1990 Ford F250

TL* THE CONTACT OWNS A 1990 FORD F250. THE CONTACT STATED THAT THE FUEL TANK STRAP WAS RUSTED AND LEAKING GAS. THE DEALER WAS MADE AWARE OF THE FAILURE HOWEVER, DID NOT OFFER ANY ASSISTANCE. THE MANUFACTURER WAS NOT CONTACTED TO REPORT THE FAILURE. THE CURRENT MILEAGE WAS 120,000 AND THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 06/07/11*LJ THE CONSUMER STATED THE STRAP WAS NOT RUSTED, BUT IT DID WEAR A HOLE IN THE GAS TANK. UPDATED 06/23/11

TL* THE CONTACT OWNS A 1990 FORD F250. THE CONTACT STATED THAT WHILE ATTEMPTING TO ACCELERATE FROM AT A TRAFFIC LIGHT, THE VEHICLE FELT AS IF IT WERE TRAVELING OVER A LARGE AMOUNT OF LIQUID. THE CONTACT OBSERVED EXCESSIVE FUEL LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DUPLICATED. THE CONTACT BELIEVED NHTSA CAMPAIGN ID NUMBER:01I008000(FUEL SYSTEM, GASOLINE) TO BE DIRECTLY RELATED TO THE FAILURE. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL AND WOULD NOT PROVIDE ANY FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 112,209 AND THE APPROXIMATE CURRENT MILEAGE WAS 120,000.

TL*THE CONTACT OWNS A 1990 FORD F250. WHILE DRIVING 45 MPH, THE FUEL PUMP FAILED. THE CONTACT SMELLED GAS AND NOTICED A GAS LEAK. HE BOUGHT A NEW FUEL PUMP AND REPLACED THE BODIES; HOWEVER, THE FAILURE RECURRED. THE REAR FUEL TANK SHUT DOWN AND THE FRONT TANK DID NOT REGISTER ON THE FUEL GAUGE. THE CONTACT PURCHASED AND INSTALLED NEW FUEL LINES, BUT THE FAILURE RECURRED. HE BOUGHT NEW FUEL LINES AGAIN, BUT THE FAILURE CONTINUED. THE DEALER INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 93V125000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). HE WENT TO A FEW DEALERS AND WAS INFORMED THAT HE DID NOT FALL WITHIN THE TIME FRAME FOR THE RECALL. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 160,000 AND FAILURE MILEAGE WAS 130,000.

DT*: THE CONTACT STATED WHEN THE VEHICLE WAS USING THE FRONT FUEL TANK, THE FUEL WAS EXHAUSTED QUICKLY. FUEL ALSO LEAKED OUT OF THE REAR TANK. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP WHO DETERMINED THAT THE CHECK VALVE HAD MALFUNCTIONED. THERE WERE NO IMMEDIATE REPAIRS MADE. THERE WAS A NHTSA RECALL # 93V125000, WHICH PERTAINED TO THE FUEL TANK ASSEMBLY. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. UPDATED 09/19/06. *JB

DT NHTSA RECALL 92V026000 WAS ISSUED. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. MY BRAKES FAILED. THE DEALER HAS NOT LOOKED AT THE VEHICLE BECAUSE THEY WOULD CHARGE THE CONSUMER FOR THE REPAIRS. CONTACTED FORD, THEY GAVE THE RUN AROUND. THERE WAS NO WARNING BEFORE THE BRAKES WENT OUT. THE BRAKE FLUID WAS OVER HEATING. THE BRAKE PEDAL WENT DOWN TO THE FLOOR. HAD TO USE EMERGENCY BRAKE, AND THE BRAKES ON THE BOAT THAT I WAS TOWING. THIS HAPPENED ON FRIDAY AUGUST 12, 2005. *AK

CONSUMER CONCERNED ABOUT RECALL ON 1990 FORD F250 FUEL TANK. *BF THE VEHICLE'S FRONT TANK PUSHED FUEL TO THE REAR TANK WHICH CAUSED IT TO OVERFLOW. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR FACILITY WHO FOUND RECALL 93S68 WHICH REFERENCED THAT FAILURE. THE CONSUMER NEVER RECEIVED A RECALL NOTICE FROM THE MANUFACTURER. THE CONSUMER CONTACTED THE MANUFACTURER WHO INFORMED HIM THAT HE WAS OVER THE MILEAGE AND TIME ALLOTTED FOR THE RECALL. THE INDEPENDENT DEALER REPLACED THE FAULTY CHECK VALVE, REGULATOR AND FUEL PUMP BUT THIS DID NOT CORRECT THE OVERFLOW CONDITION. *NM

