COMPONENT SPOTLIGHT

Ford Explorer transmission problems

2,441 distinct owner reports with a transmission-specific component in this snapshot.

General power-train reports are not automatically counted as transmission problems. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.

89 crash reports24 fire reports36 injury reports

Reports by model year

Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.

When problems were reported

Mileage at the reported incident

242

0–25K

245

25–50K

392

50–75K

339

75–100K

321

100–150K

150K+

1,608 reports with mileage · 833 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What owners actually said

2,441 reports

2003 model year · Mileage unknown · Jul 7, 2006

Power Train

Read full complaint

MY SUV HAS 86791 MILES ITS A 2003 AND THE TRANSMISSION WENT.. I WAS DRIVING DOWN THE HIGHWAY AND IT STOP SHIFTING AND THE OVERDRIVE LIGHT KEPT FLASHING. I HAD TO TAKE IT TO THE DEALER AND $1400.00 LATER ITS FIXED.. WITH THE FORD EXPLORER YOU CAN'T CHANGE OR CHECK THE TRANSMISSION FLUID IT'S IN A SEALED CANISTER.. ITS MOSTLY HIGHWAY DRIVING AND THE TRANSMISSION SHOULD NOT HAVE FAILED THIS SOON IN A VEHICLE....THIS IS A POOR DESIGN AND FORD WON'T EVEN FACE UP TO IT.. I ALSO FOUND OUT IT IS A PROBLEM NOT ONLY IN MY CAR BUT IN OTHERS.. *JB

NHTSA ODI #10161827

2004 model year · 50,000 miles · Jul 6, 2006

Power Train

04 EXPLORER HAD HARSH REVERSE. RPM'S WENT TO 7 SHIFTING FROM 2ND TO 3RD GEAR. FORD REFUSED TO DO ANYTHING EVEN THOUGH THEY HAD A "CUSTOMER SATISFACTION CAMPAIGN",FORDS ALTERNATIVE TO A RECALL, THAT EXPIRED LAST YEAR TO PUT AN ADDITIVE IN THE TRANSMISSION FLUID BECAUSE THE PUT IN THE WRONG TYPE. HAD THE SOLENOID REPLACED ONCE B…

Read full complaint

NHTSA ODI #10161711

2006 model year · 5,000 miles · Jul 2, 2006

Power Train

WHEN TRYING TO MOVE THE GEAR SHIFT FROM PARK TO ANY GEAR AFTER BEING PARKED FOR ANY AMOUNT OF TIME; THE GEAR SHIFT SAFETY LEVER WILL NOT ENGAGE ALLOWING ME TO CHANGE GEARS. *NM

NHTSA ODI #10161238

2002 model year · 107,000 miles · Jul 1, 2006

Power Train

Read full complaint

OVERDRIVE LIGHT BEGAN TO FLASH, THEN SHIFTING BECAME VERY DIFFICULT BECOMING INCREASINGLY WORSE TO THE POINT OF NOT SHIFTING AT ALL. NOTICEABLY JERKS WHEN SHIFTING INTO REVERSE. LOTS OF WHINING NOISE FROM UNDER THE VEHICLE. ALSO REAR DIFFERENTIAL MAKES LOUD WHINE/ROAR AT SPEEDS ABOVE 30 AND AT ACCELERATION. I UNDERSTAND THESE ARE VERY COMMON COMPLAINTS AMONG EXPLORER OWNERS AND CAN BE VERY COSTLY. MOST TRANSMISSION REPAIR PEOPLE TELL ME THAT IT IS A MANUFACTURING DEFECT AND THAT FORD SHOULD FIX IT. *JB

