When I drove over 50mph and hit any bump the front of the truck shakes wildly. Online says DEATH WOBBLE. This has been going on for 4 months. When taking my children to school 20+ miles away on the highway this has happened several times to and from school on the same day. Other vehicles move out of my line to avoid me while I…
Read full complaint
When I drove over 50mph and hit any bump the front of the truck shakes wildly. Online says DEATH WOBBLE. This has been going on for 4 months. When taking my children to school 20+ miles away on the highway this has happened several times to and from school on the same day. Other vehicles move out of my line to avoid me while I slow the truck to under 45 mph. They are scared and nervous about getting to school safely. My mother and wife refuse to drive the truck after experiencing this while driving. The fuel injector now also has a problem. The truck is going in to be serviced for the failing fuel injector and death wobble hopefully today if Waldorf MD Ford has openings I am awaiting a call back. It has not been inspected yet only diagnostic at AutoZone showing the fuel injector error code. No warning was given prior to this happening, the truck was riding smoothly, hit a bump in the highway and went crazy. Then it did it again and again and again.
NHTSA ODI #11503106
74,000 miles · Mar 24, 2021
Electrical SystemVehicle Speed ControlWheelsCrash
VEHICLE WAS PURCHASED FROM PRIORTY FORD IN NORFOLK, VA ON SUNDAY MARCH 21ST 2021. INCIDENT #1 MARCH 22ND 2021: FRONT DRIVER'S TIRE COMPLETELY BLEW ON HIGHWAY EN ROUTE TO TENNESSE AN HOUR AND A HALF OUT OF GATLINBURG, TN. SPEEDOMETER WAS ALSO NOT FUNCTIONING PROPERLY PRIOR TO SAYING WE WERE DRIVING A FASTER THAN ACTUAL MPH (CONF…
Read full complaint
VEHICLE WAS PURCHASED FROM PRIORTY FORD IN NORFOLK, VA ON SUNDAY MARCH 21ST 2021. INCIDENT #1 MARCH 22ND 2021: FRONT DRIVER'S TIRE COMPLETELY BLEW ON HIGHWAY EN ROUTE TO TENNESSE AN HOUR AND A HALF OUT OF GATLINBURG, TN. SPEEDOMETER WAS ALSO NOT FUNCTIONING PROPERLY PRIOR TO SAYING WE WERE DRIVING A FASTER THAN ACTUAL MPH (CONFIRMED WHILE USING GPS). SPARE TIRE WAS PUT IN PLACE OF BLOWN OUT TIRE, CHANGED SPARK PLUG WIRE (WHICH DIDN'T REPAIR TICKING NOISE PER MECHANIC) MECHANIC ALSO SAID WE WOULD BE GOOD TO GO WITH SPARE TIRE. INCIDENT #2 MARCH 24TH 2021: WHILE EN ROUTE TO NEXT DESTINATION (NEW ORLEANS, LA) TRED CAME OFF REAR DRIVERS SIDE TIRE CAUSING TRUCK TO GO OUT OF CONTROL ON I-59 NEAR BIRMINGHAM, AL. VEHICLE SPUN INTO GRASS MEDIAN ONTO OPPOSITE SIDE OF INTERSTATE AND WAS NO LONGER DRIVABLE. A POLICE REPORT WAS MADE AND TRUCK WAS TOWED. ADDITIONAL INFORMATION AND PROOF VIA PICTURES AND REPORTS AVAILABLE UPON REQUEST.**
NHTSA ODI #11404759
11 miles · Mar 2, 2020
SteeringSuspensionVehicle Speed Control
DRIVING ON INTERSTATE AND THE TRUCK STARTED A UNCONTROLLABLE WOBBLE. DURING THE WOBBLE I FELT I HAD NO CONTROL OF VEHICLE AND WAS MOVING OUT OF MY LANE. FORD NEEDS TO DO SOMETHING IMMEDIATELY BEFORE SOMEONE GETS KILLED I ALSO TELL A FIFTH WHEEL CAMPER AND I CAN ONLY IMAGINE HAVING THAT KIND OF WEIGHT BEHIND ME THAT THE TRUCK WOU…
Read full complaint
DRIVING ON INTERSTATE AND THE TRUCK STARTED A UNCONTROLLABLE WOBBLE. DURING THE WOBBLE I FELT I HAD NO CONTROL OF VEHICLE AND WAS MOVING OUT OF MY LANE. FORD NEEDS TO DO SOMETHING IMMEDIATELY BEFORE SOMEONE GETS KILLED I ALSO TELL A FIFTH WHEEL CAMPER AND I CAN ONLY IMAGINE HAVING THAT KIND OF WEIGHT BEHIND ME THAT THE TRUCK WOULD FLIP AND POSSIBLY KILL ME OR SOMEONE ELSE ON THE INTERSTATE.
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Ford Motor Company (Ford) is recalling certain 2016 Super Duty F-250, F-350, F-450, and F-550 vehicles. Dust may accumulate in the steering wheel clock spring, causing a disconnection in the electrical connection resulting in the driver's air bag not deploying as intended.
Consequence & remedy
Consequence: A disconnected driver's air bag can result in it not deploying, as intended, during a crash, increasing the risk of injury.
Remedy: Dealers will replace the steering wheel clock spring, free of charge. Remedy parts are expected to become available in the 3rd Quarter of 2023. An interim notification letter informing owners of the safety risk was mailed on July 6, 2022. Owner notification letters were mailed July 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S35.
Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-250, F-350, F-450, and F-550 trucks manufactured April 5, 2016, to April 11, 2016. The tires installed during assembly of the affected vehicles may have sustained damage to the inner sidewall, possibly resulting in a loss of air or a tire rupture.
Consequence & remedy
Consequence: A rapid loss of air or a tire rupture while the vehicle is being driven may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires for damage and replace them as necessary, free of charge. The recall began on May 23, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S17.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
2016 Ford F-250 Sd Problems, Complaints & Recalls | Skip That Year
Illustration