NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Diesel complaints
10 reportsClear category filter212,000 miles · Aug 4, 2025
Fuel System, Diesel
The contact owns a 2016 Ford F-250. The contact stated while driving approximately 25 MPH, the vehicle started losing motive power. There was no warning light illuminated. The contact was able to coast to the driveway at the residence and became aware of an oil leak underneath the vehicle. The contact stated that an unknown deal…
Read full complaint
The contact owns a 2016 Ford F-250. The contact stated while driving approximately 25 MPH, the vehicle started losing motive power. There was no warning light illuminated. The contact was able to coast to the driveway at the residence and became aware of an oil leak underneath the vehicle. The contact stated that an unknown dealer was contacted and informed the contact that a fuel system upgrade was available; however, the vehicle was not upgraded. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure and a case was filed. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 212,000.
NHTSA ODI #11678272
66,634 miles · Aug 1, 2025
Fuel System, Diesel
The contact owns a 2016 Ford F-250. The contact stated while driving at an undisclosed speed, the vehicle experienced reduced power and poor fuel efficiency. The messages "DPF System Overloaded" and "Exhaust System Fault - 50 Miles Until Speed Restrict" were displayed. The vehicle was taken to the dealer on four separate occasio…
Read full complaint
The contact owns a 2016 Ford F-250. The contact stated while driving at an undisclosed speed, the vehicle experienced reduced power and poor fuel efficiency. The messages "DPF System Overloaded" and "Exhaust System Fault - 50 Miles Until Speed Restrict" were displayed. The vehicle was taken to the dealer on four separate occasions. The dealer performed a manual regeneration three times, but the failure persisted. The vehicle was taken back to the dealer, where it was determined that the Diesel Particulate Filter (DPF) system needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program Number: 20M06 (Diesel Particulate Filter Warranty Extension with Diagnostic Trouble Code P2002) and Emission Recall Number: 20E08 (Extended Idle Diesel Particulate Filter Calibration); however, the VIN was not included. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was 66,634.
NHTSA ODI #11677804
91,000 miles · May 21, 2025
Fuel System, Diesel
The contact owns a 2016 Ford F-250. The contact stated while driving 45 MPH, the vehicle lost motive power. There was no warning light illuminated. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to the residence. The vehicle was then towed to the dealer, where it was diagno…
Read full complaint
The contact owns a 2016 Ford F-250. The contact stated while driving 45 MPH, the vehicle lost motive power. There was no warning light illuminated. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to the residence. The vehicle was then towed to the dealer, where it was diagnosed with an inoperable high-pressure fuel pump(HPFP). The dealer determined that the entire fuel system needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 91,000.
NHTSA ODI #11662363
178,000 miles · Feb 11, 2025
Fuel System, Diesel
The contact owns a 2016 Ford F-250. The contact stated that while driving 10 MPH, the check engine warning light illuminated, and the vehicle stalled while driving through an intersection. The contact was able to safely coast the vehicle over to the side of the highway. The contact was able to restart the vehicle. The contact st…
Read full complaint
The contact owns a 2016 Ford F-250. The contact stated that while driving 10 MPH, the check engine warning light illuminated, and the vehicle stalled while driving through an intersection. The contact was able to safely coast the vehicle over to the side of the highway. The contact was able to restart the vehicle. The contact stated that several days later the failure reoccurred, and the vehicle was taken to a local dealer to be diagnosed. The contact was informed that there were metal particles inside the fuel system. The contact was informed that the fuel system needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL) as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 178,000.
NHTSA ODI #11641966
240,000 miles · Jan 3, 2025
Fuel System, Diesel
The contact owns a 2016 Ford F-250. The contact stated while driving at an undisclosed speed, the reduced power warning light illuminated, and the vehicle lost motive power. The contact drifted over to the shoulder of the roadway. The vehicle was towed to an independent mechanic where it was diagnosed with a failed high-pressure…
Read full complaint
The contact owns a 2016 Ford F-250. The contact stated while driving at an undisclosed speed, the reduced power warning light illuminated, and the vehicle lost motive power. The contact drifted over to the shoulder of the roadway. The vehicle was towed to an independent mechanic where it was diagnosed with a failed high-pressure fuel pump. The contact was informed that the high-pressure fuel pump needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 240,000.
NHTSA ODI #11633903
140,000 miles · Jul 31, 2024
Fuel System, Diesel
The contact owns a 2016 Ford F-250. The contact stated while her husband was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the failure occurred while driving on a busy highway. The contact's husband drove the vehicle to the int…
Read full complaint
The contact owns a 2016 Ford F-250. The contact stated while her husband was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the failure occurred while driving on a busy highway. The contact's husband drove the vehicle to the intended destination. The vehicle was taken to an independent mechanic. The contact stated that several warning lights illuminated, and the vehicle lost motive power. The vehicle was diagnosed with a clogged diesel particulate filter. The contact was informed that the diesel particulate filter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 140,000.
NHTSA ODI #11605688
237,778 miles · Jun 17, 2024
Fuel System, Diesel
The contact owns a 2016 Ford F-250. The contact stated while driving approximately 5 MPH and hauling a trailer, the vehicle suddenly lost motive power and stalled. There was no warning light illuminated. The vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed and determined that the fuel pump ha…
Read full complaint
The contact owns a 2016 Ford F-250. The contact stated while driving approximately 5 MPH and hauling a trailer, the vehicle suddenly lost motive power and stalled. There was no warning light illuminated. The vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed and determined that the fuel pump had failed due to metal shavings in the fuel system. The contact was informed that the fuel system kit needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 237,778.
NHTSA ODI #11594731
110,000 miles · Apr 4, 2024
Fuel System, Diesel
The contact owns a 2016 Ford F-250. The contact stated that while driving 20 MPH, the vehicle lost motive power and stalled. The check engine warning light was illuminated, with a message stating to check the engine. The vehicle was towed to an independent mechanic where a diagnostic test was performed. The mechanic stated that …
Read full complaint
The contact owns a 2016 Ford F-250. The contact stated that while driving 20 MPH, the vehicle lost motive power and stalled. The check engine warning light was illuminated, with a message stating to check the engine. The vehicle was towed to an independent mechanic where a diagnostic test was performed. The mechanic stated that the high-pressure pump created metal debris that traveled through the fuel system and the high-pressure fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 110,000.
NHTSA ODI #11581075
67,000 miles · Jul 18, 2022
Fuel System, Diesel
The contact owns a 2016 Ford F-250. The contact stated while driving at an unknown speed, the shifted into Limp Mode. The contact stated that the check engine warning light was illuminated. The vehicle was towed to an independent mechanic who diagnosed that the failure was due to metal chips being in the fuel. The independent me…
Read full complaint
The contact owns a 2016 Ford F-250. The contact stated while driving at an unknown speed, the shifted into Limp Mode. The contact stated that the check engine warning light was illuminated. The vehicle was towed to an independent mechanic who diagnosed that the failure was due to metal chips being in the fuel. The independent mechanic advised the contact to tow the vehicle to the dealer. The vehicle was towed to the dealer where it was awaiting a final diagnostic report. The mechanic confirmed metal chips inside the fuel. The contact stated that he was informed by other mechanics that the failure was a known issue. The manufacturer was notified of the failure and advised the contact to file a complaint with the NHTSA. The approximate failure mileage was 67,000.
NHTSA ODI #11474542
Mileage unknown · Jul 17, 2021
Fuel System, Diesel
The DEF fluid heater has failed. This can cause failure or DEF delivery to the system at lower outdoor temperatures. This component has already been subject to a NHTSA recall in earlier year models of tge same truck, up to model year 2015.
NHTSA ODI #11425302
Official recalls
3Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
May 13, 2022
Ford Motor Company (Ford) is recalling certain 2016 Super Duty F-250, F-350, F-450, and F-550 vehicles. Dust may accumulate in the steering wheel clock spring, causing a disconnection in the electrical connection resulting in the driver's air bag not deploying as intended.
Consequence & remedy
Consequence: A disconnected driver's air bag can result in it not deploying, as intended, during a crash, increasing the risk of injury.
Remedy: Dealers will replace the steering wheel clock spring, free of charge. Remedy parts are expected to become available in the 3rd Quarter of 2023. An interim notification letter informing owners of the safety risk was mailed on July 6, 2022. Owner notification letters were mailed July 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S35.
Apr 26, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-250, F-350, F-450, and F-550 trucks manufactured April 5, 2016, to April 11, 2016. The tires installed during assembly of the affected vehicles may have sustained damage to the inner sidewall, possibly resulting in a loss of air or a tire rupture.
Consequence & remedy
Consequence: A rapid loss of air or a tire rupture while the vehicle is being driven may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires for damage and replace them as necessary, free of charge. The recall began on May 23, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S17.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.