NHTSA ODI #10161199

2003 model year · 12,000 miles · Jun 30, 2006

Fuel System, GasolinePower TrainSeats

Read full complaint

HELLO. I HAVE SEVERAL COMPLAINTS REGARDING MY 2003 FORD EXPLORER INCLUDING SEVERAL SAFETY ISSUES. THE FIRST COMPLAINT IS REGARDING THE DRIVER'S SEAT WHICH SHIFTS ROUTINELY ON ACCELERATION AND DE-ACCELERATION. THIS CONCERNS ME IF I GET INTO AN ACCIDENT AND THE SEAT MALFUNCTIONS. THE SECOND COMPLAINT IS REGARDING THE GEAR SHIFTER NOT GOING INTO PARK EASILY. I HAVE TO JIGGLE IT TO INTO PARK. I AM CONCERNED THAT THIS MIGHT NOT PROPERLY ENGAGE PARK AND MY VEHICLE MIGHT ROLL. THIRDLY, MY REAR LIFT GATE TRIM HAS HAD TO BE REPAIRED AT LEAST 3 TIMES. I AM CONCERNED THAT ALTHOUGH THE DEALERSHIP SAYS THERE IS NO SAFETY ISSUE, THERE POSSIBLY COULD BE DUE TO THE REAR LIFT GATE HINGES BEING RECALLED AND REPRESENTATIVE INFORMING ME THAT THE REASON THAT I CONTINUE TO HAVE A CRACK APPEARING IS DUE TO DESIGN FLAW. THIS CONCERNS ME B/C I FREQUENTLY UTILIZE THE LIFT GATE TO RETRIEVE GROCERIES AND OTHER ITEMS AND DO NOT WANT THE WINDOW TO FAIL AND FALL ON MY HEAD. THE REMAINDER CONCERNS ARE REGARDING THE FUNCTION OF MY VEHICLE. I HAVE HAD TO HAVE 3 OF THE WINDOW MOTORS REPLACED UNDER WARRANTY. THE TRANSMISSION HAS HAD TO BE FIXED TWICE (SHIFTING MODULE MALFUNCTION). FINALLY, THE FUEL GAUGE HAD TO BE REPAIRED DUE TO IMPROPER FUEL READINGS. I GUESS ALL THESE ITEMS COULD BE VERY PROBLEMATIC AS WELL B/C I COULD RUN OUT OF GAS AND BE STRANDED WITH MY CHILD, MY VEHICLE MIGHT NOT SHIFT PROPERLY LEAVING ME STRANDED. PLEASE DO NOT HESITATE TO CONTACT ME IF YOU HAVE QUESTIONS. PS. I WOULD ALSO LIKE TO ADD THAT AS I WAS COMPLETING THIS PROCESS I REMEMBERED THAT MY VEHICLE HAD A HIGH PITCHED WHINE THAT HAD TO BE REPAIRED. I DO NOT REMEMBER EXACTLY WHAT HAD TO BE REPAIRED BUT IT WAS COVERED UNDER WARRANTY. *NM

NHTSA ODI #10161178

2002 model year · 86,000 miles · Jun 26, 2006

Power Train

TRANSMISSION WENT BAD WHEN ONLY 3 YEARS OLD, FORD TOLD ME THAT IT'S A KNOWN PROBLEM. *JB

NHTSA ODI #10160777

2002 model year · 54,000 miles · Jun 26, 2006

Power Train

Read full complaint

2002 FORD EXPLORER XLT, 56,000 MILES. WHINING FROM REAR DIFFERENTIAL BETWEEN 40-60 MPH. WHINING GOES AWAY IF PRESSURE IS REDUCED FROM ACCELERATOR OR IF SPEED IS GREATER THAN 60 MPH. SOME LEAKING OF REAR DIFFERENTIAL FLUID AROUND DRIVESHAFT PINION SEAL. ALSO HAD TRANSMISSION REBUILT AT 54,000 MILES DUE TO ROUGH SHIFTING FROM 3 TO 4. TRANSMISSION WAS NOT COVERED UNDER 36,000 MILE WARRANTY. IN MY RESEARCH, I HAVE UNCOVERED MANY OTHER 2002/2003 EXPLORER OWNERS WITH SIMILAR WHINING REAR DIFFERENTIAL ISSUES. WOULD SEEM THAT SINCE THERE ARE MANY OTHERS HAVING THE SAME ISSUE THAT THERE IS SOME DESIGN/MATERIALS FLAW IN THE REAR END GEARBOX CAUSING THIS ISSUE. I WILL BE FORCED TO REPLACE THE REAR END IN ADDITION TO THE TRANSMISSION IF THERE IS NO REMEDY FROM FORD. *JB

NHTSA ODI #10160723

2002 model year · 85,350 miles · Jun 22, 2006

Power Train

AUTOMATIC TRANSMISSION ON 2002 FORD EXPLORER 4WD EDDIE BAUER AT 85450 MILES - 3RD GEAR CLUTCH OUT AND REQUIRES REBUILD. *JB

NHTSA ODI #10160411

2002 model year · 65,000 miles · Jun 20, 2006

Power Train

MY 2002 FORD EXPLORER TRANSMISSION WENT OUT AT 65,000 MILES. NOW ITS COSTING ME $3500 PLUS TAX TO HAVE A REFURBISHED ONE INSTALLED. TRANSMISSIONS SHOULD LAST MUCH LONGER THAN THIS AND I HAVE SEEN A HUGE NUMBER OF FORD TRANSMISSION FAILURES FOR THIS VEHICLE. FORD NEEDS A RECALL AND TO REIMBURSE US THAT HAVE ALREADY PAID. *NM

NHTSA ODI #10160262

2003 model year · Mileage unknown · Jun 12, 2006

Power Train

2003 EXPLORER ENGINE STALLING AND SURGING WHEN DRIVING AND COMING TO A STOP. *TS ***NAR*** THE DEALER REPROGRAMMED THE PCM. 8JB

NHTSA ODI #10160495

Related Official recalls

26V402000 · Power Train:automatic Transmission

Jun 24, 2026

Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.

