NHTSA ODI #10245330
Mileage unknown · Oct 10, 2008
Electrical System
I WAS TRYING TO LEAVE WORK TO GO HOME. I PUT THE KEY IN THE IGNITION AND THE KEY WOULD NOT TURN. I WAS TOLD TO TAKE IT TO A FORD DEALERSHIP, WHERE THEY TOLD ME I NEEDED TO REPLACE THE IGNITION, A COST OF $500. *TR
NHTSA ODI #10245041
44,959 miles · Oct 9, 2008
Engine And Engine Cooling
NOTICED COOLANT LEAKING ONTO PAVEMENT FOR SEVERAL DAYS. FOR FEAR OF OVERHEATING TOOK IT INTO A PEP BOYS AS WAS CLOSEST REPAIR FACILITY. THEY FOUND THE THERMOSTAT HOUSING (PLASTIC I MIGHT ADD) WAS FAULTY AND WITH PARTS AND LABOR IT CAME TO $455 FOR THE JOB. THE NEAREST FORD DEALER SAID THEY WOULD NEED 2 DAYS TO EVEN LOOK AT TH…
Read full complaint
NOTICED COOLANT LEAKING ONTO PAVEMENT FOR SEVERAL DAYS. FOR FEAR OF OVERHEATING TOOK IT INTO A PEP BOYS AS WAS CLOSEST REPAIR FACILITY. THEY FOUND THE THERMOSTAT HOUSING (PLASTIC I MIGHT ADD) WAS FAULTY AND WITH PARTS AND LABOR IT CAME TO $455 FOR THE JOB. THE NEAREST FORD DEALER SAID THEY WOULD NEED 2 DAYS TO EVEN LOOK AT THE PROBLEM. *TR
NHTSA ODI #10244993
60,160 miles · Oct 8, 2008
Structure
ON 10/3/08 I WAS CHANGING OIL ON MY 2001 FORD FOCUS WITH 60000 MILES AND NOTICED RUST HOLES THROUGH THE FRONT SUBFRAME, WHICH HOLDS THE MOTOR, LOWER WHEEL CONTROL ARMS TO THE CAR BODY. IT IS A VERY CRUCIAL PART THAT SHOULD LAST THE LIFE OF THE CAR. I TOOK THE CAR TO THE DEALER AND THEY SAID THE FRAME WAS DEFECTIVE AND THAT IF …
Read full complaint
ON 10/3/08 I WAS CHANGING OIL ON MY 2001 FORD FOCUS WITH 60000 MILES AND NOTICED RUST HOLES THROUGH THE FRONT SUBFRAME, WHICH HOLDS THE MOTOR, LOWER WHEEL CONTROL ARMS TO THE CAR BODY. IT IS A VERY CRUCIAL PART THAT SHOULD LAST THE LIFE OF THE CAR. I TOOK THE CAR TO THE DEALER AND THEY SAID THE FRAME WAS DEFECTIVE AND THAT IF I HIT A LARGE BUMP THAT THE FRAME MAY BREAK IN HALF AND THAT IT WAS UNSAFE TO DRIVE. THE DEALER SAID THAT THE CAR IS OUT OF THE WARRANTY PERIOD AND THERE WAS NOTHING THEY COULD DO ABOUT IT. I CALLED FORD AND THEY SAID THE SAME THING. THIS REPAIR WAS ESTIMATED BY THE DEALER TO BE AROUND $900.00. THE CAR IS BEING REPAIRED AS I WRITE THIS. I FEEL THAT THIS IS A DEFECTIVE PART FORD HAS USED AND THEY SHOULD INSPECT AND REPLACE THE PART ON THIS MODEL BEFORE ONE DOES BREAK AND SOMEONE GETS HURT. *TR
NHTSA ODI #10244768
113,500 miles · Oct 6, 2008
Electrical System
IGNITION SWITCH WONT TURNED ON. *TR
NHTSA ODI #10244563
108,000 miles · Sep 27, 2008
Electrical SystemFire
2001 FORD FOCUS CAUGHT ON FIRE UNDER THE HOOD, IT STARTED NEAR BATTERY, CAR IS A TOTAL LOSS. *TR
NHTSA ODI #10243630
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration