COMPONENT SPOTLIGHT

Ford Explorer transmission problems

2,441 distinct owner reports with a transmission-specific component in this snapshot.

General power-train reports are not automatically counted as transmission problems. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.

89 crash reports24 fire reports36 injury reports

Reports by model year

Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.

When problems were reported

Mileage at the reported incident

242

0–25K

245

25–50K

392

50–75K

339

75–100K

321

100–150K

150K+

1,608 reports with mileage · 833 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What owners actually said

2,441 reports

2002 model year · 60,000 miles · Feb 25, 2007

Power Train

Read full complaint

TRANSMISSION FAILED AFTER HAVING BEEN SERVICED ON MULTIPLE OCCASIONS BY FORD DEALERSHIP. TRANSMISSION FAILED CAUSING VEHICLE TO BE DISABLED IN TRAVEL AREA OF THE ROADWAY. FORD DEALERSHIP STATED ON MULTIPLE OCCASIONS THAT THERE WAS "NO PROBLEM WITH THE TRANSMISSION". VEHICLE NOW NEEDS NEW TRANSMISSION AFTER ONLY 60,000 MILES AT COST OF $2000 +. THIS IS AN ONGOING PROBLEM WITH 2002 FORD EXPLORER SUV'S AND IMMEDIATE FAILURES ARE DANGEROUS TO PASSENGERS AND OTHER MOTORISTS. *NM

NHTSA ODI #10183443

2004 model year · Mileage unknown · Feb 25, 2007

Power Train

DELAYED SHIFTING FROM PARK TO REVERSE AND REVERSE TO DRIVE, SOMETIMES 10 SECONDS TO CATCH GEAR. HARD SHIFTING FROM PARK TO REVERSE, SLAMS INTO GEAR. CLUNKING WHEN PARKING OR WHEELS AT FULL LOCK. *NM

NHTSA ODI #10183454

2003 model year · 51,600 miles · Feb 21, 2007

Power Train

Read full complaint

I HAVE A 2003 FORD EXPLORER WITH 51,000 MILES. ON 2/13/2007 O/D LIGHT STARTED FLASHING AND SERVICE TRANSMISSION MESSAGE APPEARED IN MESSAGE CENTER. TOOK TO AN INDEPENDENT SERVICE SHOP AND WAS TOLD IT WAS PROBABLY THE TORQUE CONVERTER. HAD IT TRANSFERRED TO A TRANSMISSION SHOP WHERE THEY REMOVED THE TRANSMISSION PAN AND FOUND METAL SHAVINGS. THEY SAID IT IS THE TORQUE CONVERTER AND I WILL NEED A PARTIAL OR FULL REBUILD, THEY WILL NOT BE SURE UNTIL THEY REMOVE THE TRANSMISSION. THEY ALSO MENTIONED THEY HAVE SEEN THIS IN MULTIPLE VEHICLES AND HAVE HAD TO REPLACE A LARGE NUMBER OF EXPLORER TRANSMISSIONS FOR SIMILAR PROBLEMS. *JB

NHTSA ODI #10183131

2002 model year · 66,000 miles · Feb 20, 2007

Power Train

TRANSMISSION WENT AT 66K AND CAUSED ME SAFETY CONCERNS WHEN DRIVING BECAUSE I COULD NOT ACCELERATE. *JB

NHTSA ODI #10183057

2000 model year · 89,591 miles · Feb 19, 2007

Power Train

PREMATURE FAILURE OF AUTOMATIC TRANSMISSION, 2000 FORD EXPLORER, TRANSMISSION IS THE SAME USED IN THE PINTO. VERY UNDER RATED FOR WHAT IT IS EXPECTED TO PERFORM. *NM