Consequence & remedy

Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.

23V199000 · Parking Brake:electrical; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Mar 24, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.

Consequence & remedy

Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

Additional source detail variants (2)

Parking Brake:electrical

Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

23V069000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 10, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.

Consequence & remedy

Consequence: A park system that is damaged may not shift into "PARK," resulting in a vehicle rollaway and increasing the risk of injury or crash.

Remedy: Dealers will inspect the park system for damage and repair as necessary, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S05.

23V070000 · Power Train:automatic Transmission

Feb 10, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."

Consequence & remedy

Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.

Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.

19V575000 · Electrical System: Instrument Cluster/panel; Parking Brake; Power Train:automatic Transmission:gear Position Indication (prndl)

Aug 5, 2019

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."

Consequence & remedy

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Additional source detail variants (3)

Parking Brake

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Electrical System: Instrument Cluster/panel

Power Train:automatic Transmission:gear Position Indication (prndl)

07V453000 · Power Train:automatic Transmission:cooling Unit And Lines

Sep 26, 2007

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY LOOSEN AND THE TRANSMISSION OIL COOLER LINES MAY DISENGAGE FROM THE TRANSMISSION, CAUSING A TRANSMISSION FLUID LEAK.

Consequence & remedy

Consequence: IF LEAKING TRANSMISSION FLUID CONTACTS THE CATALYTIC CONVERTER, IT MAY POSE A RISK OF FIRE.

Remedy: DEALERS WILL INSPECT AND HAVE THE TRANSMISSION COOLER LINE ATTACHMENT BOLT TIGHTENED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 30, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

00V395000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Nov 28, 2000

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. AT THESE EXTREME SPEEDS, THE VEHICLE COULD BE CAPABLE OF EXCEEDING THE SPEED RATING OF THE TIRE.

Consequence & remedy

Consequence: OPERATING THE VEHICLE ABOVE THE MAXIMUM SPEED RATING COULD LEAD TO A TIRE FAILURE WHICH AT THESE SPEEDS COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE.

91V189000 · Power Train:automatic Transmission

Nov 4, 1991

WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR.

Consequence & remedy

Consequence: DRIVER MAY BELIEVE THE VEHICLE IS SAFELY ENGAGED IN PARKWHEN THE GEAR IS NOT TRULY ENGAGED. THIS CAN LEAD TO THE VEHICLE JUMPING OUT OFGEAR UNINTENTIONALLY, VEHICLE ROLLAWAY WHEN PARKED ON A SLOPED SURFACE, ANDINADVERTENT MOTION WHEN THE VEHICLE IS STARTED. ALL OF THESE CONDITIONS CANRESULT IN A VEHICLE ACCIDENT.

Remedy: REPAIR THE TRANSMISSION WITH A NEW PARK PAWL.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

Related NHTSA investigations

EA09013 · Vehicle Rollaway Allegations

Opened Aug 18, 2009 · Closed Feb 12, 2013

Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:column Shift; Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

Additional source detail variants (5)

Power Train:automatic Transmission:gear Position Indication (prndl)

Power Train:automatic Transmission:lever And Linkage:column Shift

Steering:column

Steering:column LOCKING:ANTI-THEFT Device

Steering

RQ97015 · Parking Pawl

Opened Oct 29, 1997 · Closed Apr 1, 1999

Status: closed (inferred from source dates) · Power Train:automatic Transmission

WHEN THE AUTOMATIC SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARKING PAWL DOES NOT ALWAYS ENGAGE THE PARK GEAR.THIS CAN LEAD TO THE VEHICLE JUMPING OUT OF GEAR UNINTENTIONALLY AND CAUSE THE VEHICLE TO START ROLLING INADVERTENTLY

PE91127 · Park Pawl Bending

Opened Sep 16, 1991 · Closed Nov 8, 1991

Status: closed (inferred from source dates) · Power Train:automatic Transmission

There is no summary currently available

Additional source detail variants (2)

Power Train:automatic Transmission

There is no summary currently available

Power Train:automatic Transmission

There is no summary currently available