2010 Ford F-150

2010 FORD F150 ONLY OWNER - Brake Calipers and break line failed. Took it into Ford Dealership and they were unable to provide a diagnosis. Truck still shakes when in idle. All maintenance and needed care for the truck has been maintained. Repair cost over $4k to repair for 6 months in with the issue. Camera does not work and has not since 2014. Heated seats stopped working and burned out in 2014. All issues started to surface after truck was paid off.... Of course

DRIVER HEATED SEAT FUNCTION WAS ON WHILE DRIVING, SUDDENLY THERE WAS A VERY HOT SPOT FELT UNDER DRIVER'S LEFT LEG, THEN HEATED SEAT FUNCTION THEN WENT OFF. FURTHER ATTEMPTS TO OPERATE THE HEATED SEAT FUNCTION RESULTED IN A TEMPORARY ILLUMINATION OF THE DRIVER HEATED SEAT INDICATOR, FOLLOWED BY AN EXTINGUISHING OF SAME INDICATOR AFTER ABOUT 1 SECOND. THE VEHICLE IN QUESTION IS NO LONGER ELIGIBLE FOR COVERAGE UNDER THE 3/36,000 BUMPER TO BUMPER PORTION OF THE FORD 2010 NEW VEHICLE LIMITED WARRANTY; THEREFORE, THE VEHICLE OWNER ELECTED TO PERFORM HIS OWN INVESTIGATION INTO THE PROBLEM. THE OWNER DISMANTLED THE DRIVER SEAT AND FOUND BURNT COMPONENTS IN THE VICINITY OF A FAILED WIRE THAT WAS PART OF THE SEAT HEATER SUBSYSTEM, ALL OF THIS UNDER THE SEAT COVER IN AN AREA THAT WOULD HAVE BEEN UNDERNEATH THE LEFT LEG OF THE DRIVER. THE FAILURE WAS IDENTIFIED AS A BURNT/CHARRED WIRE THAT OPENED THE CIRCUIT OF THE HEATED SEAT FUNCTION. PHOTOS OF THE DISMANTLED SEAT SHOWING THE BURNT/CHARRED COMPONENTS ARE AVAILABLE AT: HTTP://WWW.F150FORUM.COM/F38/2010-DRIVER-BUCKET-SEAT-HEAT-REPAIR-286693/. OTHER POSTINGS AT WWW.F150FORUM.COM SUGGEST THAT THIS PROBLEM IS NOT NECESSARILY AN ISOLATED INCIDENT. THE VEHICLE OWNER SUBSEQUENTLY AFFECTED HIS OWN REPAIR TO THE HEATED SEAT SUBSYSTEM, RETURNING THE SUBSYSTEM TO FULL FUNCTIONALITY. THE VEHICLE OWNER IS CONCERNED THAT AN AS-ASSEMBLED-BY-THE-MANUFACTURER SUBSYSTEM FAILURE OF THIS TYPE HAS THE POTENTIAL TO INDUCE A CONDITION OF THERMAL RUNAWAY WHICH COULD POTENTIALLY LEAD TO A VEHICLE FIRE. THE VEHICLE OWNER HAS YET TO INFORM THE FORD MOTOR COMPANY OF THIS INCIDENT AT THE TIME OF THIS WRITING ON 24-JAN-2015. *TR

2010 F-150 WITH 5.4 L V-8 ENGINE, DURING OPERATION OF THE AIR CONDITIONING SYSTEM THE PASSENGER SIDE FLOOR BOARD TO INCLUDE CARPET AND MATTING WERE SOAKED. SUBSEQUENT SERVICING BY DEALERSHIP FOUND A FAULTY ELBOW AND HOSE FROM AIR CONDITIONING UNIT. DEALERSHIP REPLACED ELBOW AND HOSE AND RE-PLUMBED THE HOSE AT A COST OF APPROXIMATELY $300. DEALERSHIP NOTED THAT THE ELBOW AND HOSE WERE FAULTY ON THE INVOICE. *TR

TL* THE CONTACT OWNS A 2010 FORD F-150. THE CONTACT STATED THAT THE DRIVER'S SIDE METAL TRACK ASSEMBLY AND CABLE FAILED DUE TO DEFECTIVE MATERIAL. IN ADDITION, THE DRIVER'S SEAT COULD NOT BE ADJUSTED IN A SAFE DRIVING POSITION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE METAL TRACK ASSEMBLY AND CABLE WAS REPLACED. THE FAILURE MILEAGE WAS 57,317 AND THE CURRENT MILEAGE WAS 59,000.

THE DRIVER'S SIDE SEAT HEATER QUIT WORKING AFTER MY WIFE COMPLAINED ABOUT IT "GETTING SO HOT IT WAS LITERALLY BURNING HER LEGS". I TOOK APART THE SEAT TODAY TO REPLACE THE HEATING PAD BECAUSE I HAD READ ABOUT THIS BEING A COMMON PROBLEM. TO MY SURPRISE MY WIFE WAS NOT EXAGGERATING. THERE WERE BURN MARKS ON THE FOAM INSULATION AROUND A CONNECTING PIECE OF THE BOTTOM SEAT HEATER. MY TRUCK IS OUT OF WARRANTY, OTHERWISE I PROBABLY WOULD'VE JUST DROPPED IT OFF AT THE DEALER AND NEVER WITNESSED THIS MYSELF. *TR

ISSUES BEGAN ON FRIDAY MORNING. HAD A WARNING ON DASH INDICATING LEFT REAR DOOR AJAR, WHEN IN FACT THE DOOR WAS CLOSED. TOOK TO DEALER WHO SAID IT WAS PROBABLY A BAD SENSOR AND FOR $400 THEY COULD FIX IT. FAULTY WARNING WILL NOT LET AUTO LOCKS ENGAGE OR ALARM TO SET AS IT IS READING THE DOOR AS OPEN. HUGE SAFETY CONCERN IF YOU ARE TRAVELLING WITH A CHILD, THE DOORS WILL NOT LOCK AND YOU HAPPEN TO GET INTO AN ACCIDENT. POSSIBLE EJECTION OF PASSENGERS. THEN CAME OUT TO THE TRUCK ON FRIDAY AFTERNOON AND NOTICED THE REAR SEATS WERE WET. UNABLE TO FIND OUT WHY. FURTHER INVESTIGATION TODAY REVEALS THAT THE HEADLINER IS DAMAGED FROM WATER DAMAGE. READING SEVERAL PLACES ONLINE, IT APPEARS THAT THE F-150 HAS A BAD LEAKING PROBLEM FROM THE 3RD BRAKE LIGHT ON THE REAR OF THE CAB. THIS WILL NOW HAVE TO BE FIXED AND REPLACED AND THE TRUCK IS HARDLY 3 YEARS OLD. DISAPPOINTED IN THE QUALITY "FORD BUILT" PRODUCTS. *TR

TL*THE CONTACT OWNS A 2010 FORD F150. THE CONTACT STATED THAT WHEN SITTING IN THE VEHICLE, THE HEAD REST WOULD APPLY EXTREME PRESSURE TO THE BACK OF HIS HEAD. THE HEAD REST WOULD PUSH HIS HEAD DOWNWARD AND HE WOULD HAVE TO LOOK UPWARD AND OVER HIS GLASSES IN ORDER TO SEE THE ROAD. THE DEALER ADVISED THE CONTACT THAT THE OLDER MODEL F150 HEAD RESTS WERE TWO INCHES FARTHER BACK THAN THE NEWER MODELS AND THE DESIGN WAS CHANGED BASED ON SAFETY STANDARDS AND CRASH TEST RESULTS. THE DEALER WAS UNABLE TO PROVIDE A REMEDY FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 100 AND THE CURRENT MILEAGE WAS 850. UPDATED 10/26/10. *LJ UPDATED 10/26/10*JB