SkipThatYearREAL DATA. SMARTER CAR DECISIONS.

COMPONENT SPOTLIGHT

Ford Explorer transmission problems

2,441 distinct owner reports with a transmission-specific component in this snapshot.

General power-train reports are not automatically counted as transmission problems. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.

89 crash reports24 fire reports36 injury reports

Reports by model year

YearTopic reportsRecallsInvestigations
2022
1
2422021
3
2622020
13
3332019
4
612018
2
722017
11
1322016
13
1422015
1
852014
3
642013
1
1162011
2
642010
2
112009
1
002008
3
112007
19
112006
120
102005
42
022004
330
042003
159
232002
971
472001
24
622000
98
941999
81
961998
66
981997
64
761996
88
631995
97
561994
54
4131993
55
6141992
63
4141991
48
8171990
2
02

Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.

When problems were reported

Mileage at the reported incident

1,608 reports with mileage · 833 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What owners actually said

2,441 reports
2005 model year · Mileage unknown · Sep 6, 2007
Engine And Engine CoolingExterior LightingPower Train

2005 EXPLORER WITH MULTIPLE PROBLEMS WITH THE ENGINE AND TRANSMISSION. CUSTOMER STATES THE VEHICLE HAS BEEN TO THE DEALER ON 3 SEPARATE OCCASIONS FOR SHUTTING OFF AND PASSING GEARS ALMOST CAUSING ACCIDENTS. *KB THERE WAS A KNOCKING NOISE COMING FROM THE ENGINE AREA. THE VEHICLE JERKED INTO PASSING GEAR WHILE THE CONSUMER WAS…

Read full complaint

2005 EXPLORER WITH MULTIPLE PROBLEMS WITH THE ENGINE AND TRANSMISSION. CUSTOMER STATES THE VEHICLE HAS BEEN TO THE DEALER ON 3 SEPARATE OCCASIONS FOR SHUTTING OFF AND PASSING GEARS ALMOST CAUSING ACCIDENTS. *KB THERE WAS A KNOCKING NOISE COMING FROM THE ENGINE AREA. THE VEHICLE JERKED INTO PASSING GEAR WHILE THE CONSUMER WAS TRYING TO ACCELERATE. THE TRANSMISSION GASKET WAS REPLACED. THE CRUISE CONTROL WOULD NOT ENGAGE. THE LEFT TURN SIGNAL BULB WAS REPLACED. *JB

NHTSA ODI #10202676

2002 model year · 67,117 miles · Sep 6, 2007
Power Train

TL*THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT HE HAD TO REBUILD HIS TRANSMISSION AND REPLACE THE REAR DIFFERENTIAL BEARINGS. THE VEHICLE FAILED WHILE DRIVING 70 MPH. HE STATED THAT THE VEHICLE SHUT OFF WHEN HE SHIFTED INTO REVERSE. HE HAD TO WAIT A FEW MINUTES BEFORE THE VEHICLE COULD BE RESTARTED. THE V…

Read full complaint

TL*THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT HE HAD TO REBUILD HIS TRANSMISSION AND REPLACE THE REAR DIFFERENTIAL BEARINGS. THE VEHICLE FAILED WHILE DRIVING 70 MPH. HE STATED THAT THE VEHICLE SHUT OFF WHEN HE SHIFTED INTO REVERSE. HE HAD TO WAIT A FEW MINUTES BEFORE THE VEHICLE COULD BE RESTARTED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 80,000 AND FAILURE MILEAGE WAS 67,117.

NHTSA ODI #10202117

2004 model year · 64,800 miles · Sep 6, 2007
Power Train

2004 FORD EXPLORER. WHEN PUTTING INTO REVERSE, VEHICLE BANGS, YOU CAN HEAR AND FEEL IT. WAS IN SHOP, AND FFOUND NOTHING WRONG. OCCURRED OCCAISIONALLY, NOW ALOT! NOW MY TRANSMISSION IS LEAKING FLUID. MY WARRANTY RAN OUT 5,000 MILES AGO. I DON'T THINK THIS IS NORMAL IN A NEWER CAR.

NHTSA ODI #10202061

2002 model year · 76,161 miles · Sep 5, 2007
Power Train

WE HAVE A 2002 FORD EXPLORER. WE PURCHASED THIS USED IN AUGUST 2004. ON JUNE 2005 WE STARTED HAVING TROUBLE WITH THE TRANSMISSION AND TOOK IT IN TO THE DEALERSHIP ON JUNE 8, 2005 THEY HAD IT FOR 8 DAYS AND REPAIRED IT UNDER WARRANTY. WE TOOK IT BACK ON JUNE 24, 2005 FOR THE SAME PROBLEM. THEY HAD IT FOR 5 DAYS BUT SAID THEY CO…

Read full complaint

WE HAVE A 2002 FORD EXPLORER. WE PURCHASED THIS USED IN AUGUST 2004. ON JUNE 2005 WE STARTED HAVING TROUBLE WITH THE TRANSMISSION AND TOOK IT IN TO THE DEALERSHIP ON JUNE 8, 2005 THEY HAD IT FOR 8 DAYS AND REPAIRED IT UNDER WARRANTY. WE TOOK IT BACK ON JUNE 24, 2005 FOR THE SAME PROBLEM. THEY HAD IT FOR 5 DAYS BUT SAID THEY COULD NOT DUPLICATE THE PROBLEM. ON JAN 20, 2006 WE HAD TO TAKE IT BACK IN TO THE DEALERSHIP FOR TRANSMISSION PROBLEMS AGAIN. THEY HAD IT FOR 7 DAYS THIS TIME AND REPAIRED THE PROBLEM UNDER WARRANTY. THEN ON FEB 10, 2006 WE HAD TO TAKE IT BACK TO THE DEALERSHIP FOR TRANSMISSION PROBLEMS AGAIN. THIS TIME THEY HAD IT FOR 19 DAYS AND AGAIN REPAIRED IT UNDER WARRANTY. NOW WE ARE HAVING TRANSMISSION PROBLEMS AGAIN AND WE TOOK IT TO THE DEALERSHIP FOR REPAIR BUT THEY SAY IT IS OUT OF WARRANTY AND THAT THERE IS NOTHING THEY CAN DO FOR US. THEY SAY THAT IT HAS BEEN 1-1/2 YEARS AND 40,000 MILES SINCE IT WAS LAST WORKED ON AND IT IS OUT OF WARRANTY. AFTER TALKING TO EVERYONE AT THE DEALERSHIP FROM THE SERVICE MGR, THE GENERAL MANAGER AND FINALLY THE OWNERS DAUGHTER, ALL THEY ARE WILLING TO DO FOR US IS TO REPLACE THE TRANSMISSION AND GIVE US THE EMPLOYEE DISCOUNT PRICE WHICH IS $ 2641.50. I FEEL THAT THIS IS AN OWN GOING PROBLEM AND THAT THE TRANSMISSION IS A LEMON AND THEY SHOULD HAVE TO REPLACE THE TRANSMISSION AT NO CHARGE TO US. ALSO AFTER DOING SOME RESEARCH ON THE INTERNET, I AM FINDING THAT THIS SEEMS TO BE A PROBLEM WITH A LOT OF 2002 FORD EXPLORERS

NHTSA ODI #10201897

2006 model year · Mileage unknown · Aug 31, 2007
Power Train

ON SEVERAL OCCASIONS WHEN SHIFTING INTO REVERSE THE VEHICLE WAS EXTREMELY HESITANT & EVENTUALLY WOULD LUNGE BACKWARDS WHILE MAKING A LOUD "CLACK" AS IT JUMPED INTO GEAR. ANOTHER TIME I STARTED MY CAR & IT LUNGED INTO PARK AS IF IT WAS NEVER IN PARK COMPLETELY BEFORE I SHUT OFF AND EXITED THE VEHICLE PRIOR TO THIS. WE ALL KNOW YO…

Read full complaint

ON SEVERAL OCCASIONS WHEN SHIFTING INTO REVERSE THE VEHICLE WAS EXTREMELY HESITANT & EVENTUALLY WOULD LUNGE BACKWARDS WHILE MAKING A LOUD "CLACK" AS IT JUMPED INTO GEAR. ANOTHER TIME I STARTED MY CAR & IT LUNGED INTO PARK AS IF IT WAS NEVER IN PARK COMPLETELY BEFORE I SHUT OFF AND EXITED THE VEHICLE PRIOR TO THIS. WE ALL KNOW YOU CANT TAKE THE KEYS OUT OF THE IGNITION W/O IT BEING IN PARK,SO EXPLAIN THIS! AFTER NUMEROUS COMPLAINTS TO MY DEALERSHIP THEY FIND A PROBLEM(A FACTORY DEFECT,NOT ONE CAUSED BY ME)THEY REPLACED PARTS AND NOW ONLY A FEW MONTHS LATER I AM HAVING THE SAME PROBLEMS ALL OVER AGAIN. ONLY NOW MY PROBLEMS ARE WORSE. WHILE DRIVING INSTEAD OF SHIFTING MY CAR JUST REVS REAL HIGH & GOES NOWHERE. THIS LASTS ANYWHERE FROM 15-45 SECONDS & THEN STOPS. IT ALSO IS HESITANT WHEN SHIFTING FROM GEAR TO GEAR. I HAVE MY CAR SERVICED REGULARLY AND DONT DRVE IT HARD,I SHOULD NOT BE EXPERIENCING THESE PROBLEMS AT ALL!!! I AM A VERY,VERY UNHAPPY FORD OWNER. I PAID $38,000 CASH FOR THIS VEHICLE THE DAY I BOUGHT IT & HAVE HAD NOTHING BUT PROBLEMS SINCE,ONLY REGRETS. *JB

