IllustrationPROBLEM: CRANK NO START. NO CHECK ENGINE LIGHT. TURNS OUT TO BE THE FUSE FOR THE FUEL PUMP. HEATS UP ON ONE SIDE AND LOOKS TO BE MELTING. NEVER POPS THE FUSE. ALLOWS THE TRUCK TO START SOMETIMES AND WHEN YOU LEAST TO EXPECT IT JUST KEEPS CRANKING WITH NO START. AFRAID IT MAY CAUSE A FIRE!
2014 Ford F-150
Owner reports · Recalls · Investigations
More warning signs than most F-150 years
Owner complaints for the 2014 Ford F-150 are substantially higher than the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1700–25K
20525–50K
21150–75K
14675–100K
167100–150K
109150K+
1,008 reports with mileage · 523 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 422 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 288 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
38 crash reports16 fire reports27 injury reports
What owners actually said
1,531 reportsI PURCHASED THIS VEHICLE FEBRUARY 2020 FROM SNYDER MOTORS-BOZEMAN, AND DROVE IT FROM APPROXIMATELY 107K TO 110K MILES WITH NO ISSUES. THIS VEHICLE FIRST PERFORMED THIS MAJOR SAFETY ISSUE ON APPROXIMATELY MAY 10TH, 2020. I WAS ATTEMPTING TO PASS A VEHICLE ON THE TWO-LANE MONTANA HIGHWAY FROM NORRIS, MT TO FOUR CORNERS, MT. I QUIC…
Read full complaint
I PURCHASED THIS VEHICLE FEBRUARY 2020 FROM SNYDER MOTORS-BOZEMAN, AND DROVE IT FROM APPROXIMATELY 107K TO 110K MILES WITH NO ISSUES. THIS VEHICLE FIRST PERFORMED THIS MAJOR SAFETY ISSUE ON APPROXIMATELY MAY 10TH, 2020. I WAS ATTEMPTING TO PASS A VEHICLE ON THE TWO-LANE MONTANA HIGHWAY FROM NORRIS, MT TO FOUR CORNERS, MT. I QUICKLY ACCELERATED FROM 65MPH TO 80MPH AND PASSED THEM IN THE LEFT LANE DURING A PASSABLE STRETCH. JUST AS I HAD ALMOST FINISHED PASSING, I NOTICED THE LIGHT THAT INDICATES MY MODE OF DRIVE (PARK, NEUTRAL, REVERSE, ETC.) FLICKER VERY QUICKLY AND ERRATICALLY BETWEEN THE DIFFERENT DRIVE MODES. WHEN THE LIGHT FIRST HIT THE REVERSE POSITION, IT VIOLENTLY SHOOK THE VEHICLE WITH ME AND MY TWO GOOD FRIENDS WITHIN. I THEN LOST ALL CONTROL OF THE VEHICLE'S POWER AS IF IT HAD SHIFTED ITSELF INTO NEUTRAL. I WAS THEN FORCED TO VERY QUICKLY BRAKE AND GET BACK INTO MY LANE AS I HAD NO POWER AND ANOTHER VEHICLE CAME AROUND A TURN IN THE PASSING LANE AND APPROACHED TOWARDS US. I HAD TO SHUT THE VEHICLE OFF BRIEFLY TO REGAIN CONTROL, AND THEN HAD TO GET ON THE HIGHWAY. THE TRUCK THEN PERFORMED THE ISSUE AGAIN WHILE GOING UP A STEEP HILL DESPITE SLOWING TO 60MPH. I HAVE SINCE HAD THE VEHICLE PERFORM THE ISSUE A MYRIAD OF TIMES, USUALLY DUE TO HILLS GOING 30-40 MPH SINCE I'VE HAD TO AVOID HIGHWAYS. EACH TIME, I AM SINCERELY SCARED FOR MY LIFE AND WELL BEING. I TOOK IT INTO BOZEMAN FORD FROM 6/22/20 TO 6/29/20 AFTER FIRST TAKING THE VEHICLE TO FOSTER'S MASTERTECH AND HAVING THEM REPLICATE THE ISSUE AND AGREE IT IS A SAFETY CONCERN. I WAS ABLE TO REPLICATE THE ISSUE WITH A BOZEMAN FORD TECH AND HE ALSO AGREED THAT IT WAS A SCARY EXPERIENCE AND STATED THIS TO A SERVICE REP. FORD REPLACED THE MOLDED LEAD FRAME, BUT TO NO AVAIL AS THE TRUCK PERFORMED THE ISSUE AGAIN THAT DAY. IT IS NOW BACK WITH BOZEMAN FORD, ATTACHED ARE MY DOCUMENTS FROM THE INITIAL SERVICE. *TR
TL* THE CONTACT OWNS A 2014 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V332000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE LOW BRAKE FLUID WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO BO BEUCKM…
Read full complaint
TL* THE CONTACT OWNS A 2014 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V332000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE LOW BRAKE FLUID WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO BO BEUCKMAN QUALITY FORD LOCATED AT 15675 MANCHESTER RD, ELLISVILLE, MO 63011, (636) 227-5700, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE BRAKE SYSTEM NEEDED TO BE FLUSHED. ADDITIONALLY, THE BRAKE MASTER CYLINDER AND BRAKE BOOSTER NEEDED TO BE REPLACED. THE DEALER ALSO CONFIRMED THAT PARTS FOR THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 51,338. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2014 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS STOPPED, THE CONTACT ATTEMPTED TO ACTIVATE THE REAR WINDOW DEFROSTER HOWEVER, THE SYSTEM FAILED TO OPERATE AS DESIGNED. THE CONTACT STATED THAT VISIBILITY OUT OF THE REAR WINDOW WAS IMPAIRED. MIKE REICHENBACH FORD LINCOLN (600 N COIT ST, FLOREN…
Read full complaint
TL* THE CONTACT OWNS A 2014 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS STOPPED, THE CONTACT ATTEMPTED TO ACTIVATE THE REAR WINDOW DEFROSTER HOWEVER, THE SYSTEM FAILED TO OPERATE AS DESIGNED. THE CONTACT STATED THAT VISIBILITY OUT OF THE REAR WINDOW WAS IMPAIRED. MIKE REICHENBACH FORD LINCOLN (600 N COIT ST, FLORENCE, SC 29501; 866-957-8563) WAS CONTACTED AND INFORMED OF THE FAILURE HOWEVER, NO ASSISTANCE WAS PROVIDED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 17,500.
WHILE COMING TO A STOP AND APPLYING THE BRAKES, I'VE NOTICED OVER THE LAST SEVERAL DAYS THAT THE BRAKES HAVE BECOME SOFT, ALMOST GOING COMPLETELY TO THE FLOOR AT TIMES. ALSO, WHILE STOPPED AND APPLYING THE BRAKES, THE BRAKE PEDAL SLOWLY SINKS TOWARDS THE FLOOR. I HAVE CHECK THE TRUCK FOR POSSIBLE LEAKS AND HAVE FOUND NONE APPARE…
Read full complaint
WHILE COMING TO A STOP AND APPLYING THE BRAKES, I'VE NOTICED OVER THE LAST SEVERAL DAYS THAT THE BRAKES HAVE BECOME SOFT, ALMOST GOING COMPLETELY TO THE FLOOR AT TIMES. ALSO, WHILE STOPPED AND APPLYING THE BRAKES, THE BRAKE PEDAL SLOWLY SINKS TOWARDS THE FLOOR. I HAVE CHECK THE TRUCK FOR POSSIBLE LEAKS AND HAVE FOUND NONE APPARENT. THE RESERVOIR IS DOWN A BIT BUT AGAIN, NO VISIBLE LEAKS. I CHECKED FORD'S SITE FOR A POSSIBLE RECALL AND IT SAYS THERE IS NONE. HOWEVER, I KNOW THERE IS SOME 2013 AND 2014 MODELS WITH A MASTER CYLINDER RECALL. I'M THINKING MAYBE THE RECALL DIDN'T INCLUDE ENOUGH VEHICLES BECAUSE IT SOUNDS LIKE MY TRUCK IS HAVING THE SAME ISSUE. *TR
VEHICLE WOULD LOSE ALL ABILITY TO ACCELERATE OR USE ANY TYPE OF THROTTLE CONTROL WHILE DRIVING ON HIGHWAY. HAD TO CONTINUALLY DRIFT TO A SHOULDER ON THE HIGHWAY TO TURN OFF VEHICLE BECAUSE THE THROTTLE BODY WENT BAD. EXTREMELY DANGEROUS, VEHICLE BECAME INOPERABLE AND UNSAFE TO BE ON ANY ROADWAY. *TR
MY USED 2014 F-150, (WITH 51K MILES) I OWNED FOR A MONTH, HAS A 6R80 TRANS, SLIPPED FROM 6TH GEAR, INTO 1ST GEAR WHILE I WAS DOING 65 MPH, WHILE I WAS DRIVING ON THE N.J. PKWY. IT WAS COVERED BY DEALER, TURNED OUT TO BE THE "LEAD BODY" THAT NEEDED REPLACING WITHIN THE TRANS. THIS HAS BEEN AN ISSUE WITH THIS TRANS, WITH THIS YEAR…
Read full complaint
MY USED 2014 F-150, (WITH 51K MILES) I OWNED FOR A MONTH, HAS A 6R80 TRANS, SLIPPED FROM 6TH GEAR, INTO 1ST GEAR WHILE I WAS DOING 65 MPH, WHILE I WAS DRIVING ON THE N.J. PKWY. IT WAS COVERED BY DEALER, TURNED OUT TO BE THE "LEAD BODY" THAT NEEDED REPLACING WITHIN THE TRANS. THIS HAS BEEN AN ISSUE WITH THIS TRANS, WITH THIS YEAR AND OTHER MODELS. PRESENTLY THERE IS A RECALL FOR 2015 AND HIGHER YEAR MODELS, JUST NOT FOR THE "14" MODEL AS OF YET, THIS COULD CAUSE SERIOUS ACCIDENT DUE TO IT'S, ABRUPT ONSET, WITHOUT ANY WARNING, OR CHANGE IN DRIVING TO INVOKE SUCH AN ACTION. *TR
