IllustrationWHEN DRIVING IN THE RAIN, IF I GO THROUGH A PUDDLE ON THE PASSENGER SIDE OF THE CAR, THE POWER STEERING FAILS FOR VARYING AMOUNTS OF TIME. IT HAS HAPPENED MORE THAN ONCE, THROUGH THE LIFE OF THE CAR. I ONLY JUST FOUND OUT I COULD MAKE A COMPLAINT.
2008 Ford Explorer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2008 Ford Explorer do not stand out strongly from the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
2025–50K
2850–75K
2875–100K
30100–150K
10150K+
129 reports with mileage · 19 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports2 injury reports
Steering complaints
13 reportsSTIFFNESS IN STEERING WHEN YOU TURN THE WHEEL . NO SOUNDS COMING FROM POWER STEERING/BELT OR ANYTHING FOR THAT MATTER .. JUST WHEN YOU SLOW TO TURN IT'S STIFF
LOSS OF STEERING. "POWER STEERING ASSIST FAULT" THIS IS A KNOWN ISSUE AND DOCUMENTED ISSUE AND FORD IS 'SELECTIVELY' CHOOSING TO CHERRY-PICK COVERAGE ON RECALL. THIS NEEDS TO BE COVERED ON ALL EFFECTED VEHICLES NOT CHERRY PICKED! I SHOULD NOT HAVE TO PAY 2-$3,000 + FOR A REPAIR THAT'S BEEN WELL DOCUMENTED
BRAKES FAILED ! I WAS MAKING A LEFT TURN ( ABOUT 80 ANGLE ) INTO A STORE PLAZA THAT HAS A SLIGHT HILL . WHILE MAKING THE TURN THERE WAS A SINGLE THUMP. STEERING WHEEL LOCKED INTO TURNING POSITION THEN RELEASED , DEPRESSED THE BREAKS AS I HIT THE BREAKS THE BREAK PEDDLE WENT TO THE FLOOR AND NOTHING HAPPENED MADE SEVERAL QUICK A…
Read full complaint
BRAKES FAILED ! I WAS MAKING A LEFT TURN ( ABOUT 80 ANGLE ) INTO A STORE PLAZA THAT HAS A SLIGHT HILL . WHILE MAKING THE TURN THERE WAS A SINGLE THUMP. STEERING WHEEL LOCKED INTO TURNING POSITION THEN RELEASED , DEPRESSED THE BREAKS AS I HIT THE BREAKS THE BREAK PEDDLE WENT TO THE FLOOR AND NOTHING HAPPENED MADE SEVERAL QUICK ATTEMPTS THEN BRAKES WENT TO NORMAL OPERATION.
CAR SHUTS OFF AND BRAKE SYSTEM LOCKS UP. REPAIR SHOP AND FORD SAID IT WAS A POWER STEERING CONTROL MODULE.FORD HAS ADMITTED THAT THIS PART IS A PROBLEM AND THAT THERE ARE NONE AVAILABLE ANYWHERE IN THE US. I HAVE BEEN WITHOUT MY CAR FOR OVER FOUR WEEKS. FORD CUSTOMER SERVICE ADMITTED TO THE PROBLEM, BUT SAID THERE WAS NOTHING TH…
Read full complaint
CAR SHUTS OFF AND BRAKE SYSTEM LOCKS UP. REPAIR SHOP AND FORD SAID IT WAS A POWER STEERING CONTROL MODULE.FORD HAS ADMITTED THAT THIS PART IS A PROBLEM AND THAT THERE ARE NONE AVAILABLE ANYWHERE IN THE US. I HAVE BEEN WITHOUT MY CAR FOR OVER FOUR WEEKS. FORD CUSTOMER SERVICE ADMITTED TO THE PROBLEM, BUT SAID THERE WAS NOTHING THEY COULD DO. IT WAS A SUPPLIER PROBLEM. *TR
TL* THE CONTACT OWNS A 2008 FORD EXPLORER. THE CONTACT STATED WHILE STARTING THE VEHICLE A WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO NOTICED A SMALL AMOUNT OF TRANSMISSION FLUID LEAKING. IN ADDITION, THE STEERING WHEEL SEIZED INTERMITTENTLY WHILE DRIVING OR UPON STARTING THE…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD EXPLORER. THE CONTACT STATED WHILE STARTING THE VEHICLE A WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO NOTICED A SMALL AMOUNT OF TRANSMISSION FLUID LEAKING. IN ADDITION, THE STEERING WHEEL SEIZED INTERMITTENTLY WHILE DRIVING OR UPON STARTING THE VEHICLE AND THEN RESUMED NORMALLY. THE DEALER INFORMED THE CONTACT THAT THE STEERING MALFUNCTION WAS CONTRIBUTED TO THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 07V453000 (POWER TRAIN). THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 39,500.PDATED 06/10/14 *BF UPDATED 06/17/2014 *JS
