NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
36 reportsClear category filter165,000 miles · Jul 10, 2026
Power Train
The contact owns a 2008 Ford Explorer. The contact stated that while attempting to park the vehicle, the gear shifter was shifted into park, and the vehicle rolled backwards about an inch. No warning lights were illuminated. The contact stated that the parking brake was enabled to stop the vehicle. The vehicle was taken to an in…
Read full complaint
The contact owns a 2008 Ford Explorer. The contact stated that while attempting to park the vehicle, the gear shifter was shifted into park, and the vehicle rolled backwards about an inch. No warning lights were illuminated. The contact stated that the parking brake was enabled to stop the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed with possible transmission failure. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 165,000.
NHTSA ODI #11749575
197,000 miles · Feb 1, 2021
Back Over PreventionElectrical SystemPower Train
AN ORANGE WRENCH LIGHT COMES ON ON MY DASHBOARD AND I CAN'T PICK UP SPEED. I'VE HAD IT LOOKED AT A FEW TIMES AND NO ONE CAN FIGURE OUT THE PROBLEM. THERE'S BEEN MANY PEOPLE ON YOUTUBE COMPLAINING OF THE SAMETHING. THIS IS VERY DANGEROUS AND SHOULD BE INVESTIGATED IMMEDIATELY, LUCKILY THE INTERSTATE WASN'T BUSY WHEN MY TRUCK LOST…
Read full complaint
AN ORANGE WRENCH LIGHT COMES ON ON MY DASHBOARD AND I CAN'T PICK UP SPEED. I'VE HAD IT LOOKED AT A FEW TIMES AND NO ONE CAN FIGURE OUT THE PROBLEM. THERE'S BEEN MANY PEOPLE ON YOUTUBE COMPLAINING OF THE SAMETHING. THIS IS VERY DANGEROUS AND SHOULD BE INVESTIGATED IMMEDIATELY, LUCKILY THE INTERSTATE WASN'T BUSY WHEN MY TRUCK LOST ITS ABILITY TO ACCELERATE. I COULD'VE CAUSE A CAR PILE UP AND THERE COULD'VE BEEN MANY LIVES LOST
NHTSA ODI #11391058
61,000 miles · Nov 13, 2019
Power TrainWheels
TRANSMISSION ON MY FORD EXPLORER V8 4.6 LIMITED NOT CHANGING INTO LAST GEAR. WHEN COMING TO A COMPLETE STOP TRANSMISSION JERKS SLIGHTLY. AT 61000 MILES NOW ..... I DIDN'T EXPECT TRANSMISSION PROBLEMS. FRONT WHEEL BEARINGS ARE HUMMING..... I HAD THIS WHEEL BEARING PROBLEM BEFORE ON MY OTHER 2008 FORD EXPLORER XLT 6 CYLINDER 4.0
NHTSA ODI #11279892
100,000 miles · Sep 9, 2019
Power Train
STOPPED AT THE 4 WAY ..AND MY TURN TO GO..MY CAR GOES MAYBE 2 SECONDS THEN IT REVVS WHEN I PRESSED THE PEDAL BIT MYCAR DOESNT ENGAGE . THE TOOL LIGHT AND ENGINE LIGHT ON. I RODE IT TO THE SIDE ..TURNED IT OFF. THEN STARTED IT AGAIN..GETTING BACK ON THE ROAD AGAIN..AND ONCE AGAIN I MOVE SOME..THEN THE ENGINE REVVVS BUT THE C…
Read full complaint
STOPPED AT THE 4 WAY ..AND MY TURN TO GO..MY CAR GOES MAYBE 2 SECONDS THEN IT REVVS WHEN I PRESSED THE PEDAL BIT MYCAR DOESNT ENGAGE . THE TOOL LIGHT AND ENGINE LIGHT ON. I RODE IT TO THE SIDE ..TURNED IT OFF. THEN STARTED IT AGAIN..GETTING BACK ON THE ROAD AGAIN..AND ONCE AGAIN I MOVE SOME..THEN THE ENGINE REVVVS BUT THE CAR DOESN T FO..TWICE I ALMOSTGOT SIDE SWIPED BY ON COMING VARS UP BEHIND ME. I TALKED TO THE MECHANIC..AS I JUST BOUGHT THIS CAR IN JULY LAST YEAR..HESAID ITS A FORD THING..COMMOM.. BUT NO ONE HAS THE CORRECT ANSWER..TRIAL AND ERROR..OR SPEND THOUSANDS ON A NEW TRANSMISSION. A FEW PEOPLE SAID ITS THE TRANSMOSSION WIRE HARNESS??
NHTSA ODI #11254321
100,232 miles · Aug 12, 2018
Electrical SystemPower Train
"TRANSMISSION FAILURE" AT 100233 MILES THE WRENCH AND ENGINE LIGHT CAME WHILE DRIVING. UPON PARKING & TURNING OFF THE VEHICLE, THE TRANSMISSION WOULD NOT WORK. CUT THRU ALL GEARS LIKE BUTTER. WOUND NOT "ENTER" INTO ANY GEAR. TOWED. AFTER VEHICLE COOLED, TRANSMISSION WORKS AGAIN, ONLY TO BECOME HOT, REPEAT TOW. CODE P0775. AFTE…
Read full complaint
"TRANSMISSION FAILURE" AT 100233 MILES THE WRENCH AND ENGINE LIGHT CAME WHILE DRIVING. UPON PARKING & TURNING OFF THE VEHICLE, THE TRANSMISSION WOULD NOT WORK. CUT THRU ALL GEARS LIKE BUTTER. WOUND NOT "ENTER" INTO ANY GEAR. TOWED. AFTER VEHICLE COOLED, TRANSMISSION WORKS AGAIN, ONLY TO BECOME HOT, REPEAT TOW. CODE P0775. AFTER COOLING, SAME EVENT. TRANSMISSION SOLENOID GOES OUT WHILE HOT, IN A HOT CLIMATE. MANUFACTURER DEFECT. NEEDS SAFETY RECALL.
NHTSA ODI #11119406
136,700 miles · Jul 12, 2018
Power TrainSeats
TRANSMISSION FAILURE, FRONT DRIVER SEAT WILL NOT ADJUST BEFORE GOING OUT WOULD MOVE ON ITS OWN AND CAUSE INTERIOR LIGHTS TO COME ON. PREVIOUS OWNER TOOK VEHICLE IN AFTER PURCHASE FOR HARD SHIFTING OF TRANSMISSION AND NO REPAIRS WERE DONE. TRANSMISSION PROBLEM WAS NOT DISCLOSED TO ME AT TIME OF PURCHASE.
NHTSA ODI #11110952
100,000 miles · Jun 28, 2018
Power Train
TRANSMISSION GOING OUT AT 100,000MILES AND COOLIANT PROBLEMS.
NHTSA ODI #11104463
147,000 miles · Sep 12, 2017
Power Train
TL* THE CONTACT OWNS A 2008 FORD EXPLORER. WHILE DEPRESSING THE ACCELERATOR PEDAL TO ACCELERATE FROM A STOP, THE VEHICLE FAILED TO ACCELERATE. THE WRENCH WARNING ICON ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, TURNED OFF AND RESTARTED THE VEHICLE, AND WAS ABLE TO DRIVE NORMALLY. AFTER DRIVING A BLOCK, …
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD EXPLORER. WHILE DEPRESSING THE ACCELERATOR PEDAL TO ACCELERATE FROM A STOP, THE VEHICLE FAILED TO ACCELERATE. THE WRENCH WARNING ICON ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, TURNED OFF AND RESTARTED THE VEHICLE, AND WAS ABLE TO DRIVE NORMALLY. AFTER DRIVING A BLOCK, THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V453000 (POWER TRAIN). NO FURTHER ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 147,000.
NHTSA ODI #11022854
117,809 miles · Jul 19, 2017
Electrical SystemEnginePower Train
I'VE HAD MY 2008 EDDIE BAUER FORD EXPLORER JUST OVER A YEAR. AS I'M DRIVING ON A LOCAL ROAD, IT STARTS ACTING LIKE IT'S ABOUT TO CUT OFF. I GET TO A RED LIGHT AND AS I'M ABOUT TO TAKE OFF, IT SHUTS OFF. I PLACED IT IN PARK AND RESTARTED IT THEN IT SPUTTERS AND THEN CATCHES. A FEW MINUTES LATER THIS ERROR MESSAGE COMES UP ON THE …
Read full complaint
I'VE HAD MY 2008 EDDIE BAUER FORD EXPLORER JUST OVER A YEAR. AS I'M DRIVING ON A LOCAL ROAD, IT STARTS ACTING LIKE IT'S ABOUT TO CUT OFF. I GET TO A RED LIGHT AND AS I'M ABOUT TO TAKE OFF, IT SHUTS OFF. I PLACED IT IN PARK AND RESTARTED IT THEN IT SPUTTERS AND THEN CATCHES. A FEW MINUTES LATER THIS ERROR MESSAGE COMES UP ON THE DASH WITH A WRENCH. I TOOK IT TO THE NEAREST AUTO STORE, THEY PLACED IT ON THE MACHINE AND SAID IT LOOKS LIKE MY ENGINE WIRING HARNESS OR ECM/PCM. I HAD THE HARNESS REPLACED (ALMOST $900) AND A WEEK LATER THE WRENCH ERROR MESSAGE RETURNED AND THE PROBLEM HAS RETURNED AS WELL.
NHTSA ODI #11006312
103,500 miles · Jun 28, 2017
Power TrainUnknown Or Other
WHEN THE PROBLEM OCCURRED IT CAME FROM NOWHERE. I WAS DRIVING AS NORMAL THEN THERE WAS AN INITIAL LOSS OF POWER AS I NOTICED THE CHECK ENGINE LIGHT AND AN UNFAMILIAR ORANGE WRENCH WERE NOW ILLUMINATED. SEEMING AS I HAD NO POWER I CAUTIOUSLY GUIDED THE VEHICLE TO THE SHOULDER OF THE EXPRESSWAY. SINCE THEN I'VE TRIED HAVING THE PR…
Read full complaint
WHEN THE PROBLEM OCCURRED IT CAME FROM NOWHERE. I WAS DRIVING AS NORMAL THEN THERE WAS AN INITIAL LOSS OF POWER AS I NOTICED THE CHECK ENGINE LIGHT AND AN UNFAMILIAR ORANGE WRENCH WERE NOW ILLUMINATED. SEEMING AS I HAD NO POWER I CAUTIOUSLY GUIDED THE VEHICLE TO THE SHOULDER OF THE EXPRESSWAY. SINCE THEN I'VE TRIED HAVING THE PROBLEM FIXED TO NO AVAIL, BECAUSE IT'S INTERMITTENT AND FORD THEMSELVES HAVE NO REMEDY. ALSO, TOOK IT UPON MYSELF TO CONTACT FORD TO BE TOLD THE VEHICLE IS PAST WARRANTY SO GO THE DEALER AND HAVE THEM LOOK AT THE VEHICLE. THIS HAS BEEN AN ISSUE FOR THE PAST 2 MONTHS OF OWNING THIS VEHICLE AND STILL OCCURRING OCCASIONALLY.
NHTSA ODI #11001887
NHTSA investigations
1PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration