2016 Ford F-250 Sd

Traveling on uneven road leads to uncontrollable driving when u hit a bump the front end shakes to the point you have to stop even when passing a vehicle on interstates ( my incident) my mechanic has changed numerous parts , rotated tires ( installed 06 21) i cannot let my wife drive this truck for fear of her not being able to control the shaking if she hits a bump especially while on the interstate I just think she would freak out I did the first time now I am very cautious when driving but in Louisiana it is impossible to miss a bump

On 08/01/2022 at approximately 1400 hours, I was driving my 2016 Ford F250 4x4 and towing a 5th wheel trailer weighing approximately 14000 lbs. I was traveling at approximately 60 MPH when I hit a small bump on I-215 which caused a violent shaking from the front end of the vehicle (condition commonly referred to as "death wobble"). I immediately released the accelerator to try and correct the violent shake, but the condition continued. I attempted to brake, which caused the condition to worsen and brake efficiency was greatly reduced. Allowing the vehicle to coast and slow down without brake input was the only way to correct the condition. Once we slowed to below 45 MPH, the condition was no longer present. I inspected the front end suspension and steering components of the vehicle. I discovered the ball joint (Ford Part# MCF-2225) securing the track bar to the front axle was warn and had excessive play in it. This play allowed the front axle to have lateral movement perpendicular to the vehicles travel. All other suspension and steering components checked okay. After replacement of the track bar ball joint, the condition has not reoccured. The defective ball joint is available for inspection, however it fell apart when pressed out of the front axle. This issue caused a severe reduction in steering and braking, putting myself and those around me at risk. As the truck is no longer in warranty, it has not been seen by the dealer or a third party. There was no warning prior to the condition occurring.

10 times over about a 12 month period,(with 5 of the 10 happening in one 6 hour period, after we have spent thousands of dollars trying to fix this issue) if we run over a bump in the road at over 60 mph, the front end of the truck goes into violent, uncontrollable shaking. The only way to stop it is to smash the brakes as hard as you can to get the trucks speed below 30 mph so you can regain control of the steering wheel and front end. It’s one of the scariest things we have ever experienced. Please make FORD fix this problem before someone gets killed!!!!

Death rattle in the front-end suspension!!!!!! I have spent thousands of dollars to replace original factory parts since this issue has happened in the past year once I passed 125,000 miles, even with brand new parts replaced and beefed up in shocks and springs and steering arms. I still have this happening between 50 plus mph. bumps and cracks in the road will set this off in heavy highway traffic and I have to slow down to 10mph to get the truck under control. this will cause an accident eventually.

My truck regular experiences violent shakes when I hit bumps in the road when traveling over 45MPH. I was on a bridge today and had to slow traffic to less than 30mph to control the shakes. The last 4 times I have entered the freeway at a specific entrance I have experienced the violent shakes, requiring me to enter the emergency lane to gain control.

My vehicle violently shakes when hitting even the most minute bump in the road, known to some as the "death wobble." I took it to the dealership to inspect and Ford will not fix it, unless I pay. It is a safety issue and in the last month, I've had four instances where I have stopped traffic behind me while the truck was shaking and it literally bounced its way into another lane. I am a service member and I'm pretty sure if I am injured, the military will sue Ford for the hospital bill. The problem has been reproduced and confirmed by Ford. There are no warning lights or warning before it occurs, other than I know to drive real slow and not hit bumps. It cannot be trusted on the highway, so I avoid it now. The first time it happened was in 2021 and I've talked to Ford since, but there is no safety recall.

On approximately 26 May 2022 I was driving down an entrance ramp to I-77 and the front end of the truck started shaking very severely -- violently. This was without any warning and I had never experienced anything like this before on this vehicle, or any other vehicle I had ever driven. I took my foot off the gas and pretty much coasted to the side of the road to a stop. I caught my breath, suspected there was an issue with the shock absorber, and slowly accelerated again and merged onto the interstate and drove the rest of the way home. There were no more similar instances like this for several days. When I got back to my RV I check the shock and could see no problems. On 5 June I went to a local Firestone Service Center for an alignment check and to see if they could find a problem. They made minor corrections to the alignment; told me they could find not problems, even though they told me the tech said there was a lot of vibration at about 55 MPH when he took it for a test drive; and then advised me to take it to a Ford dealer for review. On my drive back to my RV I experienced about 4 more instances of very severe and violent front end shaking of the truck, typically when I was at 55 MPH or faster. In each case the shaking would not stop until I pulled over and came to a stop. On Monday, 6 June I visited two Ford dealerships and one independent repair shop to try and get an analysis and fix. I have been able to make an appointment for 8 June. During the drive back to my RV on the 6th I experienced 3 more vibration events. One of these was as I was decelerating and exiting the interstate and was traveling at about 45 MPH. This front end vibration shakes the front end of the truck and steering wheels extremely bad. I was able to maintain control but it would not take much to send the truck into a sideways skid. From what the Firestone tech told me I believe they were able to confirm the vibration issue, but they did not communicate the severity very well.