IllustrationTL* THE CONTACT OWNS A 2010 FORD EXPLORER. THE CONTACT STATED THAT THE HEADLIGHT SWITCH FRACTURED. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE HEADLIGHT SWITCH BEZEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
2010 Ford Explorer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2010 Ford Explorer do not stand out strongly from the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
1525–50K
1650–75K
1275–100K
14100–150K
3150K+
95 reports with mileage · 20 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports0 fire reports3 injury reports
Exterior Lighting complaints
2 reports8 DAYS AFTER NEW VEHICLE WAS PURCHASED, I WAS PULLED OVER BY THE SHERIFF FOR NO TAILLIGHTS. THE VEHICLE WAS LATER TAKEN INTO THE DEALER FOR REPAIR AND THEY SAID THE FUSE WAS BLOWN AND THEY REPLACED THE 15AMP FUSE TO THE SMART JUNCTION BOX. ABOUT 50 MILES LATER, A HIGHWAY PATROL DROVE BY AND ANNOUNCED ON THE SPEAKER SYSTEM TO TUR…
Read full complaint
8 DAYS AFTER NEW VEHICLE WAS PURCHASED, I WAS PULLED OVER BY THE SHERIFF FOR NO TAILLIGHTS. THE VEHICLE WAS LATER TAKEN INTO THE DEALER FOR REPAIR AND THEY SAID THE FUSE WAS BLOWN AND THEY REPLACED THE 15AMP FUSE TO THE SMART JUNCTION BOX. ABOUT 50 MILES LATER, A HIGHWAY PATROL DROVE BY AND ANNOUNCED ON THE SPEAKER SYSTEM TO TURN ON THE HEADLIGHTS. I CHECKED AND MY HEADLIGHTS WERE ON, SO I PULLED OVER AND NOTICED THE TAILLIGHTS WERE OUT AGAIN. THE NEXT DAY, THE CAR WAS SERVICED A SECOND TIME AND THEY SAID THEY REPLACED THE BURNED OUT FUSE AGAIN AND DID AN EXTENDED ROAD TEST AND PUT 130 MILES ON THE CAR AND SAID THE TAILLIGHTS ARE WORKING FINE. AFTER 5 DAYS OF BEING WITH THE DEALER SERVICE, WE PICKED UP THE VEHICLE, THE TAILLIGHTS WENT OUT AGAIN AFTER 100 MILES. WE WILL BE IN CONTACT WITH THE DEALER... *TR
Official recalls
110V161000 · Seats:front Assembly:recliner
Apr 20, 2010
FORD IS RECALLING CERTAIN MODEL YEAR 2010 FUSION, EXPLORER, EXPLORER SPORT TRAC, AND MERCURY MILAN AND MOUNTAINEER VEHICLES MANUFACTURED BETWEEN DECEMBER 15, 2009 THROUGH FEBRUARY 3, 2010 EQUIPPED WITH FRONT SEAT MANUAL RECLINERS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINT." THE RECLINER GEAR PLATE TEETH MAY BE OUT OF DIMENSION SPECIFICATION WHICH COULD RESULT IN LIMITED PAWL TO GEAR PLATE TOOTH ENGAGEMENT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEATBACK AND HEAD RESTRAINT MAY MOVE REARWARD, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL REPLACE THE MANUAL RECLINERS FOR BOTH POWER AND MANUAL SEATS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 30, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.