NHTSA ODI #10201621

2002 model year · 96,000 miles · Aug 29, 2007
Power Train

MY TRANSMISSION HAS TO BE REPLACED WHICH WILL COST $3800. PLUS $500.FOR THE COST OF A RENTAL CAR. 2ND TIME TRANSMISSION HAS TO BE WORKED ON. THE FIRST TIME THE CAR JUST STOPPED IN THE MIDDLE OF RUSH HOUR. CAR IS MAINTAINED EVERY 3000 MILES@A FORD DEALERSHIP. CHECK ENGINE LIGHT CAME ON WITH OVERDRIVE LIGHT BLINKING. *TR

NHTSA ODI #10201118

2006 model year · Mileage unknown · Aug 28, 2007
Electrical SystemEquipmentPower Train

2006 FORD EXPLORER WITH FREQUENT TRANSMISSION PROBLEMS. CUSTOMER STATES THAT THE TRANSMISSION HAS SHIFTING INCONSISTENCIES WHICH CAUSES THE VEHICLE TO SHAKE. *KB THE CONSUMER STATED THE ERRATIC SHIFTING OF THE VEHICLE STARTED THE DAY AFTER PURCHASE AND AFTER THE INCIDENT HE CONTACTED THE DEALERSHIP TO INFORM THEM OF THE DEFEC…

Read full complaint

2006 FORD EXPLORER WITH FREQUENT TRANSMISSION PROBLEMS. CUSTOMER STATES THAT THE TRANSMISSION HAS SHIFTING INCONSISTENCIES WHICH CAUSES THE VEHICLE TO SHAKE. *KB THE CONSUMER STATED THE ERRATIC SHIFTING OF THE VEHICLE STARTED THE DAY AFTER PURCHASE AND AFTER THE INCIDENT HE CONTACTED THE DEALERSHIP TO INFORM THEM OF THE DEFECT. THE DEALERSHIP THEN IN TURN HAD THE CONSUMER COME IN ON 4 SEPARATE OCCASIONS TO RECTIFY THE SITUATION BUT TO NO AVAIL. THE CONSUMER WOULD LIKE THE SITUATION INVESTIGATED AND WOULD LIKE FOR THE DEALER TO REPURCHASE THE VEHICLE AT THE VALUE IN WHICH IT WAS SOLD. THE DEALER STATED THE SPEAKERS SOUND LIKE THEY ARE DISTORTED, TOP COVER OF INSTRUMENT CLUSTER IS LOOSE. *TR

NHTSA ODI #10201545

2002 model year · 63,649 miles · Aug 24, 2007
Power Train

PURCHASED NEW 2002 FORD EXPLORER. I HAD THE ORIGINAL TRANSMISSION REPLACED AT 63,658 MILES DUE TO ITS FAILURE. THE REBUILT ONE THAT COST $2,974 IS NOW SLIPPING @77,853 MILES. IT WILL HAVE TO BE REPLACED SOON AND THE COMPANY THAT DID THE WORK IS NOW OUT OF BUSINESS, THUS THE WARRANTY IS WORTHLESS AND I AM PROBABLY GOING TO HAV…

Read full complaint

PURCHASED NEW 2002 FORD EXPLORER. I HAD THE ORIGINAL TRANSMISSION REPLACED AT 63,658 MILES DUE TO ITS FAILURE. THE REBUILT ONE THAT COST $2,974 IS NOW SLIPPING @77,853 MILES. IT WILL HAVE TO BE REPLACED SOON AND THE COMPANY THAT DID THE WORK IS NOW OUT OF BUSINESS, THUS THE WARRANTY IS WORTHLESS AND I AM PROBABLY GOING TO HAVE TO JUNK THE VEHICLE AND BUY A FOREIGN VEHICLE. *TR

NHTSA ODI #10200643

2000 model year · 32,000 miles · Aug 22, 2007
Power Train

I WAS TOLD IN DEC 2004 BY MY MECHANIC THAT MY TRANSMISSION WAS FAILING (MY VEHICLE HAD ONLY 32K MILES AT THE TIME), BUT BECAUSE MY 2000 FORD EXPLORER WAS TOO OLD, THERE WAS NOT ANY THING THAT I COULD DO OTHER THAN PAY FOR A REPAIR. REGARDLESS OF AGE, I DON'T THINK ANY TRANSMISSION SHOULD FAIL WITH ONLY 32K MILES ON THE CAR. *TR

NHTSA ODI #10200500

2002 model year · Mileage unknown · Aug 19, 2007
Power Train

THE OVERDRIVE LIGHT ON THE 2002 FORD EXPLORER IS BLINKING. THIS WAS AFTER THE 100K MILES CHECKUP. I AM NOW BEING TOLD THAT THE TRANSMISSION IS POSSIBLY DAMAGED DUE TO A FAULTY PART THAT IS A KNOW ISSUE WITH FORD MOTOR COMPANY. *JB

NHTSA ODI #10200063

Related Official recalls

8

26V402000 · Power Train:automatic Transmission

Jun 24, 2026

Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.