WHILE DRIVING AT HIGHWAY SPEED 65 TO 75 THE TRUCK JUST SHUTS DOWN ,STOPS RUNNING THIS IS THE 4TH TIME IN 5 YEARS THIS HAS HAPPENED TO US ALMOST HAD A MAJOR REAR END MISHAP AS A SEMI WAS ON US GOING UP A BRIDGE IN HEAVY TRAFFIC,A WRENCH SHOWED UP ON DASH DISPLAY TRUCK STARTED BUT DIED 3 MORE TIMES AT ROAD SPEED IN 20 MILES. …
Read full complaint
WHILE DRIVING AT HIGHWAY SPEED 65 TO 75 THE TRUCK JUST SHUTS DOWN ,STOPS RUNNING THIS IS THE 4TH TIME IN 5 YEARS THIS HAS HAPPENED TO US ALMOST HAD A MAJOR REAR END MISHAP AS A SEMI WAS ON US GOING UP A BRIDGE IN HEAVY TRAFFIC,A WRENCH SHOWED UP ON DASH DISPLAY TRUCK STARTED BUT DIED 3 MORE TIMES AT ROAD SPEED IN 20 MILES. *TR
I HAVE 86000 MILES ON MY TRUCK AND NOTICED A KNOCKING NOISE UPON STARTING TURNS OUT I HAVE A STRETCHED TIMING CHAIN AND MY EXTENDED WARRANTY WONT COVER IT THIS IS NOW THE SECOND FORD I HAVE BEEN TAKEN TO THE CLEANERS. *TR
2014 F150 WITH 61,000 MILES INTERMITTENTLY LOSES POWER STEERING. HAD IT AT THE DEALERSHIP TWICE UNTIL THE CONDITION HAPPENED. I WAS TOLD THAT THE STEERING SHAFT IS FAILING AND MUST BE REPLACED (APPROX. COST $1900). DOING RESEARCH I FOUND THAT THERE WAS A RECALL ON THE 2014 F150 (NHTSA ID 14V316000) IN WHICH THE STEERING ASSIS…
Read full complaint
2014 F150 WITH 61,000 MILES INTERMITTENTLY LOSES POWER STEERING. HAD IT AT THE DEALERSHIP TWICE UNTIL THE CONDITION HAPPENED. I WAS TOLD THAT THE STEERING SHAFT IS FAILING AND MUST BE REPLACED (APPROX. COST $1900). DOING RESEARCH I FOUND THAT THERE WAS A RECALL ON THE 2014 F150 (NHTSA ID 14V316000) IN WHICH THE STEERING ASSIST WAS INCORRECTLY ASSEMBLED AND MUST BE REPLACED. ALSO, THE RECALL ONLY INCLUDES TRUCKS MANUFACTURED BETWEEN MAY 26 AND JUNE 19, I'M TOLD MY TRUCK WAS NOT MANUFACTURED DURING THAT TIME AND I AM RESPONSIBLE FOR THE REPAIR. *TR
Official recalls
826V378000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles previously repaired incorrectly under recall number 24V444. A loss of signal between the transmission output shaft speed sensor and the powertrain control module (PCM) can cause the transmission to unexpectedly downshift into first gear.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed July 8, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26S45. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
24V444000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jun 17, 2024
Ford Motor Company (Ford) is recalling certain 2014 F-150 vehicles. A loss of signal between the transmission output shaft speed sensor and the powertrain control module can cause the transmission to unexpectedly downshift into first gear, regardless of vehicle speed.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 1, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S37.
20V332000 · Service Brakes, Hydraulic:foundation Components:master Cylinder; Service Brakes, Hydraulic:power Assist
Jun 8, 2020
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
17V472000 · Seat Belts; Seats
Jul 25, 2017
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence & remedy
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
Additional source detail variants (2)
Seats
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
Seat Belts
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
16V345000 · Service Brakes, Hydraulic:fluid
May 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.
Consequence & remedy
Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.
14V710000 · Seats
Nov 7, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 Ford F-150 and Flex vehicles manufactured March 1, 2014, to May 31, 2014. The affected vehicles were manufactured with a reduced clearance between the seat frame and the seat track assembly. This can cause the Occupant Classification System (OCS) to inaccurately register passenger weight and improperly suppress the passenger front airbag when the passenger seat is occupied by an adult passenger. Thus, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) No. 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Improper suppression of the passenger airbag increases the risk of an injury to the seat occupant in the event of a crash necessitating deployment of the front passenger airbag.
Remedy: Ford will notify owners, and dealers will widen the gap between the seat frame and seat track assembly and recalibrate the seat OCS, free of charge. The recall began November 25, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C10.
14V709000 · Exterior Lighting:brake Lights:switch; Service Brakes, Hydraulic:pedals And Linkages
Nov 5, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
Service Brakes, Hydraulic:pedals And Linkages
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
14V316000 · Steering:electric Power Assist System
Jun 12, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 Ford F-150 trucks manufactured May 26, 2014 to June 19, 2014, and equipped with Electronic Power Assist Steering (EPAS). The affected vehicles may have an incorrectly installed EPAS gear motor position sensor magnet that can lead to a total loss of steering control while driving.
Consequence & remedy
Consequence: A loss of steering control while driving increases the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will replace the EPAS steering gear, free of charge. The recall began in July 2014. Note: Owners are advised not to drive their vehicles until they have been remedied. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S09.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ24005 · Unintended Transmission Downshift
Opened Mar 27, 2024 · Closed Jul 29, 2024
Status: closed (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
In September 2016, Ford Motor Company (Ford) issued safety recall 16V-248 which included certain model year (MY) 2011-2012 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions. This recall was in response to allegations of unintended, unexpected vehicle transmission downshifting to a lower gear without warning, often accompanied by temporary rear wheel lock-up, increasing the risk of a crash and/or injury, and included approximately 153,581 vehicles. Ford identified the root cause of the unintended, unexpected vehicle transmission downshifting to a lower gear to be intermittent signal loss from the transmission’s Output Shaft Speed (OSS) sensor due to solder joint cracks on the OSS circuit board as a result of manufacturing process issues. The OSS sensor is mounted onto the molded lead frame and transmits changes in transmission shaft speed to the Powertrain Control Module (PCM). The remedy program described in safety recall 16V-248 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In December 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-010) to assess the scope and remedy effectiveness of safety recall 16V-248. As a result of this ODI investigation, Ford issued safety recall 19V-075 to expand the scope of 16V-248 to include MY 2011-2013 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions and included approximately 1,263,051 vehicles. The remedy program described in safety recall 19V-075 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In June 2019, Ford issued safety recall 19V-433 as the remedy program used to service MY 2013 Ford F-150 5.0L and 6.2L vehicles in accordance with safety recall 19V-075 did not contain the necessary updates to prevent unintended vehicle transmission downshifting from occurring and included approximately 107,857 vehicles. On March 27, 2024, ODI opened this Recall Query (RQ24-005) to investigate the scope of the above-described safety recalls. At the time that this investigation was opened, ODI had received 86 Vehicle Owner Questionnaires (VOQs) reporting allegations of unintended, unexpected vehicle transmission downshifting to a lower gear without warning, often accompanied by temporary rear wheel lock-up, in MY 2014 Ford F-150 vehicles. As a result of this Recall Query, Ford filled safety recall 24V-444 on June 14, 2024, to include MY 2014 Ford F-150 vehicles and expand the scope of safety recalls 16V-248, 19V-075 and 19V-433. The remedy program described in safety recall 24V-444 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring and included approximately 552,188 vehicles. In its May 2024 response to ODI’s information request, Ford concluded that a predominant root cause for the intermittent OSS signal loss has not been identified outside of the original safety recall (16V-248). Ford’s investigation also concluded that the primary causes of the defect in MY 2014 F-150 vehicles were related to the molded lead frame and the control assembly transmission main. In the May 2024 response, Ford identified 2,184 total reports that described unintended vehicle transmission downshifting and rear wheel lock-up events; 1,441 warranty claims and 743 reports from consumer complaints, field reports, consumer surveys, and lawsuits/legal claims. Note that the values presented here and in the table above represent the total number of reports which can include a single consumer with multiple reports of the same event as well as a consumer with reports of multiple distinct events. Of the 1,441 warranty claims, 551 warranty claims involved repair of the molded lead frame (38%) and 509 warranty claims involved repair of the control assembly transmission main (35%). Ford has also stated that the PCM programming used to prevent unintended vehicle transmission downshifting was implemented starting with MY 2015 vehicle #1 production and onward. In view of the safety recall action being taken by Ford, ODI is closing this Recall Query (RQ24-005). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE16003 · Master Cylinder External Leak
Opened Feb 29, 2016 · Closed Jul 26, 2016
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Additional source detail variants (4)
Service Brakes
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:fluid
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107