2016 Ford F-250 Sd

The contact owns a 2016 Ford F-250. The contact stated while driving 45-50 MPH, and depressing the accelerator pedal, the RPM fluctuated, and the vehicle failed to respond as needed. The power train and the check engine warning lights were illuminated. The contact pulled over to side of the road, turned off and restarted the vehicle; however, while attempting to drive, the vehicle failed to respond while in drive(D), but responded while in reverse(R). The vehicle was towed to the residence. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and advised the contact to write to Consumer Affairs. The failure mileage was approximately 130,000.

The contact owns a 2016 Ford F-250. The contact stated while driving 50 MPH, the front end was shaking violently after driving over a bump in the roadway. There were no warning lights illuminated. The contact called the local dealer, who stated that there were no open recalls on the VIN related to the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 136,000.

The problem is commonly called "DEATH WOBBLE". The steering system enters an extremely violent wobble/shake making control of the vehicle nearly impossible. 2 independent service centers have addressed the issue. The first did repairs, including warranty replacement of a faulty part and the truck still has the "DEATH WOBBLE". The 2nd independent service center made note of the 2nd faulty replacement part (TRACK BAR) and reports "TRACK BAR BUSHING IS MOVING EXCESSIVELY. TRACK BAR SHOULD BE REPLACED." No other physical inspections have been performed. There were no vehicle warning lights due to this issue. There were a few incidences of the "DEATH WOBBLE" prior to my first appointment with an independent service center. That first appointment was approx. 2/19/2024, completed on 2/27/2024. Second time completed on 6/21/2024.

I have had my vehicle inspected and supposedly repaired for the death wobble by two separate ford dealerships (Castle Rock Ford in Castle Rock, CO and Phil Long Ford in Colorado Springs CO). I continue to have safety issues as when I hit pot holes or rough roads, the steering and suspension system shakes the front wheels and steering wheel to the point that I have to come to a full stop. The entire steering system and shocks have been replaced (some parts multiple times) over the past two years. Please assists.

The contact owns a 2016 Ford F-250. The contact stated while driving approximately 5 MPH and hauling a trailer, the vehicle suddenly lost motive power and stalled. There was no warning light illuminated. The vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed and determined that the fuel pump had failed due to metal shavings in the fuel system. The contact was informed that the fuel system kit needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 237,778.

The contact owns a 2016 Ford F-250. The contact stated that while driving at approximately 50 MPH, the check engine light illuminated, and the message “Reduced Power Mode” was displayed. The vehicle was taken to a dealer where it was diagnosed that the fuel pump, manifold assembly, fuel injectors, injector terminal seal, gaskets, vacuum pump, and left side fuel rail pressure pump needed to be replaced. The manufacturer was notified of the failure. The failure mileage was approximately 76,880.

It has been labeled as the death wobble. When driving down the highway at 65-70 mph and I hit a bump, pothole or a washboard effect in the road with the left front wheel. The whole truck will shake violently. So much that I can barely hold on to the steering wheel. The only way to stop the shaking is to slow the truck down to 30-40 mph. In the middle of the highway. I can watch the other vehicles around me scatter and put on their brakes as they try and avoid me. Sometimes it’s to hard to control and I will waver into another lane or on coming traffic. This happens sporadically and without warning. I have taken the truck to the Ford dealership for $3000 in steering component repairs . I have 60,000 miles on it and it is only used for personal use and never abused. This is a design defect that is going to get someone killed. A heavy duty truck should not have the parts wearing out to such a degree that threatens the lives of everyone on the road around me.

The contact owns a 2016 Ford F-250. The contact stated while driving at an undisclosed speed, the steering wheel was shaking uncontrollably. The contact stated that the steering wheel was shaking, and it was difficult to hold onto the steering wheel. The contact decelerated and the vehicle was taken to an independent mechanic. The vehicle was not diagnosed or repaired. The contact stated that the failure had previously occurred, and the vehicle was repaired; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.