Consequence & remedy

Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.

23V199000 · Parking Brake:electrical; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Mar 24, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.

Consequence & remedy

Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

Additional source detail variants (2)

Parking Brake:electrical

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.

Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.

Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

23V069000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 10, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.

Consequence & remedy

Consequence: A park system that is damaged may not shift into "PARK," resulting in a vehicle rollaway and increasing the risk of injury or crash.

Remedy: Dealers will inspect the park system for damage and repair as necessary, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S05.

23V070000 · Power Train:automatic Transmission

Feb 10, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."

Consequence & remedy

Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.

Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.

19V575000 · Electrical System: Instrument Cluster/panel; Parking Brake; Power Train:automatic Transmission:gear Position Indication (prndl)

Aug 5, 2019

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."

Consequence & remedy

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Additional source detail variants (3)

Parking Brake

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Electrical System: Instrument Cluster/panel

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Power Train:automatic Transmission:gear Position Indication (prndl)

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

07V453000 · Power Train:automatic Transmission:cooling Unit And Lines

Sep 26, 2007

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY LOOSEN AND THE TRANSMISSION OIL COOLER LINES MAY DISENGAGE FROM THE TRANSMISSION, CAUSING A TRANSMISSION FLUID LEAK.

Consequence & remedy

Consequence: IF LEAKING TRANSMISSION FLUID CONTACTS THE CATALYTIC CONVERTER, IT MAY POSE A RISK OF FIRE.

Remedy: DEALERS WILL INSPECT AND HAVE THE TRANSMISSION COOLER LINE ATTACHMENT BOLT TIGHTENED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 30, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

00V395000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Nov 28, 2000

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. AT THESE EXTREME SPEEDS, THE VEHICLE COULD BE CAPABLE OF EXCEEDING THE SPEED RATING OF THE TIRE.

Consequence & remedy

Consequence: OPERATING THE VEHICLE ABOVE THE MAXIMUM SPEED RATING COULD LEAD TO A TIRE FAILURE WHICH AT THESE SPEEDS COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE.

91V189000 · Power Train:automatic Transmission

Nov 4, 1991

WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR.

Consequence & remedy

Consequence: DRIVER MAY BELIEVE THE VEHICLE IS SAFELY ENGAGED IN PARKWHEN THE GEAR IS NOT TRULY ENGAGED. THIS CAN LEAD TO THE VEHICLE JUMPING OUT OFGEAR UNINTENTIONALLY, VEHICLE ROLLAWAY WHEN PARKED ON A SLOPED SURFACE, ANDINADVERTENT MOTION WHEN THE VEHICLE IS STARTED. ALL OF THESE CONDITIONS CANRESULT IN A VEHICLE ACCIDENT.

Remedy: REPAIR THE TRANSMISSION WITH A NEW PARK PAWL.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

Related NHTSA investigations

3

EA09013 · Vehicle Rollaway Allegations

Opened Aug 18, 2009 · Closed Feb 12, 2013

Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:column Shift; Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

Additional source detail variants (5)

Power Train:automatic Transmission:gear Position Indication (prndl)

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

Power Train:automatic Transmission:lever And Linkage:column Shift

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

Steering:column

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

Steering:column LOCKING:ANTI-THEFT Device

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

Steering

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

RQ97015 · Parking Pawl

Opened Oct 29, 1997 · Closed Apr 1, 1999

Status: closed (inferred from source dates) · Power Train:automatic Transmission

WHEN THE AUTOMATIC SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARKING PAWL DOES NOT ALWAYS ENGAGE THE PARK GEAR.THIS CAN LEAD TO THE VEHICLE JUMPING OUT OF GEAR UNINTENTIONALLY AND CAUSE THE VEHICLE TO START ROLLING INADVERTENTLY

PE91127 · Park Pawl Bending

Opened Sep 16, 1991 · Closed Nov 8, 1991

Status: closed (inferred from source dates) · Power Train:automatic Transmission

There is no summary currently available

Additional source detail variants (2)

Power Train:automatic Transmission

There is no summary currently available

Power Train:automatic Transmission

There is no summary currently available