COMPONENT SPOTLIGHT

Ford Explorer transmission problems

2,441 distinct owner reports with a transmission-specific component in this snapshot.

General power-train reports are not automatically counted as transmission problems. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.

89 crash reports24 fire reports36 injury reports

Reports by model year

Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.

When problems were reported

Mileage at the reported incident

242

0–25K

245

25–50K

392

50–75K

339

75–100K

321

100–150K

150K+

1,608 reports with mileage · 833 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What owners actually said

2,441 reports

2002 model year · 55,000 miles · Apr 8, 2006

Power Train

TRANSMISSION SOMETIMES NOT GOING INTO 3RD AND SLIPPING BETWEEN 1ST AND 2ND AND 3RD. BOUGHT IT USED SO OUT OF LUCK BUT HAVE TALKED TO DOZENS WHO HAD THE SAME PROBLEM. FORD ISSUED THIS WARNING TO THEIR DEALERS "03-25-4 DEC 03 A/T - 5R55W NO 3RD GEAR/SLIPPING 2-3 SHIFT/DTC'S SET" SO MANY OF THESE ARE JUST GOING OUT. DUE TO HAVING A…

Read full complaint

NHTSA ODI #10154880

2002 model year · 68,200 miles · Apr 7, 2006

Power Train

TRANSMISSION WENT BAD AT 68,000 MILES. IT WAS UNABLE TO SHIFT FROM SECOND TO THIRD GEAR. PREVIOUS TO THAT MAKE VERY HARD NOISES WHEN SHIFTING FROM THIRD TO SECOND. *JB

NHTSA ODI #10154841

2002 model year · 34,000 miles · Apr 6, 2006

Power Train

TOOK 02 FORD EXPLORER IN DUE TO CAR NOT SHIFTING WHEN IT SHOULD. ACCORDING TO FORD, I NEED A NEW TRANSMISSION. THE EXPLORER ONLY HAS 34,000 MILES. FREEDOM FORD IN HAMPTON, VA INSTALLED A NEW TRANSMISSION FOR $3600.00. *NM

NHTSA ODI #10154753

2000 model year · 46,342 miles · Apr 6, 2006

Engine And Engine CoolingPower Train

Read full complaint

I HAVE A 2000 FORD EXPLORER WITH 46,000 MILES ON IT. I NOTICED A DELAY GOING INTO FIRST GEAR ON TRANSMISSION. TOOK CAR TO DEALER AND THEY REPAIRED TRANSMISSION TO THE COST OF $2900. I AM 61 YEARS OLD AND DRIVE VERY LITTLE. I EXPECTED AT LEAST 100,000 MILES FROM THIS VEHICLE BEFORE MAJOR PROBLEMS. DEALER FOUND ELC TRANS DIAGNOSTIC FOUND INTERNAL WEAR. FOUND INTER AND OD SERVO PISTON HARD 2-3 SHIFT VALVE STICKING. R/R VALVE BODY. PISTONS OVERHAULED AND FLUSHED COOLER LINES .REPLACED CONTROL ASSEMBLY,GASKET, PISTON AND ROD, SCREEN ASSEMBLY, CONVERTER ASSEMBLY & FLUID. *JB

NHTSA ODI #10154707

2004 model year · 40,000 miles · Apr 6, 2006

Power Train

TRANSMISSION IS SLIPPING WHEN CHANGING GEARS, ESPECIALLY WHEN PUTTING THE VEHICLE IN REVERSE. SOMETIMES TAKES SEVERAL SECONDS FOR THE VEHICLE TO GO IN TO REVERSE.

NHTSA ODI #10154728

2003 model year · 38,000 miles · Apr 3, 2006

Power Train

NHTSA 10003163. NOISE FROM CONVERTER HOUSING. SUV HAS 42,272 MILES AND DEALER ESTIMATED $1200.00 REPAIR. FORD KNEW THERE WAS A PROBLEM WITH TSB #17050. *JB

NHTSA ODI #10154471

2002 model year · 30,360 miles · Mar 30, 2006

Power Train

Read full complaint

AUTOMATIC TRANSMISSION (5R55W) HAS FAILED AT 30,300 MILES 10 MONTHS PAST LOUSY 3YR/36K BUMPER TO BUMPER WARRANTY EXPIRATION! 1 MONTH PRIOR TO FAILING THERE WAS A SECOND OR SO DELAY SHIFTING INTO REVERSE OR A HARSH BUMP UPON ENGAGEMENT. ON 2/26/06 AFTER A 30 MINUTE DRIVE ON THE INTERSTATE AND THEN DOING AN IN-TOWN ERRAND, THE OVERDRIVE OFF LIGHT STARTED FLASHING. AFTER PARKING IT IN OUR GARAGE THERE WAS A BURNED FLUID SMELL. DUE FOR THE 30K TRANSMISSION SERVICE, I ALSO ASKED FOR A COMPUTER DIAGNOSTIC TEST AT AN INDEPENDENT TRANS. SPECIALIST. THE MECHANIC CAME TO ME WITH THE PAN ASKING DO YOU POSSIBLY HAVE AN EXTENDED WARRANTY. (NO! I SHOULDN'T NEED ONE FOR A MAJOR COMPONENT SUCH AS A TRANSMISSION.) THE FLUID WAS COMPLETELY BLACK WITH NO HINT OF RED. ADDITIONALLY THE MAGNET WAS COVERED WITH A 1/2" THICK LAYER OF METAL SHAVINGS! THE COMPUTER CODE (P1783) REVEALED THAT THE FLUID HAD HEATED TO GREATER THAN 270 DEGREES F. THE TRANSMISSION IS FRIED AND HIS BEST ESTIMATE TO REBUILD IT WAS AROUND $3,000! LET ME STATE THAT THIS VEHICLE WAS NEVER DRIVEN UNDER ANY HARSH CONDITIONS, EVEN THOSE YOU SHOULD BE ABLE TO DO ACCORDING TO FORD ADVERTISEMENTS SUCH AS TOWING, OFF-ROAD OR USING THE 4 X 2 LOW GEAR. AFTER DOING AN INTERNET SEARCH AND READING HOW MANY PEOPLE HAVE REPEATED FAILURES WITH THE REBUILT AND/OR NEW 5R55W'S INSTALLED, WHAT IS THE CONSUMER SUPPOSED TO DO? WE HAVE TO PAY FOR FORD'S MANUFACTURING DEFECT BECAUSE THEY ARE NOT TAKING RESPONSIBILITY FOR POOR ENGINEERING ON THEIR VEHICLES. AS MANY OTHERS HAVE EXPRESSED, THIS VEHICLE IS NOT EVEN PAID FOR SO THIS IS A HUGE FINANCIAL BURDEN FOR OUR FAMILY. I RECOGNIZE THAT THIS IS NOT A SAFETY ISSUE EXACTLY, BUT IT SURE IS HURTING THE POCKETBOOK OF CONSUMERS WHO HAVE NO PROTECTION FROM CONSUMER LAWS ONCE IT'S PAST THE 1 YR FOR LEMON LAW OR THE WARRANTY HAS EXPIRED. HOW DO WE GET SUPPORT AS A GROUP TO GET A CLASS ACTION LAWSUIT STARTED? NOT BUILT FORD TOUGH!

NHTSA ODI #10154221

2005 model year · 8,000 miles · Mar 29, 2006

Power TrainInjury

Read full complaint

DT*: THE CONTACT STATED THE VEHICLE WAS PLACED IN PARK WHILE RUNNING AND THE EMERGENCY BRAKE APPLIED. AS THE CONTACT WAS STANDING OUTSIDE THE VEHICLE AND RELEASING THE PARKING BRAKE, THE VEHICLE ENGAGED INTO REVERSE, AND CAUGHT THE CONTACT IN THE SIDE. THE VEHICLE PROCEEDED TO DRAG THE CONTACT INTO A 4 LANE HIGHWAY THEN RAN OVER THE CONTACT AND PINNED THE CONTACT'S LEG. THE CONTACT WAS RAN OVER BY THE DRIVER'S SIDE FRONT TIRE AND TRAPPED. A BYSTANDER WATCHED THE ACCIDENT TAKE PLACE AND TO RELEASE THE CONTACT FROM UNDERNEATH THE VEHICLE, THE BYSTANDER WAS REQUIRED TO DRIVE BACK OVER THE LEG TO SAVE THE LIFE OF THE CONTACT. MAJOR INJURIES WERE SUSTAINED TO THE LEG AND SIDE. THE POLICE WERE CONTACTED TO INVESTIGATE THE INCIDENT AND PROVIDED A WRITTEN REPORT. THE VEHICLE HAS REMAINED PARKED AND HAS NOT BEEN TAKEN TO THE DEALERSHIP.

NHTSA ODI #10153990

1994 model year · 21,782 miles · Mar 28, 2006

Power TrainCrashInjury

VEHICLE'S AUTOMATIC TRANSMISSION ENGAGED AT 2500 RPM DURING A CA. STATE SMOG INSPECTION . RESULTED IN TECHNICIAN BEING PINNED AND CRUSHED TO VEHICLE PARKED IN FRONT . TECH WAS AMBULANCED TO HOSPITAL WITH SEVERE LOWER LEG AND ANKLE INJURIES TRANSMISSION WAS REBUILT AT OTHER SHOP AFTER SAID FAILURE. *JB

NHTSA ODI #10153957

2002 model year · Mileage unknown · Mar 27, 2006

Power Train

WHILE DRIVING ON THE FREEWAY, MY O/D LIGHT STARTED FLASHING AND MY CAR WOULD NOT SHIFT. I ENDED UP HAVING TO DRIVE AT 25 MPH AND AT 5000 RPMS IN ORDER TO GET HOME. I HAVE HEARD OF MORE THAN SEVERAL OTHER PEOPLE HAVING THE SAME PROBLEM WITH 2002 EXPLORERS. FORD DID NOTHING TO HELP ME. *JB

NHTSA ODI #10153785

Related Official recalls

26V402000 · Power Train:automatic Transmission

Jun 24, 2026

Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.

Consequence & remedy

Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.

23V199000 · Parking Brake:electrical; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Mar 24, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.

Consequence & remedy

Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

Additional source detail variants (2)

Parking Brake:electrical

Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

23V069000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 10, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.

Consequence & remedy

Consequence: A park system that is damaged may not shift into "PARK," resulting in a vehicle rollaway and increasing the risk of injury or crash.

Remedy: Dealers will inspect the park system for damage and repair as necessary, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S05.

23V070000 · Power Train:automatic Transmission

Feb 10, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."

Consequence & remedy

Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.

Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.

19V575000 · Electrical System: Instrument Cluster/panel; Parking Brake; Power Train:automatic Transmission:gear Position Indication (prndl)

Aug 5, 2019

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."

Consequence & remedy

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Additional source detail variants (3)

Parking Brake

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Electrical System: Instrument Cluster/panel

Power Train:automatic Transmission:gear Position Indication (prndl)

07V453000 · Power Train:automatic Transmission:cooling Unit And Lines

Sep 26, 2007

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY LOOSEN AND THE TRANSMISSION OIL COOLER LINES MAY DISENGAGE FROM THE TRANSMISSION, CAUSING A TRANSMISSION FLUID LEAK.

Consequence & remedy

Consequence: IF LEAKING TRANSMISSION FLUID CONTACTS THE CATALYTIC CONVERTER, IT MAY POSE A RISK OF FIRE.

Remedy: DEALERS WILL INSPECT AND HAVE THE TRANSMISSION COOLER LINE ATTACHMENT BOLT TIGHTENED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 30, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

00V395000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Nov 28, 2000

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. AT THESE EXTREME SPEEDS, THE VEHICLE COULD BE CAPABLE OF EXCEEDING THE SPEED RATING OF THE TIRE.

Consequence & remedy

Consequence: OPERATING THE VEHICLE ABOVE THE MAXIMUM SPEED RATING COULD LEAD TO A TIRE FAILURE WHICH AT THESE SPEEDS COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE.

91V189000 · Power Train:automatic Transmission

Nov 4, 1991

WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR.

Consequence & remedy

Consequence: DRIVER MAY BELIEVE THE VEHICLE IS SAFELY ENGAGED IN PARKWHEN THE GEAR IS NOT TRULY ENGAGED. THIS CAN LEAD TO THE VEHICLE JUMPING OUT OFGEAR UNINTENTIONALLY, VEHICLE ROLLAWAY WHEN PARKED ON A SLOPED SURFACE, ANDINADVERTENT MOTION WHEN THE VEHICLE IS STARTED. ALL OF THESE CONDITIONS CANRESULT IN A VEHICLE ACCIDENT.

Remedy: REPAIR THE TRANSMISSION WITH A NEW PARK PAWL.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

Related NHTSA investigations

EA09013 · Vehicle Rollaway Allegations

Opened Aug 18, 2009 · Closed Feb 12, 2013

Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:column Shift; Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

Additional source detail variants (5)

Power Train:automatic Transmission:gear Position Indication (prndl)

Power Train:automatic Transmission:lever And Linkage:column Shift

Steering:column

Steering:column LOCKING:ANTI-THEFT Device

Steering

RQ97015 · Parking Pawl

Opened Oct 29, 1997 · Closed Apr 1, 1999

Status: closed (inferred from source dates) · Power Train:automatic Transmission

WHEN THE AUTOMATIC SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARKING PAWL DOES NOT ALWAYS ENGAGE THE PARK GEAR.THIS CAN LEAD TO THE VEHICLE JUMPING OUT OF GEAR UNINTENTIONALLY AND CAUSE THE VEHICLE TO START ROLLING INADVERTENTLY

PE91127 · Park Pawl Bending

Opened Sep 16, 1991 · Closed Nov 8, 1991

Status: closed (inferred from source dates) · Power Train:automatic Transmission

There is no summary currently available

Additional source detail variants (2)

Power Train:automatic Transmission

There is no summary currently available

Power Train:automatic Transmission

There is no summary currently available