Illustration1988 FORD F-250'S ENGINE COMPARTMENT CAUGHT ON FIRE. *TS WHILE DRIVING THE CONSUMER NOTICED SMOKE COMING FROM THE ENGINE COMPARTMENT. THE CONSUMER PULLED THE VEHICLE ONTO THE SHOULDER. THAT'S WHEN THE CONSUMER NOTICED THAT THE VEHICLE WAS ON FIRE. THE CONSUMER ATTEMPTED TO PUT THE FIRE OUT BUT WAS NOT SUCCESSFUL. *NM
1988 Ford F250
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all F250 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 62 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports9 fire reports1 injury reports
What owners actually said
62 reportsWHILE DRIVING,THE CONSUMER HEARD A LOUD NOISE COMING FROM THE REAR, THE CONSUMER WAS ABLE TO PULL OVER. THE CONSUMER NOTICED THAT THE FUEL TANK EXPLODED. NO INJURIES. THE CONSUMER WAS ABLE TO TRANSFER THE FUEL TO THE SECOND TANK AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE FUEL TANK N…
Read full complaint
WHILE DRIVING,THE CONSUMER HEARD A LOUD NOISE COMING FROM THE REAR, THE CONSUMER WAS ABLE TO PULL OVER. THE CONSUMER NOTICED THAT THE FUEL TANK EXPLODED. NO INJURIES. THE CONSUMER WAS ABLE TO TRANSFER THE FUEL TO THE SECOND TANK AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE FUEL TANK NEEDED REPLACEMENT. PLEASE FILL IN ADDITIONAL INFORMATION. *JB THE VEHICLES ENGINE DIED AS A RESULT OF THE EXPLOSION. THE CONSUMER SWITCHED TANKS AND WAS ABLE TO DRIVE TO AN INDEPENDENT GARAGE. THE GARAGE REMOVED THE GAS TANK. TANK WAS THREE TIMES THE NORMAL SIZE. WHEN TANK EXPLODED IT BENT THE VROSS MEMBER IN FRONT OF THE TANK CAUSING THE BED OF THE TRUCK TO NOW BE BOWED WHERE THE TANK WAS. *TC
WHILE DRIVING, TIRE TREAD WORE OFF THE TIRE. DEALER NOTIFIED. *AK THE FIRST TIRE BUBBLED AIR UNDER THE TREAD AND WAS ADJUSTED AT 11K MILES. THE SECOND AND THIRD TIRES ALSO HAD AIR BUBBLES UNDER THE TREAD AND HAD SEPARATED FROM THE CASING AT 14K MILES. *SCC *JB
IT TOOK NUMEROUS TRIES TO GET THE VEHICLE TO START. *JB
BOLTS AND NUTS THAT ATTACH SEAT TO TO FRAME OF VEHICLE HAVE STARTED TO PULL THROUGH FLOORBOARD.*AK CONSUMER STATES THE RIGHT FRONT NUT WAS DETACHED FROM THE FLOOR WHICH IS A SAFETY ISSUE, ALSO THE LEFT REAR NUT WAS PARTIALLY BROKEN LOOSE.*JB
PE 00 040/TIRE TREAD SEPARATION/TIRE FAILURE: LEFT FRONT TIRE WAS FLAT WHILE TRAVELING AT 45 MPH, ON A 1988, FORD, F250 WITH AFTER MARKET EQUIPMENT, TIRE SIZE LT235/85R16, DOT# UNVAILABLE. NOTICED MULTIPLE HAIR LINE CRACKS WHERE TREAD MET TIRE. FIRESTONE NOTIFIED. PLEASE FEEL FREE TO PROVIDE ROVIDE ANY FURTHER DETAILS ON THIS …
Read full complaint
PE 00 040/TIRE TREAD SEPARATION/TIRE FAILURE: LEFT FRONT TIRE WAS FLAT WHILE TRAVELING AT 45 MPH, ON A 1988, FORD, F250 WITH AFTER MARKET EQUIPMENT, TIRE SIZE LT235/85R16, DOT# UNVAILABLE. NOTICED MULTIPLE HAIR LINE CRACKS WHERE TREAD MET TIRE. FIRESTONE NOTIFIED. PLEASE FEEL FREE TO PROVIDE ROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
WHILE DRIVING, CONSUMER NOTICED THE SPARE TIRE ON FIRE, THE TIRE WAS MOUNTED UNDERNEATH THE BED AGAINST THE TAILPIPE. (OHIO TRAFFIC CRASH REPORT) *SLC
WHEN DRIVING AT ANY SPEED WITHOUT PRIOR WARNING VEHICLE CUT OFF/ ENGINE DIE OUT COMPLETELY. CONSUMER HAS CONTACTED DEALER , DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
WHILE DRIVING VEHICLE WILL COMPLETELY SHUT DOWN WITHOUT WARNING, CAUSE UNKNOWN. DEALER CANNOT IDENTIFY THE PROBLEM. PLEASE GIVE ANY FURTHER DETAILS.*AK
FIREWALL SHEET METAL FAILURE DUE TO METAL FATIGUE, CLUTCH AND BRAKE ARE TOO MUCH FORCE FOR THE DESIGN AND GAUGE OF THE FIREWALL. *SLC
Official recalls
396V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
92V026000 · Service Brakes, Hydraulic:foundation Components:drum:shoes/linings
Mar 3, 1992
A REVISED BRAKE LINING NOISE INSULATOR RESULTED IN A DECREASE IN THE THERMAL INSULATION BETWEEN THE BRAKE LINING AND THE FRONT BRAKE CALIPER PISTON. THIS CAUSED GREATER HEAT TRANSFER TO THE CALIPER PISTONS WITH THE POTENTIAL TO OVERHEAT THE BRAKE FLUID AND DIMINISH BRAKE EFFECTIVENESS DURING SEVERE BRAKING CONDITIONS.
Consequence & remedy
Consequence: INCREASED STOPPING DISTANCES AND INABLILITY TO HOLDVEHICLES ON A STEEP GRADE RESULTS IN INCREASED RISK OF ACCIDENT IN THE EVENT OFA SUDDEN STOP OR WHEN CONSTANT BRAKING IS NEEDED TO MANEUVER THROUGH AREAS WITHSTEEP GRADES.
Remedy: ADD SNAP-IN INSULATORS THAT ATTACH TO EACH OF THE FRONT BRAKE CALIPER PISTONS. IN ADDITION, VEHICLES WITH 7.5 L ENGINES WILL HAVE INSULATION ADDED TO THE ENGINE COMPARTMENT BRAKE LINES.
88V146000 · Visibility:glass, Side/rear
Sep 2, 1988
SLIDING REAR WINDOW MAY CONTAIN GLAZING PANELS WHICH DO NOT MEET REQUIREMENTS OF FMVSS 205.
Consequence & remedy
Consequence: A FRACTURED WINDOW MAY CONTAIN FRAGMENTS THAT ARE LARGERTHAN THE 425 GRAMS ALLOWED.
Remedy: REPLACE SUSPECT WINDOW PANELS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA93014 · Alternator Belt Failure
Opened Jun 4, 1993 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
EA91044 · Loss Of Brake Effectivenes
Opened Oct 30, 1991 · Closed Oct 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
PE91090 · Spare Tire Fires
Opened Jun 20, 1991 · Closed Oct 25, 1991
Status: closed (inferred from source dates) · Equipment
There is no summary currently available
PE91077 · Loss Of Brake Effectivenes
Opened May 23, 1991 · Closed Oct 31, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
DP89005 · F-SERIES Fuel Tank Fires
Opened Jan 26, 1989 · Closed Aug 1, 1989
Status: closed (inferred from source dates) · Fuel System, Gasoline
F-SERIES FUEL TANK FIRES
PE89020 · Fires
Opened Dec 7, 1988 · Closed Jun 1, 1989
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available