NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,761 reportsMileage unknown · Jan 12, 2009
Fuel System, Gasoline
2001 FORD FOCUS RECALL FOR FAULTY FUEL PUMP. *NJ THE CONSUMER STATED OVER THE LAST FEW MONTHS THE VEHICLE HAS STALLED SEVERAL TIMES. THE CONSUMER DISCOVERED A RECALL, BUT THE DEALER WANTED TO CHARGE 95.00 JUST TO PERFORM A DIAGNOSTIC TEST TO DETERMINE THE CAUSE OF THE PROBLEM AND THE TEST WOULD ONLY DETECT A FAULTY FUEL PUMP …
Read full complaint
2001 FORD FOCUS RECALL FOR FAULTY FUEL PUMP. *NJ THE CONSUMER STATED OVER THE LAST FEW MONTHS THE VEHICLE HAS STALLED SEVERAL TIMES. THE CONSUMER DISCOVERED A RECALL, BUT THE DEALER WANTED TO CHARGE 95.00 JUST TO PERFORM A DIAGNOSTIC TEST TO DETERMINE THE CAUSE OF THE PROBLEM AND THE TEST WOULD ONLY DETECT A FAULTY FUEL PUMP WHEN IT WAS IN FAILURE MODE. THE TEST WOULD NOT REVEAL A PROBLEM SINCE THE FAILURE ONLY OCCURRED ON THE ROAD AND ON AN INTERMITTENT BASIS. *JB UPDATED 04/20/10 THE CONSUMER STATED FOR YEARS HIS DAUGHTER HAD PROBLEMS WITH THE VEHICLE STALLING. UPDATED 05/07/10.*JB
NHTSA ODI #10254588
168,300 miles · Jan 9, 2009
Electrical SystemEquipment
THIS CAME OUT OF NOWHERE. ONE DAY THE KEY WOULD NOT TURN OVER. IT WAS AS IF THE STEERING COLUMN WAS LOCKED. WE GOOGLED THE PROBLEM AND FOUND THAT IT IS VERY COMMON IN FORD FOCUS'S BUILT BETWEEN 2000-2003. THE QUICK FIX WAS TO CARRY A HAMMER AROUND AND GIVE IT A HIT WHEN THE KEY GETS STUCK. THIS HAS WORKED PRETTY WELL UNTIL THIS …
Read full complaint
THIS CAME OUT OF NOWHERE. ONE DAY THE KEY WOULD NOT TURN OVER. IT WAS AS IF THE STEERING COLUMN WAS LOCKED. WE GOOGLED THE PROBLEM AND FOUND THAT IT IS VERY COMMON IN FORD FOCUS'S BUILT BETWEEN 2000-2003. THE QUICK FIX WAS TO CARRY A HAMMER AROUND AND GIVE IT A HIT WHEN THE KEY GETS STUCK. THIS HAS WORKED PRETTY WELL UNTIL THIS MORNING. IT TOOK ME 15 MINUTES TO START THE CAR. *TR
NHTSA ODI #10254361
65,000 miles · Dec 31, 2008
Fuel System, Gasoline
MY SECOND 2001 FORD FOCUS STATION WAGON(# ) HAS JUST STARTED TO LOSE FUEL PRESSURE SPORADICALLY WHEN DRIVING. SEVERAL TIMES IT HAS CAUSED A LOSS IN BREAK-ABILITY, SINCE THE ENGINE ISN'T RUNNING SMOOTHLY WHEN THE PRESSURE DROPS. IT DEFINATELY CAUSES THE CAR TO STALL AND NOT RUN AS WELL, WHICH COULD LEAD TO A WRECK. MY FIRST 2…
Read full complaint
MY SECOND 2001 FORD FOCUS STATION WAGON(# ) HAS JUST STARTED TO LOSE FUEL PRESSURE SPORADICALLY WHEN DRIVING. SEVERAL TIMES IT HAS CAUSED A LOSS IN BREAK-ABILITY, SINCE THE ENGINE ISN'T RUNNING SMOOTHLY WHEN THE PRESSURE DROPS. IT DEFINATELY CAUSES THE CAR TO STALL AND NOT RUN AS WELL, WHICH COULD LEAD TO A WRECK. MY FIRST 2001 FORD FOCUS WAGON (#) HAD THE SAME ISSUE, AND IT WAS REPAIRED BY FORD UNDER THE NHTSA 03V482000 RECALL, YET FORD IS DENYING THE SECOND WAGON FOR A RECALL REPAIR. I HOPE TO RESOLVE THIS ISSUE QUICKLY, AS IT MAY CAUSE HARM TO SOMEONE IF I LEAVE THIS INTERMITTENTLY-BAD PUMP IN THE CAR. THIS FUEL PUMP PRESSURE FAILURE OCCURS ALMOST EVERY OTHER DAY NOW, WHICH MAKES THE CAR UNRELIABLE TO DRIVE IN HEAVY TRAFFIC. I WOULD LIKE FORD TO CONSIDER THIS CAR AS THEY DO MY OTHER CAR, AND FIX THE FUEL PUMP PROBLEM THAT IS DEFINATELY A MANUFACTURING ISSUE. THIS CAR HAS LESS THAN 70,000 MILES ON IT. IT SHOULDN'T HAVE A FUEL PUMP PROBLEM ALREADY. I WILL SEE WHAT I CAN DO TO FIX IT; AND I WILL KEEP THE OLD PART FOR REFERENCE AND POSSIBLY REFUND IF YOU ARE ABLE TO RESEARCH THIS AND HOLD FORD ACCOUNTABLE FOR THEIR FUEL PUMPS THAT DON'T PRODUCE ADEQUATE FUEL PRESSURE CONSISTENTLY. *TR
NHTSA ODI #10253388
100,000 miles · Dec 29, 2008
TiresWheels
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE MERGING OFF THE HIGHWAY AT 10 MPH, THE CONTACT HEARD A LOUD NOISE AND NOTICED THE REAR DRIVER'S SIDE TIRE ROLLING BACK ONTO THE HIGHWAY. SHE RECOVERED THE TIRE AND NOTICED THAT THE BOLTS, LUGS, NUTS, AND WHEEL BEARING WERE STILL ATTACHED TO THE TIRE. A REPORT WAS FILED WITH THE MAN…
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE MERGING OFF THE HIGHWAY AT 10 MPH, THE CONTACT HEARD A LOUD NOISE AND NOTICED THE REAR DRIVER'S SIDE TIRE ROLLING BACK ONTO THE HIGHWAY. SHE RECOVERED THE TIRE AND NOTICED THAT THE BOLTS, LUGS, NUTS, AND WHEEL BEARING WERE STILL ATTACHED TO THE TIRE. A REPORT WAS FILED WITH THE MANUFACTURER AND THEY STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 01I017000 (WHEELS LUGS, NUTS, BOLTS); HOWEVER, THE DEALER COULD PROVIDE A WARRANTY FOR THE REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 100,000.
NHTSA ODI #10253042
55,000 miles · Dec 22, 2008
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING BETWEEN 5-10 MPH, THE ENGINE SHUT OFF WITHOUT WARNING. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO THE DEALER FOR REPAIR. THE DEALER STATED THAT THE FUEL PUMP NEEDED TO BE REPAIRED. THE CONTACT PAID FOR THE REPAIR. HE DISCOVERED A RECALL FOR THE FUEL PUMP, BUT THE DEAL…
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING BETWEEN 5-10 MPH, THE ENGINE SHUT OFF WITHOUT WARNING. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO THE DEALER FOR REPAIR. THE DEALER STATED THAT THE FUEL PUMP NEEDED TO BE REPAIRED. THE CONTACT PAID FOR THE REPAIR. HE DISCOVERED A RECALL FOR THE FUEL PUMP, BUT THE DEALER DID NOT INFORM HIM OF THE RECALL. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 55,000.
NHTSA ODI #10252532
101,225 miles · Dec 20, 2008
Electrical System
I HAVE A 2001 FORD FOCUS AND AS I WAS LEAVING WORK ONE DAY, I WENT TO START MY CAR AND THE KEY WOULDN'T FIT IN THE IGNITION. AFTER I WAS FINALLY ABLE TO PUT MY KEY IN IT WOULD NOT TURN. I HAD TO CALL FORD AND THEY TOLD ME THAT THIS IS COMMON WITH FORD FOCUS' AND TOLD ME TO HAMMER IN MY KEY BECAUSE A BARREL WAS DEFECTIVE IN THE…
Read full complaint
I HAVE A 2001 FORD FOCUS AND AS I WAS LEAVING WORK ONE DAY, I WENT TO START MY CAR AND THE KEY WOULDN'T FIT IN THE IGNITION. AFTER I WAS FINALLY ABLE TO PUT MY KEY IN IT WOULD NOT TURN. I HAD TO CALL FORD AND THEY TOLD ME THAT THIS IS COMMON WITH FORD FOCUS' AND TOLD ME TO HAMMER IN MY KEY BECAUSE A BARREL WAS DEFECTIVE IN THE IGNITION. I HAMMERED IN MY KEY AND WAS ABLE TO START MY CAR; HOWEVER, THIS IS AN ONGOING PROBLEM.
NHTSA ODI #10252336
156,000 miles · Dec 19, 2008
Electrical System
2001 FORD FOCUS IGINITION KEY DOES NOT TURN TO START VEHICLE. *TR
NHTSA ODI #10252257
104,000 miles · Dec 1, 2008
Seat BeltsCrashInjury
DURING A RECENT AUTOMOBILE ACCIDENT, THE DRIVER SIDE SEAT BELT DID NOT SECURE THE DRIVER. THE DRIVE SUFFERED FACIAL INJURY WHEN CONTACT WAS MADE WITH THE STEERING WHEEL. I WILL CONTACT THE FORD DEALERSHIP THIS WEEK. *TR
NHTSA ODI #10250223
127,923 miles · Nov 25, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE PURCHASING THE VEHICLE, THE CONTACT WAS INFORMED THAT THE MOTOR MOUNTS, WHICH HOLD THE ENGINE IN PLACE, NEEDED TO BE REPLACED. SHE WAS INSTRUCTED TO BRING THE VEHICLE TO THE DEALER THE FOLLOWING DAY FOR REPAIR. WHEN SHE ARRIVED AT THE DEALER, SHE WAS INFORMED TO LEAVE THE VEHICLE. …
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE PURCHASING THE VEHICLE, THE CONTACT WAS INFORMED THAT THE MOTOR MOUNTS, WHICH HOLD THE ENGINE IN PLACE, NEEDED TO BE REPLACED. SHE WAS INSTRUCTED TO BRING THE VEHICLE TO THE DEALER THE FOLLOWING DAY FOR REPAIR. WHEN SHE ARRIVED AT THE DEALER, SHE WAS INFORMED TO LEAVE THE VEHICLE. WHEN THE CONTACT ARRIVED TO RETRIEVE THE VEHICLE TWO DAYS LATER, THE DEALER REFUSED TO PROVIDE PAPERWORK STATING THAT THE VEHICLE WAS REPAIRED. ONE WEEK LATER, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND A LOUD RATTLING SOUND WAS HEARD COMING FROM THE ENGINE. SHE CALLED THE DEALER TO RETURN THE VEHICLE FOR REPAIR, BUT THEY REFUSED TO TAKE HER CALLS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP AND A MECHANIC STATED THAT THE MOTOR MOUNTS WERE NEVER REPLACED AND WOULD COST $3,000. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 127,923 AND CURRENT MILEAGE WAS 128,000.
NHTSA ODI #10249775
95,000 miles · Nov 13, 2008
Electrical System
THE PROBLEM I'M HAVE WITH MY 2001 IS MY KEY WILL NOT TURNING MY IGNITION. AFTER REVIEW THE COMPLAINTS I SEE SEVERAL PEOPLE IS HAVING THE SAME PROBLEM. CAN YOU REVIEW THE COMPLAINTS WITH THE IGNITIONS. *TR
NHTSA ODI #10248768
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration