Vehicle has 44,000 miles, has never been wrecked in any way. Recently the advance trac system began displaying a fault at random. The light would come and go. At the time the fault light was active the turn signals did not operate normally. A message noted to service advance trac system. ( which is related to the abs) I noticed…
Read full complaint
Vehicle has 44,000 miles, has never been wrecked in any way. Recently the advance trac system began displaying a fault at random. The light would come and go. At the time the fault light was active the turn signals did not operate normally. A message noted to service advance trac system. ( which is related to the abs) I noticed, once, the abs activate momentarily for no apparent reason. I narrowed the fault down to the steering wheel angle sensor. I had a Ford service center confirm the issue was the steering angle sensor. The sensor was on a backorder. I called around and other dealers confirmed. A week later while entering a cloverleaf and slowing down the system faulted, illuminated the error, and the abs activated. The brake system applied brakes unevenly pulling the vehicle to the left then right and aggressively slowing down without driver brake input. I had to fight to control the vehicle to prevent losing control or get rear ended. The roads were clean, dry, and it was daylight. Upon that i could see the complete loss of steering wheel angle sensor input. The dash can show this readout. Without the steering wheel angle input the system, which is to prevent accidents, nearly caused one. I tried turning off the advance trac via the traction control button, this was ineffective. I had to remove the abs pump fuse to get home safely. This system should not in any way be able to cause this severe loss of vehicle control simply due to the loss of one sensor. This is absolute unsafe software protocall. Attatched are images of the sensor reading then no place holder for it when it does not read.
NHTSA ODI #11570420
2,500 miles · Jun 23, 2017
Service Brakes
COMPLETE BRAKE FAILURE, 2,500 MILES ON THIS CAR!
NHTSA ODI #11000844
Mileage unknown · Mar 8, 2017
Service BrakesSteeringUnknown Or Other
HAS A HISSING SOUND UNDER THE PASSENGER SIDE ,HAS BEEN GIVING US UPSET STOMACHS AND SOMETIMES HEAD ACHES,JUST PLAIN SICK FEELING, WHEN THE AC AND DEFROST ARE ON. ALSO FROM END ABS SEEMS TO ENGAGE WHEN GOING AROUND A BEND AND THEN SUPPOSEDLY THE AUTO CORRECT KICKS IN AND TRIES TO CORRECT THE TRUCK PULLING STEERING WHEEL. WAS TO…
Read full complaint
HAS A HISSING SOUND UNDER THE PASSENGER SIDE ,HAS BEEN GIVING US UPSET STOMACHS AND SOMETIMES HEAD ACHES,JUST PLAIN SICK FEELING, WHEN THE AC AND DEFROST ARE ON. ALSO FROM END ABS SEEMS TO ENGAGE WHEN GOING AROUND A BEND AND THEN SUPPOSEDLY THE AUTO CORRECT KICKS IN AND TRIES TO CORRECT THE TRUCK PULLING STEERING WHEEL. WAS TOLD THEY TESTED ONE TRUCK AND IT DID IT ONE TIME,THIS IS AFTER THEY PUT IN COUNTLESS HRS ON LABOR PLUS A $1000 INTO A NEW STEERING COLUMN AND DETERMINED THAT IT IS NORMAL OPERATING CONDITION. DIDN'T BUY IT FOR THIS GOD FOR SAKE NOISE . AS FOR THE HISSING,TOLD ME TO DETAIL THE TRUCK AND THAT THEY WERE NOT GOING TO DO ANYMORE FOR THIS. THIS HAS BEEN GOING ON SINCE THE FIRST WEEK OF BUYING THIS TRUCK. OVER AND OVER TO THE DEALERSHIP,THEY KEEP PUTTING NEW PARTS ON. IF THIS IS NORMAL OPERATING CONDITIONS,THAN WHY DON'T THEY KNOW WHAT TO REPLACE AND KEEP PUTTING MORE TEST AND PARTS. NO ANSWER ON THE HISSING SOUND AND VERY VERY RUDE MANAGERS AT DEALERSHIP.
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Ford Motor Company (Ford) is recalling certain 2016 Super Duty F-250, F-350, F-450, and F-550 vehicles. Dust may accumulate in the steering wheel clock spring, causing a disconnection in the electrical connection resulting in the driver's air bag not deploying as intended.
Consequence & remedy
Consequence: A disconnected driver's air bag can result in it not deploying, as intended, during a crash, increasing the risk of injury.
Remedy: Dealers will replace the steering wheel clock spring, free of charge. Remedy parts are expected to become available in the 3rd Quarter of 2023. An interim notification letter informing owners of the safety risk was mailed on July 6, 2022. Owner notification letters were mailed July 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S35.
Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-250, F-350, F-450, and F-550 trucks manufactured April 5, 2016, to April 11, 2016. The tires installed during assembly of the affected vehicles may have sustained damage to the inner sidewall, possibly resulting in a loss of air or a tire rupture.
Consequence & remedy
Consequence: A rapid loss of air or a tire rupture while the vehicle is being driven may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires for damage and replace them as necessary, free of charge. The recall began on May 23, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S17.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
2016 Ford F-250 Sd Problems, Complaints & Recalls | Skip That Year
Illustration