I HAVE A 1990 FORD F250 WITH DUEL GAS TANKS. THE FIRST PROBLEM WAS THE TRUCK WOULD DIE FOR WHAT SEEMED LIKE NO OBVIOUS REASON. I HAD A DIAGNOSTIC DONE TO NO AVAIL. THE TRUCK WOULD RUN FINE COLD, BUT ONCE IT GOT HOT IT WOULD DIE. FINALLY I TOOK IT TO A LOCAL MECHANIC AND HE FOUND IT WAS THE TANK SELECTOR SWITCH WHICH LETS ME CHOOSE THE FRONT OR REAR GAS TANK. THIS FIRST SWITCH COST ME $300.00 TO FIX. ITS BEEN ABOUT 8 MONTHS SINCE THE SWITCH WAS REPLACED. IT JUST WENT OUT AGAIN. THIS TIME I REPLACED IT MYSELF WITH A SWITCH FROM A FORD DEALER. WHEN I UNHOOKED THE SWITCH FROM THE HARNESS IT WAS MELTED ON THE INSIDE OF THE SWITCH AND THE HARNESS WAS ALMOST UNUSABLE. I WENT TO A LOCAL FORD DEALER AND THE SALES CLERK SAID THAT THIS IS A COMMON PROBLEM BECAUSE HE SELLS THESE SWITCHES A LOT AND THIS WAS NOT THE FIRST TIME HE HEARD OF THE SWITCH MELTING. THIS IS A FIRE WAITING TO HAPPEN. FORD SHOULD RECALL THIS PART AND FIX THE ROOT OF THE PROBLEM. *JB

THE TRUCK FRONT FUEL TANK FILLED THE REAR TANK AND CAUSED IT TO OVER FLOW. *BF THE CONSUMER INDICATED THAT HE NEVER RECEIVED THE RECALL NOTICE FOR THE FUEL TANK CHECK VALVE PROBLEM. THE DEALER REPLACED THE RECALLED COMPONENT BUT THE FAILURE RECURRED. THE DEALER ALSO REPLACED THE FUEL PUMP, RETURN LINE CHECK VALVE BUT THE FUEL LEAKAGE CONTINUED. *NM

REFERENCE NHTSA CAMPAIGN # 93V125000 RECALL # 93S68. (1) THE VEHICLE HAD BEEN DRIVEN ABOUT ONE HOUR - WHILE PARKING IN FRONT OF THE HOUSE ON THE STREET, I NOTICED A STRONG SMELL OF GASOLINE. I WAS RUNNING ON THE BACK TANK AND QUICKLY SWITCHED TO THE FRONT TANK. AFTER SHUTTING OFF THE IGNITION AND EXITING VEHICLE I SAW GASOLINE SPILLING OUT OF THE FRONT TANK FROM UNDER THE CAP (STILL ON). THIS CONTINUED FOR SOME 5-10 SECONDS AND THEN STOPPED. WHEN I LOOSENED THE CAP, THE FLOW OF GASOLINE RESTARTED - AND STOPPED AGAIN WHEN CAP WAS TIGHTENED BACK DOWN. (2) THANKFULLY, THE FAILURE DID NOT RESULT IN FIRE OR LOSS OF PROPERTY - ONLY FUEL LOSS AND PERSONAL ANXIETY AND EXPENSE. (3) WEB RESEARCH REVEALED THE ABOVE RECALL AND WHEN SPEAKING TO A FMC REPRESENTATIVE AT THE HOTLINE I WAS ADVISED THAT THIS VEHICLE HAD RECEIVED THE RECALL REPAIR. I WAS ALSO ADVISED THAT THE WARRANTY PERIOD HAD EXPIRED DEC.31, 2001 AND I WOULD BE RESPONSIBLE FOR ANY REPAIRS. WHEN PRESENTED TO THE DEALERSHIP FOR REPAIRS, I WAS ADVISE THAT THE FUEL PUMP VALVE REPAIRS WOULD BE MY RESPONSIBILTY AND NOT COVERED BY FMC. WHY DOES THE RECALL REPAIR FAIL? AND WHY DOES THE CONSUMER HAVE TO FOOT THE BILL?*AK