IllustrationWHILE COMING TO A STOP AT 20 MPH VEHICLE STALLED/ LOST POWER. CONSUMER PULLED OVER AND MANAGED TO GAIN CONTROL OF THE VEHICLE. *AK
1990 Ford Explorer
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
Counts are not adjusted for sales, age, mileage exposure or reporting. A lower count does not establish that a car is problem-free.
About this comparison →12Owner complaints
Model-year median: 609
0Recall campaignsView recall details →
2InvestigationsView investigation details →
Check a VIN with NHTSA ↗ Model-level counts do not show whether a particular VIN is affected or repaired.
Inspection summary
1990 Ford Explorer
NHTSA snapshot: September 18, 2026. 12 owner complaints · 0 recall campaigns · 2 investigations.
Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
Top reported categories (up to 5)
- Engine And Engine Cooling: 2 reports
- Fuel System, Gasoline: 2 reports
- Power Train: 2 reports
- Service Brakes, Hydraulic: 2 reports
- Tires: 2 reports
Full reported-category list and vehicle report
Recall links
No recall campaigns in this snapshot.
Check a VIN with NHTSA. Model-level history does not establish whether a particular VIN is affected or repaired.
Print the top reported categories, recall links, snapshot date and comparison limits.
How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales, mileage exposure and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 12 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports0 injury reports
What owners actually said
12 reportsFUEL GAUGE NO LONGER WORKS,. CONSUMER CANNOT TELL THE AMOUNT OF FUEL LEFT IN TANK.*AK
WHILE DRIVING 58 MPH OPENED SUN ROOF, IT DISCONNECTED AND FELL OFF.*AK
PULLING INTO DRIVEWAY & APPLIED BRAKES, PEDAL LOCKED IN ONE SPOT. VEHICLE WAS FREE ROLLING & HIT A GARAGE DOOR. TOWED VEHICLE TO DEALER & MECHANIC RAN A DIAGNOSTIC TEST FOR BRAKES & FOUND NOTHING. PROBLEM HAPPENED AGAIN SINCE HAVING ENGINE WORK DONE. PROBLEM WAS INTERMITTENT. *AK
I HAD THREE TIRES LOSE THE ENTIRE CENTER TREAD ON MY PREVIOUS VEHICLE (90 FORD EXPLORER) WHILE TRAVELING AROUNG 70MPH. ALL THREE WERE WITHIN A MONTH OF EACH OTHER. THE FIRST TIRE THAT WENT CAUSED DAMAGE TO MY VEHICLE BODY THAT WAS REPORTED TO MY INSURANCE.( DOT NUMBER: TIRE SIZE: P235/75R15 )
FIRESTONE RADIAL ATX TIRES P23575R15 ORIGINAL EQUIPMENT ON A 90 EXPLORER. WHILE DRIVING 70MPH THE DRIVER HEARD A LOUD NOISE AND NOTICED THAT REAR DRIVER'S SIDE TREAD HAD SEPARATED ,THROUGH REAR VIEW MIRROR, CAUSING DAMAGE TO VEHICLE. *AK DOT#W2HL 1PM. *SLC
NO SUMMARY LISTED FOR THIS VEHICLE. *AK
CONNECTING PIPES ON THE GAS TANK ARE FORMED FROM SEAMED STEAL PIPE, AND THE SEAM IS SEALED DUE TO BAD MANUFACTURING. THE SEAM BENDS OVER AND EVENTUALLY RUSTS AWAY, AND ALLOWS GAS TO LEAK TO GROUND. DEALER CONTACTED AND CANNOT DUPLICATE THE PROBLEM. *AK
ENGINE FIRE.
IN WET WEATHER THE ABS ANTI-LOCK BRAKES LOCK UP . *AK
Recall campaigns
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Defect investigations
2PE92084 · Front Seat Track Failure
Opened Oct 23, 1992 · Closed Feb 26, 1993
Status: closed (inferred from source dates) · Seats
There is no summary currently available
PE92029 · Whl Separation/torque Loss
Opened Mar 16, 1992 · Closed Aug 31, 1992
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.