NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
22 reportsClear category filter71,000 miles · Sep 29, 2025
Suspension
The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 35-45 MPH, the steering wheel started shaking abnormally. There were no warning lights illuminated. The contact became aware of NHTSA Campaign Number: 19V435000 (Suspension). The local dealer was contacted and provided a cost for the repai…
Read full complaint
The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 35-45 MPH, the steering wheel started shaking abnormally. There were no warning lights illuminated. The contact became aware of NHTSA Campaign Number: 19V435000 (Suspension). The local dealer was contacted and provided a cost for the repair. The vehicle was not diagnosed or repaired. The contact called another local dealer, [XXX] [XXX] ) but no assistance was provided. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 71,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11690332
Mileage unknown · Jul 1, 2025
SteeringSuspension
Clunking noise coming from rear possible tow link, clicking noise coming from steering even when vehicle not moving
NHTSA ODI #11670431
156,000 miles · Apr 7, 2025
StructureSuspension
The contact owns a 2012 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 19V435000 (SUSPENSION) and 24V031000 (STRUCTURE); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The d…
Read full complaint
The contact owns a 2012 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 19V435000 (SUSPENSION) and 24V031000 (STRUCTURE); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact stated while driving 45 MPH, there was a loud sound of air coming from the windshield. There were no warning lights illuminated. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The dealer informed the contact that parts were not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 156,000. VIN tool confirms parts not available for NHTSA Campaign Number: 24V031000 (Structure). Parts distribution disconnect for NHTSA Campaign Number: 19V435000 (Suspension).
NHTSA ODI #11653313
100,000 miles · Mar 25, 2024
Suspension
The contact owns a 2012 Ford Explorer. The contact stated that the vehicle was experiencing a hard pull to the right while depressing the accelerator pedal. The contact stated that the failure occurred while driving from a complete stop and while driving on the highway. The contact received notification of NHTSA Campaign Number:…
Read full complaint
The contact owns a 2012 Ford Explorer. The contact stated that the vehicle was experiencing a hard pull to the right while depressing the accelerator pedal. The contact stated that the failure occurred while driving from a complete stop and while driving on the highway. The contact received notification of NHTSA Campaign Number: 21V746000 (Suspension) and the vehicle was taken to the dealer, where it was determined that the rear toe links needed to be replaced; however, the part to do the recall repair was not yet available. The contact stated that the failure was recurring increasingly. The vehicle was taken back to the dealer, who informed the contact that the recall repair had already been performed on the vehicle; however, the contact stated that the recall repair had not been performed on the vehicle. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.
NHTSA ODI #11579384
198,000 miles · Mar 11, 2024
Suspension
The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed, she heard an abnormal sound coming from underneath the vehicle. The check warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the bushings. The vehicle was not repaired. …
Read full complaint
The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed, she heard an abnormal sound coming from underneath the vehicle. The check warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the bushings. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 198,000.
NHTSA ODI #11576605
Mileage unknown · Feb 5, 2024
Suspension
Rear tires rubbing and car is uneasy in rain. Had to have tires replaced due to rubbing on interior of rear of car. Tires wear extremely fast and dangerous to drive in any weather conditions such as rain. Inspection says there is no alignment or adjustment issues. However tires continue to wear apparently there are aftermarket p…
Read full complaint
Rear tires rubbing and car is uneasy in rain. Had to have tires replaced due to rubbing on interior of rear of car. Tires wear extremely fast and dangerous to drive in any weather conditions such as rain. Inspection says there is no alignment or adjustment issues. However tires continue to wear apparently there are aftermarket parts to make it adjustable but what is wrong with it in the first place? Very dangerous to drive in rain. Slides all over the place. Tires slightly bend in.
NHTSA ODI #11570125
183,000 miles · Aug 3, 2023
SteeringSuspension
The contact owns a 2012 Ford Explorer. The contact stated while driving 20-30 MPH, the steering wheel became significantly difficult to steer. The contact was able to continue driving by using his physical strength to steer the steering wheel. There was no further information provided. The contact stated that as he arrived to th…
Read full complaint
The contact owns a 2012 Ford Explorer. The contact stated while driving 20-30 MPH, the steering wheel became significantly difficult to steer. The contact was able to continue driving by using his physical strength to steer the steering wheel. There was no further information provided. The contact stated that as he arrived to the residence, the steering wheel locked. The vehicle was towed to the used car dealer it was purchased from, and it was diagnosed that the rack and pinion needed to be replaced. The Ford dealer was contacted and informed the contact that the vehicle could not be covered under Ford Campaign Number: 15N01, as the campaign had expired. The vehicle was not repaired. Additionally, the contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair of NHTSA Campaign Number: 19V435000 (Suspension). The manufacturer were contacted, but no assistance was provided. The failure mileage was approximately 183,000.
NHTSA ODI #11536286
139,000 miles · Sep 30, 2022
StructureSuspension
The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 55 MPH, he heard an abnormal snapping sound then a clunking sound coming from underneath the vehicle. The traction control and the ABS warning lights were illuminated. The contact was able to get the vehicle back to the residence while dri…
Read full complaint
The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 55 MPH, he heard an abnormal snapping sound then a clunking sound coming from underneath the vehicle. The traction control and the ABS warning lights were illuminated. The contact was able to get the vehicle back to the residence while driving approximately 10 MPH. The contact stated that the front subframe was corroded, causing the subframe to fracture and the wheels were pushed outwards in opposite directions. The contact had taken the vehicle to a certified mechanic who replaced the subframe. The manufacturer was made aware of the failure. The approximate failure mileage was 139,000.
NHTSA ODI #11487202
Mileage unknown · Oct 9, 2021
Suspension
I have had 3 upper rear lateral links snap off. 2 on the rear driver side and 1 on the rear passenger side. I am researching recalls. And there is a recall on some explorer models for the rear toe links. Sounds like the same thing that keeps happening to my vehicle. I am scared to drive it now. They literally just snap and the b…
Read full complaint
I have had 3 upper rear lateral links snap off. 2 on the rear driver side and 1 on the rear passenger side. I am researching recalls. And there is a recall on some explorer models for the rear toe links. Sounds like the same thing that keeps happening to my vehicle. I am scared to drive it now. They literally just snap and the back tire starts steering however it wants.
NHTSA ODI #11436182
Mileage unknown · Apr 24, 2021
SuspensionUnknown Or Other
JUST PURCHASED THIS CAR, DECIDED TO LOOK UP ANY RECALLS AND FOUND 1 PERTAINING TO THE TOE LINKS. LOOKING THROUGHLY AT THE VEHICLE THERE ARE A LOT OF MAJOR DEFECTS. THIS IS GOING TO BE A DAILY DRIVER FOR MY DAUGHTER AND I AND I TRULY DON'T FEEL SAFE AS I'M READING ALL THE REVIEWS AND RECALLS. THE ONLY THING I CAN MENTION AT THIS …
Read full complaint
JUST PURCHASED THIS CAR, DECIDED TO LOOK UP ANY RECALLS AND FOUND 1 PERTAINING TO THE TOE LINKS. LOOKING THROUGHLY AT THE VEHICLE THERE ARE A LOT OF MAJOR DEFECTS. THIS IS GOING TO BE A DAILY DRIVER FOR MY DAUGHTER AND I AND I TRULY DON'T FEEL SAFE AS I'M READING ALL THE REVIEWS AND RECALLS. THE ONLY THING I CAN MENTION AT THIS MOMENT ABOUT THIS CAR WOULD BE THE BACK WASHER FLUID LEAKS INTO THE CABIN, THE HOOD OF THE CAR DOES NOT SHUT CORRECTLY-HANDLE FOR THIS AREA IS LOOSE. THE STATE OF THIS CAR IS UNKNOWN.
NHTSA ODI #11413698
Official recalls
5Jan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Sep 22, 2021
Ford Motor Company (Ford) is recalling certain 2011-2013 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. These vehicles may be equipped with a cross-axis ball joint (CABJ) replacement part that could seize, and result in a fracture of the outboard section of the rear suspension toe link.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealer will inspect for the presence of a CABJ. If a CABJ of any design is found, the dealer will inspect the tightness of the CABJ, and replace the CABJ, knuckle, and/or toe link as necessary, free of charge. Interim notification letters were mailed November 10, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S43.
Jun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Consequence & remedy
Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Mar 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Explorer vehicles. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.
Consequence & remedy
Consequence: If the interior door handle return spring is unseated, the door may unlatch in the event of a side impact crash, increasing the risk of personal injury.
Remedy: Ford will notify owners, and dealers will inspect all four of the interior door handles and either repair or replace them, free of charge. The recall began on July 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S11.
May 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012. The affected vehicles may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting in a shut down of the power steering assist.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist it will require extra steering effort at lower speeds, increasing the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will update the Power Steering Control Module (PSCM) software, free of charge. If a vehicle shows a history of a loss of motor position sensor signal when the vehicle is brought in for the recall remedy, its steering rack assembly will be replaced, free of charge. The recall began on July 23, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S06.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA17002 · Exhaust Odor In Passenger Cab
Opened Jul 27, 2017 · Closed Jan 17, 2023
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
PE16008 · Ford Explorer Exhaust Odor
Opened Jul 1, 2016 · Closed Sep 12, 2017
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System; Structure:body
During the National Highway Traffic Safety Administration?s (NHTSA?s) investigation into the Ford carbon monoxide allegations, the Office of Defects Investigation (ODI) identified additional Vehicle Owner Questionnaire (VOQ) reports with similar exhaust odor claims.Presently, ODI has identified 791 VOQs for Model Year 2011-2017 Ford Explorers pertaining to exhaust odor claims.ODI has identified three crashes and 41 injuries potentially linked this issue.The reported injuries range from unspecified to loss of consciousness, with the majority being nausea, headaches, or dizziness ? all of which can be symptomatic of carbon monoxide exposure.Additionally, Ford provided 2,400 reports including owner complaints, warranty claims, dealer field reports, and legal claims, that involve 2,051 vehicles that may be connected to the exhaust odor issue.NHTSA's Vehicle Test and Research Center tested multiple vehicles, including complaint vehicles, during the investigation.ODI also conducted field inspections of complaint vehicles and crashes involving police units that occurred while the officers were on duty.When possible, data was collected to quantify carbon monoxide levels in the examined vehicles.Based on the information gathered to date, NHTSA upgraded this investigation to an Engineering Analysis (EA17-002).
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System
During the National Highway Traffic Safety Administration?s (NHTSA?s) investigation into the Ford carbon monoxide allegations, the Office of Defects Investigation (ODI) identified additional Vehicle Owner Questionnaire (VOQ) reports with similar exhaust odor claims.Presently, ODI has identified 791 VOQs for Model Year 2011-2017 Ford Explorers pertaining to exhaust odor claims.ODI has identified three crashes and 41 injuries potentially linked this issue.The reported injuries range from unspecified to loss of consciousness, with the majority being nausea, headaches, or dizziness ? all of which can be symptomatic of carbon monoxide exposure.Additionally, Ford provided 2,400 reports including owner complaints, warranty claims, dealer field reports, and legal claims, that involve 2,051 vehicles that may be connected to the exhaust odor issue.NHTSA's Vehicle Test and Research Center tested multiple vehicles, including complaint vehicles, during the investigation.ODI also conducted field inspections of complaint vehicles and crashes involving police units that occurred while the officers were on duty.When possible, data was collected to quantify carbon monoxide levels in the examined vehicles.Based on the information gathered to date, NHTSA upgraded this investigation to an Engineering Analysis (EA17-002).
Structure:body
During the National Highway Traffic Safety Administration?s (NHTSA?s) investigation into the Ford carbon monoxide allegations, the Office of Defects Investigation (ODI) identified additional Vehicle Owner Questionnaire (VOQ) reports with similar exhaust odor claims.Presently, ODI has identified 791 VOQs for Model Year 2011-2017 Ford Explorers pertaining to exhaust odor claims.ODI has identified three crashes and 41 injuries potentially linked this issue.The reported injuries range from unspecified to loss of consciousness, with the majority being nausea, headaches, or dizziness ? all of which can be symptomatic of carbon monoxide exposure.Additionally, Ford provided 2,400 reports including owner complaints, warranty claims, dealer field reports, and legal claims, that involve 2,051 vehicles that may be connected to the exhaust odor issue.NHTSA's Vehicle Test and Research Center tested multiple vehicles, including complaint vehicles, during the investigation.ODI also conducted field inspections of complaint vehicles and crashes involving police units that occurred while the officers were on duty.When possible, data was collected to quantify carbon monoxide levels in the examined vehicles.Based on the information gathered to date, NHTSA upgraded this investigation to an Engineering Analysis (EA17-002).
PE12017 · Electric Power Steering Failure
Opened Jun 19, 2012 · Closed Jun 12, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014 and amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 179,027 model year (MY) 2011 through 2013 Ford Explorer vehicles equipped with electric power assisted steering (EPAS), including 82,328 MY 2011 Explorersthat are the subject of PE12-017.Ford has assigned the recall number 14S06.The NHTSA recall number is 14V-286.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Sudden loss of power steering assist while driving can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe mode, which removes power from the EPAS motor and defaults to manual steering.Ford's DIR indicates that the majority of steering assist failures in the recalled vehicles have been caused by an intermittent electrical connection in the Power Steering Control Module (PSCM) that can lead to a loss of the motor position sensor signal.Ford's remedy instructs dealers to check the PSCM for diagnostic trouble codes (DTC).If upon initial inspection a loss of steering assist DTC is present, dealers will replace the steering gear at no charge to the owner and update the PSCM with revised software.Following detection of a motor position sensor signal fault, the revised software will provide audible and visual warnings to the driver that a power steering system fault has been detected and will maintain steering assist for the remainder of that drive cycle.If no DTC is present, dealers will reprogram the PSCM with the revised software. Analysis of information from all sources identified a total of 969 complaints and 4,059 warranty claims related to loss of power steering assist while driving in the MY 2011 through 2012 Explorer vehicles, resulting in a complaint rate of 5.4 incidents per thousand vehicles and a warranty claim rate of 2.3 percent.ODI identified 15 crashes with evidence indicating loss of power steering assist may have been a factor.All 15 crashes involved low-speed impacts with roadside objects during turning maneuvers, resulting in minor vehicle damage or no damage.In one incident that occurred in a low-speed curve, the driver attempted to brake in response to the sudden increase in steering effort and inadvertently applied the accelerator pedal instead.This caused the vehicle to run off the side of the road and strike a wooden pole at approximately 15 mph.Another incident occurred when the driver was unable to to negotiate a left-turn at an intersection and ran off the road into a shallow ditch, resulting in moderate front-end damage to the vehicle and minor injuries to the driver that did not require medical treatment. This investigation is closed.All ODI complaints associated with this closing resume are listed in the Attachment 1.
Illustration