VEHICLE BEING TOWED BEHIND MOTORHOME ON I-29 NORTH OF ST.JOSEPH,MO. HEARD NOISE AND SAW SMOKE AND MOTORHOME BEGAN DRIFTING TO RIGHT. AFTER STOPPING TO INVESTIGATE FOUND LEFT FRONT TIRE BLOWN OFF WHEEL,BRAKE LINE SEVERED, RUNNING BOARD MISSING AND CONSIDERABLE DAMAGE TO LEFT DOOR AND FENDER. PUT ON SPARE THEN PROCEEDED TO PALM…
Read full complaint
VEHICLE BEING TOWED BEHIND MOTORHOME ON I-29 NORTH OF ST.JOSEPH,MO. HEARD NOISE AND SAW SMOKE AND MOTORHOME BEGAN DRIFTING TO RIGHT. AFTER STOPPING TO INVESTIGATE FOUND LEFT FRONT TIRE BLOWN OFF WHEEL,BRAKE LINE SEVERED, RUNNING BOARD MISSING AND CONSIDERABLE DAMAGE TO LEFT DOOR AND FENDER. PUT ON SPARE THEN PROCEEDED TO PALMYRA, NE. FOR THE EVENING. JUST AFTER CROSSING IN TO WYOMING THE NEXT DAY ANOTHER LOUD REPORT AND THE LEFT REAR TIRE BLEW OUT. SAME TYPE OF TIRE AND SAME MILEAGE AS THE FRONT, ONLY THE BELT HAD WRAPPED AROUND THE AXLE AND LOCKED UP THE WHEEL. I HAVE THIS TIRE, WHAT IS LEFT OF IT ANYWAY. CONDITIONS ON BOTH OCCURANCES: CLEAR WEATHER, TEMPS IN THE MID TO HIGH 80 S, SPEED WAS 65 MPH, TRAFFIC MODERATE. TIRES WERE CHECKED AND INFLATED TO 50 PSI PRIOR TO DEPARTING BARTLETT, TN. TREAD WAS ABOUT 50% ON ALL FOUR TIRES OF THE MATCHED SET. IF VEHICLE HAD BEEN DRIVEN INSTEAD OF BEING TOWED, THIS COULD HAVE BEEN DANGEROUS TO OCCUPENTS AND OTHER MOTORISTS IN BOTH INCIDENTS .*AK
NHTSA ODI #764288
Mileage unknown · Aug 28, 2001
Tires
TIRES SEPARATED AT THE BEAD JOINT ON EACH TIRE AFTER ONLY 3,000 TO 5,000 MILES. EXPLODED THROUGH THE TREAD CAUSING DAMAGE TO VEHICLE. HAVE USED THESE TIRES FOR YEARS WITHOUT MISHAP UNTIL ABOUT TWO YEARS AGO. PROBLEM STARTED ABOUT TWO YEARS AGO. CONCERNED ABOUT THE SAFETY OF THESE TIRES ON OTHER LESS STABLE VEHICLES.*AK
NHTSA ODI #751310
Mileage unknown · May 30, 2001
Tires
THIS IS THE FOURTH TIRE FAILURE OF ORIGINAL EQUIPMENT TIRES SINCE NOV 2000. *AK (DOT NUMBER: VNOP 65C TIRESIZE: LT215/85)
NHTSA ODI #746134
Mileage unknown · Oct 1, 2000
Tires
ONE TIRE FAILURE WAS DETECTED AS A LARGE BUBBLE WHERE THE TREAD SEPARATED. THE SECOND WAS A COMPLETE LOSS OF TREAD. (TIRESIZE: LT235/85R1)( DOT NUMBER: TIRE SIZE: LT235/85R1 )
NHTSA ODI #733047
Mileage unknown · Sep 4, 2000
Tires
FRONT TIRES PUT ON BY DEALER WHEN I BOUGHT IT 03/03/2000 ON 06/13/2000 RIGHT FRONT TIRE BEGAN TO JUMP UP AND DOWN AND SHAKE THE ENTIRE TRUCK. TIRE STORE STATED PROBLEM WAS DUE TO POSSIBLE BELT SEPERATION WITH-IN THE TIRE. I DID NOT REPLACE THEM WITH THE SAME BRAND TIRES. I HAVE NOT REPLACED THE REAR TIRES YET. FRONT ALIGNMENT…
Read full complaint
FRONT TIRES PUT ON BY DEALER WHEN I BOUGHT IT 03/03/2000 ON 06/13/2000 RIGHT FRONT TIRE BEGAN TO JUMP UP AND DOWN AND SHAKE THE ENTIRE TRUCK. TIRE STORE STATED PROBLEM WAS DUE TO POSSIBLE BELT SEPERATION WITH-IN THE TIRE. I DID NOT REPLACE THEM WITH THE SAME BRAND TIRES. I HAVE NOT REPLACED THE REAR TIRES YET. FRONT ALIGNMENT WAS CHECK AND DETERMINDED NOT TO BE A FACTOR IN THE TIRE FAILURE.( DOT NUMBER: TIRE SIZE: LT-225-16 )
NHTSA ODI #730115
Mileage unknown · Oct 5, 1998
StructureTiresFire
TIRE EXPLODED, CAUSING THE GAS TANK TO IGNITE, AND TRUCK TO BURNED COMPLETELY UP, BOAT THAT WAS TOWED WAS BURNED ALSO. DESIGN OF THE VEHICLE SHOULD PROVIDE ADEQUATE SHIELD TO PROTECT FROM THIS OCCURRANCE. .*AK
NHTSA ODI #828587
Mileage unknown · Feb 16, 1995
Engine And Engine CoolingService Brakes, HydraulicTires
WARPED FRONT BRAKE ROTORS/PADS, CAUSING VEHICLE TO VIBRATE UPON BRAKING. *AK
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.
Consequence & remedy
Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.
Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9
EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
EA95012 · Failure Of Serpentine Belt
Opened Mar 31, 1995 · Closed May 28, 1996
Status: closed (inferred from source dates) · Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Additional source detail variants (2)
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
PE94004 · Hydraulic Brake Line Cracks/leaks
Opened Jan 25, 1994 · Closed Apr 29, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
1992 Ford F-350 Problems, Complaints & Recalls | Skip That Year
Illustration