The contact owns a 2016 Ford F-250. The contact stated that while driving at approximately 50 MPH, the check engine light illuminated, and the message “Reduced Power Mode” was displayed. The vehicle was taken to a dealer where it was diagnosed that the fuel pump, manifold assembly, fuel injectors, injector terminal seal, gaskets…
Read full complaint
The contact owns a 2016 Ford F-250. The contact stated that while driving at approximately 50 MPH, the check engine light illuminated, and the message “Reduced Power Mode” was displayed. The vehicle was taken to a dealer where it was diagnosed that the fuel pump, manifold assembly, fuel injectors, injector terminal seal, gaskets, vacuum pump, and left side fuel rail pressure pump needed to be replaced. The manufacturer was notified of the failure. The failure mileage was approximately 76,880.
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Ford Motor Company (Ford) is recalling certain 2016 Super Duty F-250, F-350, F-450, and F-550 vehicles. Dust may accumulate in the steering wheel clock spring, causing a disconnection in the electrical connection resulting in the driver's air bag not deploying as intended.
Consequence & remedy
Consequence: A disconnected driver's air bag can result in it not deploying, as intended, during a crash, increasing the risk of injury.
Remedy: Dealers will replace the steering wheel clock spring, free of charge. Remedy parts are expected to become available in the 3rd Quarter of 2023. An interim notification letter informing owners of the safety risk was mailed on July 6, 2022. Owner notification letters were mailed July 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S35.
Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-250, F-350, F-450, and F-550 trucks manufactured April 5, 2016, to April 11, 2016. The tires installed during assembly of the affected vehicles may have sustained damage to the inner sidewall, possibly resulting in a loss of air or a tire rupture.
Consequence & remedy
Consequence: A rapid loss of air or a tire rupture while the vehicle is being driven may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires for damage and replace them as necessary, free of charge. The recall began on May 23, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S17.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
2016 Ford F-250 Sd Problems, Complaints & Recalls | Skip That Year
Illustration