NHTSA ODI #10182970

2006 model year · Mileage unknown · Feb 18, 2007

Power Train

Read full complaint

OUR 2006 EDDIE BAUER V-8 AUTOMATIC TRANSMISSION HAS APPROX 6K MILES ON IT AND SINCE THE VERY FIRST DAY THERE HAS BEEN A HESITATION WHEN SHIFTING. FROM PARK TO REVERSE AND FROM REVERSE INTO DRIVE. THERE IS A SIGNIFICANT LAG TIME FROM ENGAGING THE TRANSMISSION TO MOVEMENT AND IS USUALLY ASSOCIATED WITH A RATHER LARGE "CLUNK". THIS IS OUT 4TH EXPLORER AND ENJOY THE STYLING BUT AM VERY CONCERNED ABOUT THIS OBVIOUS ENGINEERING FLAW. IT APPEARS FORD IS AWARE OF IT BUT HAS NO "FIX". *JB

NHTSA ODI #10182921

2004 model year · 15,000 miles · Feb 16, 2007

Power TrainSeatsVehicle Speed Control

Read full complaint

AUTO-TRANSMISSION HESITATES WHEN PUT INTO REVERSE THEN LUNGES ONCE TRANSMISSION IS ENGAGED. WHEN SHIFTING FROM REVERSE TO DRIVE THERE IS A LOUD CLUNKING SOUND. AUTOMATIC TRANSMISSION SHIFTS HARD SOMETIMES WHILE IN DRIVE. FORD SERVICE SAID THEY COULD NOT REPRODUCE AND FOUND NO PROBLEM. THIS BEGAN HAPPENING AT ABOUT 15,000 MILES. VEHICLE NOW HAS ALMOST 36,000 MILES AND PROBLEM HAS GOTTEN MUCH WORSE. ENGINE DIES WHEN TRAVELING LOW SPEEDS AND USING THE CRUISE CONTROL. EACH TIME I TRY TO USE THE CRUISE CONTROL WHEN TRAVELING 40 MPH OR LESS THE ENGINE DIES. THIS CREATES A VERY DANGEROUS SITUATION WHEN YOUR DRIVING ALONG THEN SUDDENLY YOU LOSE POWER TO THE STEERING AND BRAKES BECAUSE THE ENGINE HAS DIED! THE SEATS ARE ALSO PROBLEMATIC. THE 2 BACK SEATS FOLD DOWN. BOTH OF THE RELEASE MECHANISMS HAVE BEEN REPLACED AND ONE NEEDS TO BE REPLACED AGAIN. BOTH HANDLES HAVE BROKEN OFF TWICE. THE LEATHER ON THE DRIVERS SEAT HAS CRACKED AND WORN PREMATURELY. THE LUMBAR SUPPORT KNOB ON THE DRIVERS SEAT FELL OFF BUT I DIDN'T NOTICE WHEN IT HAPPENED SO IT WAS LOST AND FORD WILL NOT REPLACE IT WITHOUT THE DEFECTIVE PART. ALSO THE HANDLE THAT IS USED TO ADJUST THE BACK OF THE SEAT HAS FALLEN OFF. I AM A 53 YEAR OLD WOMEN AND 98% I AM THE ONLY ONE USING THIS VEHICLE. I DO NOT ROUTINELY HAUL KIDS OR OTHER CARGO AROUND IN THIS VEHICLE SO YOU WOULD THINK THE SEATS WOULD BE HOLDING UP MUCH BETTER. *JB

NHTSA ODI #10182792

2006 model year · 21,000 miles · Feb 9, 2007

Power Train

Read full complaint

I HAVE A 2006 FORD EXPLORER, V8 6 SPEED. IT HAS BEEN TO THE DEALER THREE TIMES FOR A FIX ON THE TRANSMISSION. WHEN DOWNSHIFTING BETWEEN 2ND AND 1ST, THE VEHICLE LURCHES FORWARD OR THERE IS A VERY LARGE SHIFT IN MOMENTUM THAT PUSHES THE CAR FORWARD WHILE STOPPING OR OCCASIONALLY AFTER STOPPED. THIS ACTUALLY PUSHED MY CAR FORWARD INTO AN ICY INTERSECTION. FORD IS AWARE OF THE ISSUE, BUT HAS FAILED TO COME UP WITH A FIX. MY VEHICLE IS NOT THE ONLY ONE WITH THE PROBLEM, AND THIS ONLY COMPOUNDS TRANSMISSION ISSUES AND VIBRATION I HAD ON MY LAST TWO (2003 AND 2004) EXPLORERS. I LOVE THIS PARTICULAR VEHICLE, BUT WILL LIKELY NOT PURCHASE ANOTHER EXPLORER....TOO MANY VIBRATIONS AND TRANSMISSION PROBLEMS. *JB

NHTSA ODI #10182105

2002 model year · 102,000 miles · Feb 8, 2007

Power Train

GEAR SHIFT LEVER BROKE OFF COLUMN, WHERE IT ATTACHES TO TOP OF SHIFT CABLE. WAS UNABLE TO SHIFT VEHICLE INTO OR OUT OF ANY GEAR. HAD TO HAVE VEHICLE TOWED TO A DEALERSHIP FOR REPAIR WHICH IS COSTING $1300.00, SERVICE DEPARTMENT STATED THEY COULD NOT REPLACE PART THAT BROKE, BUT HAD TO REPLACE THE WHOLE COLUMN. *NM

NHTSA ODI #10181941

2006 model year · Mileage unknown · Feb 7, 2007

Power Train

Read full complaint

I PURCHASED A BRAND NEW 2006 FORD EXPLORER LIMITED WITH THE NEW 6-GEAR 8 CYLINDER ENGINE. DURING DOWNSHIFT TO A STOP, THE TRUCK WOULD LITERALLY LURCH FORWARD AS THE ENGINE JERKED INTO THE PROPER GEAR. AFTER REPEATED VISITS (IN EXCESS OF 5) TO THE DEALERSHIP, AND REPLACEMENTS OF VALVES AND A WHOLE NEW TRANSMISSION, THE PROBLEM IS NOT AS EVIDENT, BUT CONTINUES NONETHELESS. NEW PROBLEMS HAVE ALSO DEVELOPED, SUCH AS "JERKING" MOVEMENTS ON TAKE OFF (AS IF I WERE PRESSING AND RELEASING THE GAS), DELAYED RESPONSE WHEN PRESSING THE ACCELERATOR ON TAKE OFF, AS WELL AS AN ENGINE "ROAR" ON ACCELERATION NOT TYPICAL OF AN ENGINE FAN ; NONE OF THESE ISSUES WERE CORRECTED WHEN BROUGHT TO THE ATTENTION OF THE DEALER'S SERVICE DEPARTMENT (ERNIE HAIRE FORD). I HAVE BEEN FOLLOWING A FORUM ON EDMUNDS.COM WHERE OTHER CONSUMERS ARE HAVING THE EXACT SAME ISSUES; THE "COMPUTER" WAS SIMPLY REPROGRAMMED AND EXPECTED TO "FIX" THE PROBLEM WITH NO FURTHER OPTIONS AVAILABLE, SINCE AN ATTEMPT TO "LEMON LAW" THE VEHICLE WOULD RESULT IN "A LOT OF LAWYERS AND LITIGATION AND PAPERWORK," AS EXPRESSED BY THE SERVICE MANAGER AT ERNIE HAIRE, AND WOULD "PROBABLY WIND UP BEING A WASTE OF MY TIME AND MONEY IF THE COMPANY COULDN'T FIND ANYTHING WRONG WITH THE VEHICLE DURING THE PROCESS". I DID NOT HAVE THESE MECHANICAL ISSUES WITH MY '97 EXPLORER. *NM

NHTSA ODI #10181933

Related Official recalls

26V402000 · Power Train:automatic Transmission

Jun 24, 2026

Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.

Consequence & remedy

Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.

23V199000 · Parking Brake:electrical; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Mar 24, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.

Consequence & remedy

Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

Additional source detail variants (2)

Parking Brake:electrical

Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

23V069000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 10, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.

Consequence & remedy

Consequence: A park system that is damaged may not shift into "PARK," resulting in a vehicle rollaway and increasing the risk of injury or crash.

Remedy: Dealers will inspect the park system for damage and repair as necessary, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S05.

23V070000 · Power Train:automatic Transmission

Feb 10, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."

Consequence & remedy

Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.

Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.

19V575000 · Electrical System: Instrument Cluster/panel; Parking Brake; Power Train:automatic Transmission:gear Position Indication (prndl)

Aug 5, 2019

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."

Consequence & remedy

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Additional source detail variants (3)

Parking Brake

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Electrical System: Instrument Cluster/panel

Power Train:automatic Transmission:gear Position Indication (prndl)

07V453000 · Power Train:automatic Transmission:cooling Unit And Lines

Sep 26, 2007

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY LOOSEN AND THE TRANSMISSION OIL COOLER LINES MAY DISENGAGE FROM THE TRANSMISSION, CAUSING A TRANSMISSION FLUID LEAK.

Consequence & remedy

Consequence: IF LEAKING TRANSMISSION FLUID CONTACTS THE CATALYTIC CONVERTER, IT MAY POSE A RISK OF FIRE.

Remedy: DEALERS WILL INSPECT AND HAVE THE TRANSMISSION COOLER LINE ATTACHMENT BOLT TIGHTENED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 30, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

00V395000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Nov 28, 2000

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. AT THESE EXTREME SPEEDS, THE VEHICLE COULD BE CAPABLE OF EXCEEDING THE SPEED RATING OF THE TIRE.

Consequence & remedy

Consequence: OPERATING THE VEHICLE ABOVE THE MAXIMUM SPEED RATING COULD LEAD TO A TIRE FAILURE WHICH AT THESE SPEEDS COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE.

91V189000 · Power Train:automatic Transmission

Nov 4, 1991

WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR.

Consequence & remedy

Consequence: DRIVER MAY BELIEVE THE VEHICLE IS SAFELY ENGAGED IN PARKWHEN THE GEAR IS NOT TRULY ENGAGED. THIS CAN LEAD TO THE VEHICLE JUMPING OUT OFGEAR UNINTENTIONALLY, VEHICLE ROLLAWAY WHEN PARKED ON A SLOPED SURFACE, ANDINADVERTENT MOTION WHEN THE VEHICLE IS STARTED. ALL OF THESE CONDITIONS CANRESULT IN A VEHICLE ACCIDENT.

Remedy: REPAIR THE TRANSMISSION WITH A NEW PARK PAWL.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

Related NHTSA investigations

EA09013 · Vehicle Rollaway Allegations

Opened Aug 18, 2009 · Closed Feb 12, 2013

Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:column Shift; Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

Additional source detail variants (5)

Power Train:automatic Transmission:gear Position Indication (prndl)

Power Train:automatic Transmission:lever And Linkage:column Shift

Steering:column

Steering:column LOCKING:ANTI-THEFT Device

Steering

RQ97015 · Parking Pawl

Opened Oct 29, 1997 · Closed Apr 1, 1999

Status: closed (inferred from source dates) · Power Train:automatic Transmission

WHEN THE AUTOMATIC SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARKING PAWL DOES NOT ALWAYS ENGAGE THE PARK GEAR.THIS CAN LEAD TO THE VEHICLE JUMPING OUT OF GEAR UNINTENTIONALLY AND CAUSE THE VEHICLE TO START ROLLING INADVERTENTLY

PE91127 · Park Pawl Bending

Opened Sep 16, 1991 · Closed Nov 8, 1991

Status: closed (inferred from source dates) · Power Train:automatic Transmission

There is no summary currently available

Additional source detail variants (2)

Power Train:automatic Transmission

There is no summary currently available

Power Train:automatic Transmission

There is no summary currently available