TL* THE CONTACT OWNS A 2008 FORD EXPLORER. THE CONTACT STATED THAT THE STEERING WHEEL FAILED AND HAD TO BE TURNED WITH FORCE. THERE WAS NO WARNING BEFORE THE FAILURE OCCURRED. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE MANUFACTURER WAS NOT MADE AWARE…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD EXPLORER. THE CONTACT STATED THAT THE STEERING WHEEL FAILED AND HAD TO BE TURNED WITH FORCE. THERE WAS NO WARNING BEFORE THE FAILURE OCCURRED. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 99,000 THE CONSUMER STATED A NEW POWER STEERING PUMP AND BELT WAS INSTALLED ON JUNE 20, 2013
NOISE COMING FROM STEERING, FELT IN STEERING WHEEL WHILE TURNING, IN THE FORM OF A SHUDDER ACCOMPANIED WITH A PULSATING GROANING TYPE NOISE. THIS OCCURRED MORE FREQUENTLY AS TIME HAS GONE BY, NOW IT HAPPENS MORE FREQUENTLY AND WITH AN ADDITIONAL SOUND OF FLUID BYPASSING IN THE STEERING RACK, LIKE WHAT WILL HAPPEN WITH ANY VEHICL…
Read full complaint
NOISE COMING FROM STEERING, FELT IN STEERING WHEEL WHILE TURNING, IN THE FORM OF A SHUDDER ACCOMPANIED WITH A PULSATING GROANING TYPE NOISE. THIS OCCURRED MORE FREQUENTLY AS TIME HAS GONE BY, NOW IT HAPPENS MORE FREQUENTLY AND WITH AN ADDITIONAL SOUND OF FLUID BYPASSING IN THE STEERING RACK, LIKE WHAT WILL HAPPEN WITH ANY VEHICLES STEERING SYSTEM WHEN THE WHEEL IS TURNED ALL THE WAY FULL RIGHT OR FULL LEFT. IT SOUNDS JUST LIKE THAT ONLY TURNING THE WHEEL NORMALLY, NOT TO ITS WHEEL STOPS. ALSO IT FEELS LIKE SOME POWER ASSIST IS LOST AND NOT THERE LIKE IT SHOULD BE, CAUSING INCREASED STEERING WHEEL EFFORT. I AM CONCERNED THAT TOTAL LOSS OF STEERING MAY HAPPEN AT SOME POINT IN TIME! HAD IT IN TO DEALER AND THEY IGNORED MY CONCERN THEY SAID THEY FOUND NOTHING WRONG, STEERING PUMP PRESSURE TESTS SHOULD HAVE BEEN PERFORMED BUT I DON'T BELIEVE THEY DID THIS. *TR
VEHICLE CHECK CHARGING SYSTEM LIGHT CAME ON, SHORTLY AFTER THE VEHICLE STALL WHILE IN MOTION DRIVING AT A SPEED OF APPROXIMATELY 25MPH AND EVENTUALLY LOSS POWER, STEERING CONTROL AND BRAKING CAPABILITIES. CURRENTLY AT THE MECHANIC, IT APPEARS IT MAY HAVE BEEN AN ALTERNATOR MALFUNCTION THAT CAUSED THE LOSS OF POWER. *TR
FRONT BRAKES HAS A RUBBING, SCREAMING SOUND, LOUDER WHEN TURNING OR APPLYING BRAKES, SOMETIMES THE STEERING WHEEL IS HARD TO TURN WHEN THIS IS HAPPENING, NOT FOR SURE IF THE NOISE IS COMING FROM THE FRONT, MIDDLE OR THE BACK IT IS SO LOUD, WE HAVE 4 YEARS OF THE SOUND ON TAPES. THOUGHT THE TAPPING WOULD HELP FORD MOTOR COMPANY A…
Read full complaint
FRONT BRAKES HAS A RUBBING, SCREAMING SOUND, LOUDER WHEN TURNING OR APPLYING BRAKES, SOMETIMES THE STEERING WHEEL IS HARD TO TURN WHEN THIS IS HAPPENING, NOT FOR SURE IF THE NOISE IS COMING FROM THE FRONT, MIDDLE OR THE BACK IT IS SO LOUD, WE HAVE 4 YEARS OF THE SOUND ON TAPES. THOUGHT THE TAPPING WOULD HELP FORD MOTOR COMPANY AT BLUEBONNET FIND THE PROBLEM, INSTEAD WE WERE LAUGHED AT AND TREATED RUDELY.THE GEAR SHIFT HAS BEEN REPLACED TWICE BY FORD AND STILL HAS STICKING PROBLEM, WE EVEN HAD THE FORD CORP INVOLVED, NO SOLUTION OF THE MATTER HAS BEEN RESOLVED AS OF TODAY, FORD CORP OFFICE OFFERED US A EMPLOYEE RATE, BUT WHEN SPEAKING WITH A SALESPERSON FROM BLUE BONNETT FORD, WE WOULD LOOSE THE $10,000.00 WE PUT DOWN, I HAVE A VEHICLE WE REFUSE TO DRIVE LONG DISTANCE, IN FACT WE RENT A VEHICLE TO GO OUT OF TOWN, BECAUSE FORD COULD NOT TELL ME IF IT IS SAFE OR UNSAFE, WE HAS OWNER FEEL IT IS DANGEROUS. *TR
Official recalls
107V453000 · Power Train:automatic Transmission:cooling Unit And Lines
Sep 26, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY LOOSEN AND THE TRANSMISSION OIL COOLER LINES MAY DISENGAGE FROM THE TRANSMISSION, CAUSING A TRANSMISSION FLUID LEAK.
Consequence & remedy
Consequence: IF LEAKING TRANSMISSION FLUID CONTACTS THE CATALYTIC CONVERTER, IT MAY POSE A RISK OF FIRE.
Remedy: DEALERS WILL INSPECT AND HAVE THE TRANSMISSION COOLER LINE ATTACHMENT BOLT TIGHTENED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 30, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO