IllustrationDRIVER SEAT BELT BROKEN; DOES NOT STAY LATCHED. *TR
1996 Ford Explorer
Owner reports · Recalls · Investigations
More warning signs than most Explorer years
Owner complaints for the 1996 Ford Explorer are substantially higher than the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 153 of 1,450 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 570 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 148 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 120 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
195 crash reports37 fire reports179 injury reports
What owners actually said
1,450 reportsTL*THE CONTACT OWNS A 1996 FORD EXPLORER. THE CONTACT STATED THAT DASHBOARD LIGHTS WERE TOO DIM. THE GAS CAP WAS NOT SECURE ON THE TANK AND DID SHE WAS UNABLE TO REPLACE THE GAS CAP ON TIGHT. THE DEALER ADVISED HER THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED BECAUSE IT ADDED TO THE POLLUTION. SHE RECEIVED RECALL NOTICE 09…
Read full complaint
TL*THE CONTACT OWNS A 1996 FORD EXPLORER. THE CONTACT STATED THAT DASHBOARD LIGHTS WERE TOO DIM. THE GAS CAP WAS NOT SECURE ON THE TANK AND DID SHE WAS UNABLE TO REPLACE THE GAS CAP ON TIGHT. THE DEALER ADVISED HER THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED BECAUSE IT ADDED TO THE POLLUTION. SHE RECEIVED RECALL NOTICE 09V399000,VEHICLE SPEED CONTROL AND THE DEALER REPLACED THE CATALYTIC CONVERTER INSTEAD OF THE SPEED CONTROL DEACTIVATION SWITCH. SHE CALLED THE DEALER AND THE MANUFACTURER BUT RECEIVED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 157,000.
OUR 96 FORD EXPLORER TRANSMISSION HAS SLIPPED OUT OF GEAR AT UNPREDICTABLE TIMES, SPEEDS, AND INCLINES. ONLY HAVE HAD A BACK BUMPER "BUMPED" WHEN THIS HAPPENED, BUT WOULD REALLY LIKE FOR SOME DEPT OR ENTITY TO REFER US TO A TRULY KNOWLEDGEABLE AND EXPERIENCED TRANSMISSION SHOP OR OTHER HELPFUL SOURCE. *TR
1996 FORD EXPLORER ACCIDENT DUE TO TREAD SEPARATION. CW ACCORDING TO AN EYE WITNESS STATEMENT, THE DRIVER OF THE VEHICLE CROSSED SEVERAL LANES, STRUCK A GUARDRAIL AND WENT AIRBORNE AND LANDED ON IT'S ROOF. THE WITNESS STATED TWO PEOPLE WERE EJECTED FROM THE VEHICLE. THE DRIVER OF THE VEHICLE EVENTUALLY DIED. (LAWYER WROTE IN ON…
Read full complaint
1996 FORD EXPLORER ACCIDENT DUE TO TREAD SEPARATION. CW ACCORDING TO AN EYE WITNESS STATEMENT, THE DRIVER OF THE VEHICLE CROSSED SEVERAL LANES, STRUCK A GUARDRAIL AND WENT AIRBORNE AND LANDED ON IT'S ROOF. THE WITNESS STATED TWO PEOPLE WERE EJECTED FROM THE VEHICLE. THE DRIVER OF THE VEHICLE EVENTUALLY DIED. (LAWYER WROTE IN ON BEHALF OF CLIENTS) *JB
I DID NOT RECEIVE A REMEDY OR NOTIFICATION LETTER FROM FORD ABOUT MY SAFETY DEFECTS ON MY 1996 FORD EXPLORER. WHAT DO I DO NOW, IS THERE STILL TIME TO FIX THESE DEFECTS? *TR
1996 FORD EXPLORER CAUGHT FIRE WHILE DRIVING. TOTAL LOSS OF VEHICLE WITHIN MINUTES.
THE MULTI-FUNCTION SWITCH OPERATING THE WINDSHIELD WIPERS AND TURN SIGNALS FAILS, RESULTING IN TURN SIGNAL STAYING IN THE ON POSITION AND RESULTS IN WIRE SHORTAGE INSIDE THE STEERING COLUMN, CAUSING ELECTRICAL SMOKE TO COME OUT OF THE STEERING COLUMN. HAD I NOT MANUALLY PUSHED THE SWITCH OFF, THERE WOULD HAVE BEEN FIRE WITHIN S…
Read full complaint
THE MULTI-FUNCTION SWITCH OPERATING THE WINDSHIELD WIPERS AND TURN SIGNALS FAILS, RESULTING IN TURN SIGNAL STAYING IN THE ON POSITION AND RESULTS IN WIRE SHORTAGE INSIDE THE STEERING COLUMN, CAUSING ELECTRICAL SMOKE TO COME OUT OF THE STEERING COLUMN. HAD I NOT MANUALLY PUSHED THE SWITCH OFF, THERE WOULD HAVE BEEN FIRE WITHIN SECONDS. THIS HAS NOW HAPPENED TWICE IN THE SAME VEHICLE. THE SWITCH WAS REPLACED THE FIRST TIME, IN 2006. THAT SWITCH ALSO FAILED, BUT I WAS TOLD THE PART WAS ONLY UNDER WARRANTY FOR 12/12, SO I CANNOT HAVE IT REPLACED FOR FREE. SINCE IT IS FAULTY, (NOT CAUSED BY THE DRIVER) AND IS A MAJOR SAFETY HAZARD THAT COULD LEAD TO INJURY OR DEATH, I BELIEVE IT IS IMPORTANT TO RAISE AWARENESS AND GET THIS HANDLED IMMEDIATELY. *TR
96' FORD EXPLORER EDDIE BAUER EDITION CLIMATE CONTROL STOPPED WORKING. IT ONLY BLOWS COOL AIR. SHOP WANTS $900 TO REPLACE THE BLEND DOOR. I CAN'T DRIVE DURING WINTER IF THE WINDOWS FROST OR FREEZING RAIN. IMPAIRED VISIBILITY. *TR
TL* THE CONTACT OWNS A 1996 FORD EXPLORER. THE CONTROLS FOR THE CRUISE CONTROL BECAME DISLODGED AND HE COULD NOT PUT THEM BACK. THE DEALER WAS NOTIFIED, BUT HE DID NOT RECEIVE ANY ASSISTANCE. HE RECEIVED RECALL NOTICE # 09V399000 (VEHICLE SPEED CONTROL). A TECHNICIAN STATED THAT THEY WOULD REPAIR THE PART DESCRIBED UNDER THE RE…
Read full complaint
TL* THE CONTACT OWNS A 1996 FORD EXPLORER. THE CONTROLS FOR THE CRUISE CONTROL BECAME DISLODGED AND HE COULD NOT PUT THEM BACK. THE DEALER WAS NOTIFIED, BUT HE DID NOT RECEIVE ANY ASSISTANCE. HE RECEIVED RECALL NOTICE # 09V399000 (VEHICLE SPEED CONTROL). A TECHNICIAN STATED THAT THEY WOULD REPAIR THE PART DESCRIBED UNDER THE RECALL THAT WOULD CAUSE THE FIRE BUT NOT REPAIR THE CONTROLS. THE CONTROLS SHOULD ALSO BE REPAIRED BECAUSE WITHOUT THERE FUNCTIONING, THE CRUISE CONTROL COULD NOT BE ACTIVATED. THE CURRENT MILEAGE WAS APPROXIMATELY 157,000. THE FAILURE MILEAGE WAS APPROXIMATELY 155,000.
ON 8 AUG 09, MY RIGHT REAR TIRE BLEW OUT WHILE GOING NORTH ON I95 AT EXIT 132 NEAR ROCKY MOUNT, NC. MY SUV FLIPPED OVER A FEW TIMES AND MY DAUGHTER AND I ENDED UP UPSIDE DOWN LOOKING AT THE TRAFFIC. I NOTICED THAT MY AIR BAG DID NOT DEPLOY. *TR
Official recalls
609V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
00V402000 · Suspension
Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.
Consequence & remedy
Consequence: VEHICLE HANDLING COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS.
97V137000 · Structure:body:hatchback/liftgate:support Device/strut
Aug 19, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.
Consequence & remedy
Consequence: THE GAS CYLINDER BRACKET MAY NOT PROPERLY SUPPORT THE LIFTGATE INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.
97V074000 · Vehicle Speed Control
Apr 30, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Consequence & remedy
Consequence: ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.
Remedy: DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.
96V161000 · Equipment:other:labels
Aug 29, 1996
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
96V070000 · Latches/locks/linkages:doors:latch
Apr 22, 1996
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.