NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
52 reports130,000 miles · Aug 7, 2017
Fuel/propulsion System
TL* THE CONTACT OWNS A 1992 FORD F-350. WHILE FUELING THE VEHICLE, THE FUEL WAS TRANSFERRING TO THE REAR FUEL TANK AND OVERFLOWING. THE FAILURE CAUSED FUEL TO LEAK OUT ONTO THE GROUND. THE VEHICLE WAS TAKEN TO KALISPELL FORD, IN KALISPELL MT 59901, BUT THE RECALL HAD EXPIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFO…
Read full complaint
TL* THE CONTACT OWNS A 1992 FORD F-350. WHILE FUELING THE VEHICLE, THE FUEL WAS TRANSFERRING TO THE REAR FUEL TANK AND OVERFLOWING. THE FAILURE CAUSED FUEL TO LEAK OUT ONTO THE GROUND. THE VEHICLE WAS TAKEN TO KALISPELL FORD, IN KALISPELL MT 59901, BUT THE RECALL HAD EXPIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 93V125000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #11013487
Mileage unknown · Aug 22, 2006
SteeringCrash
1992 FORD F-350 HAD EQUIPMENT FAILURE, CAUSING IT TO STRIKE THE MEDIAN WALL. *KB THE CONSUMER STATED A FAILURE WITHIN THE STEERING CAUSED THE ACCIDENT. *JB
NHTSA ODI #10166902
45,000 miles · Jun 4, 2004
Fuel System, Gasoline
THE DEFECTIVE CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILL. SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO THE SOURCE OF IGNITION. *AK THE CONSUMER CONT…
Read full complaint
THE DEFECTIVE CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILL. SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO THE SOURCE OF IGNITION. *AK THE CONSUMER CONTACTED THE DEALER WHO INDICATED THAT THE RECALL HAD EXPIRED AND THAT THEY WOULD NOT FIX IT UNDER THE RECALL. *NM
NHTSA ODI #10072197
Mileage unknown · Aug 12, 2003
Fuel System, Other
CONSUMER STATES THAT VEHICLE IS LEAKING FUEL. DEALER NOTIFIED.*AK
NHTSA ODI #10033755
Mileage unknown · Feb 25, 2003
Fuel System, Gasoline
FUEL LEAKED OUT OF THE FRONT TANK.*JB
NHTSA ODI #10009252
Mileage unknown · Oct 28, 2002
Fuel System, Gasoline
CONSUMER STATES THAT WHEN THEY HAD RECALL DONE, DEALERSHIP FORGOT TO INSTALL A PART STATED IN THE RECALL. WHICH CAUSE RECALL REDEEM TO FAIL. WENT BACK, THEY CORRECTED THE PROBLEM, BUT LATER ON PROBLEM REACCURED. TS
NHTSA ODI #8021726
Mileage unknown · Jul 15, 2002
Tires
VEHICLE BEING TOWED BEHIND MOTORHOME ON I-29 NORTH OF ST.JOSEPH,MO. HEARD NOISE AND SAW SMOKE AND MOTORHOME BEGAN DRIFTING TO RIGHT. AFTER STOPPING TO INVESTIGATE FOUND LEFT FRONT TIRE BLOWN OFF WHEEL,BRAKE LINE SEVERED, RUNNING BOARD MISSING AND CONSIDERABLE DAMAGE TO LEFT DOOR AND FENDER. PUT ON SPARE THEN PROCEEDED TO PALM…
Read full complaint
VEHICLE BEING TOWED BEHIND MOTORHOME ON I-29 NORTH OF ST.JOSEPH,MO. HEARD NOISE AND SAW SMOKE AND MOTORHOME BEGAN DRIFTING TO RIGHT. AFTER STOPPING TO INVESTIGATE FOUND LEFT FRONT TIRE BLOWN OFF WHEEL,BRAKE LINE SEVERED, RUNNING BOARD MISSING AND CONSIDERABLE DAMAGE TO LEFT DOOR AND FENDER. PUT ON SPARE THEN PROCEEDED TO PALMYRA, NE. FOR THE EVENING. JUST AFTER CROSSING IN TO WYOMING THE NEXT DAY ANOTHER LOUD REPORT AND THE LEFT REAR TIRE BLEW OUT. SAME TYPE OF TIRE AND SAME MILEAGE AS THE FRONT, ONLY THE BELT HAD WRAPPED AROUND THE AXLE AND LOCKED UP THE WHEEL. I HAVE THIS TIRE, WHAT IS LEFT OF IT ANYWAY. CONDITIONS ON BOTH OCCURANCES: CLEAR WEATHER, TEMPS IN THE MID TO HIGH 80 S, SPEED WAS 65 MPH, TRAFFIC MODERATE. TIRES WERE CHECKED AND INFLATED TO 50 PSI PRIOR TO DEPARTING BARTLETT, TN. TREAD WAS ABOUT 50% ON ALL FOUR TIRES OF THE MATCHED SET. IF VEHICLE HAD BEEN DRIVEN INSTEAD OF BEING TOWED, THIS COULD HAVE BEEN DANGEROUS TO OCCUPENTS AND OTHER MOTORISTS IN BOTH INCIDENTS .*AK
NHTSA ODI #764288
Mileage unknown · Aug 28, 2001
Tires
TIRES SEPARATED AT THE BEAD JOINT ON EACH TIRE AFTER ONLY 3,000 TO 5,000 MILES. EXPLODED THROUGH THE TREAD CAUSING DAMAGE TO VEHICLE. HAVE USED THESE TIRES FOR YEARS WITHOUT MISHAP UNTIL ABOUT TWO YEARS AGO. PROBLEM STARTED ABOUT TWO YEARS AGO. CONCERNED ABOUT THE SAFETY OF THESE TIRES ON OTHER LESS STABLE VEHICLES.*AK
NHTSA ODI #751310
Mileage unknown · May 30, 2001
Tires
THIS IS THE FOURTH TIRE FAILURE OF ORIGINAL EQUIPMENT TIRES SINCE NOV 2000. *AK (DOT NUMBER: VNOP 65C TIRESIZE: LT215/85)
NHTSA ODI #746134
Mileage unknown · Mar 30, 2001
Fuel System, Gasoline
WHEN FILLING FUEL TANK, ONE TANK WOULD OVERFLOW INTO OTHER TANK AND CAUSE A SPILLAGE FROM THAT TANK. FUEL TANK REPAIRED UNDER RECALL A SECOND TIME AS GOODWILL GESTURE. CURRENTLY, SERVICE MANAGER REFUSING TO DO REPAIRS AGAIN. 2ND OWNER. *AK
NHTSA ODI #884733
Defect investigations
9EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
EA95012 · Failure Of Serpentine Belt
Opened Mar 31, 1995 · Closed May 28, 1996
Status: closed (inferred from source dates) · Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Additional source detail variants (2)
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
PE94004 · Hydraulic Brake Line Cracks/leaks
Opened Jan 25, 1994 · Closed Apr 29, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration