IllustrationTHE DESIGN OF THE WIPERS ALLOWS ICE TO BUILD UP ON WIPERS AND WINDSHIELD RESULTING IN POOR VISIBILITY.
1996 Ford Explorer
Owner reports · Recalls · Investigations
More warning signs than most Explorer years
Owner complaints for the 1996 Ford Explorer are substantially higher than the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 153 of 1,450 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 570 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 148 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 120 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
195 crash reports37 fire reports179 injury reports
What owners actually said
1,450 reportsBECAUSE OF SUCH A HIGH IDLE COULD CAUSE A MAJOR WRECK
MY CAR HAD A SUDDEN ACCELERATION PROBLEM SIMILAR TO WHAT WAS RECENTLY DESCRIBED ON DATELINE (ONE WEEK LATER). LUCKILY, WE WERE ABLE TO GET THE CAR TO STOP BY PUTTING IT IN PARK AND TURNING OFF THE IGNITION. I WON'T DRIVE THE CAR ANYMORE. WE WERE ALMOST KILLED AND ALMOST KILLED SOME PEDESTRIANS. FORD IS NOT ACKNOWLEDGIN THE PR…
Read full complaint
MY CAR HAD A SUDDEN ACCELERATION PROBLEM SIMILAR TO WHAT WAS RECENTLY DESCRIBED ON DATELINE (ONE WEEK LATER). LUCKILY, WE WERE ABLE TO GET THE CAR TO STOP BY PUTTING IT IN PARK AND TURNING OFF THE IGNITION. I WON'T DRIVE THE CAR ANYMORE. WE WERE ALMOST KILLED AND ALMOST KILLED SOME PEDESTRIANS. FORD IS NOT ACKNOWLEDGIN THE PROBLEM, BUT RATHER DENYING IT. WOULD APPRECIATE SOME FOLLOW UP. REGARDLESS, I AM GETTING RID OF THE CAR BEFORE IT KILLS US. THIS IS A SERIOUS PROBLEM AND SHOULDNT BE TAKEN LIGHTLY. WE HOPE THAT YOU WILL HELP US AND OTHERS. IT IS NOT RIGHT FOR FORD TO IGNORE THE PROBLEM BECAUSE OF THE EXPENSE OF A RECALL. THEY DID IT WITH THE PINTOS AND NOW WITH THE EXPLORERS. DON'T ALLOW THIS, ITS NOT FAIR TO THE CONSUMER. I HAD MY THREE YEAR OLD BOY WITH ME AND I COULD HAVE LOST HIM. *AK
VEHICLE ACCELERATES ON ITS OWN. SLOWS DOWN WHEN USING BRAKES, BUT ACCELERATION WILL NOT STOP. DEALER CONTACTED AND CANNOT REMEDY THE PROBLEM. PROBLEM STILL EXISTS. PROVIDE FURTHER INFORMATION. *AK
LOWER BALL JOINT FAILED TO OPERATE AT 44,000 MAIL OF WEAR; DEALER/MFR NOTIFIED AND REFUSED TO REPLACE/REPAIR UNLESS COST GOES TO CONSUMER. *AK
TRANSMISSION MALFUNCTIONS. ALSO, WHEN DRIVING AT 35 TO 45 MPH WITHOUT PRIOR WARNING, THE VEHICLE WILL CUT OFF.DEALER HAS THE VEHICLE IN SHOP TO REPAIR THE PROBLEM. *AK
ON SEVERAL OCCASIONS VEHICAL ACCELERATED TO HIGH SPEEDS AND WAS EXTREMELY DIFFICULT TO STOP. VEHICLE WAS BROUGHT INTO THE DEALERSHIP AND THEY COULD NOT FIND ANY PROBLEM.
WE HAVE HAD NUMEROUS PROBLEMS WITH OUR ABS (ANNOYING PEDAL FEEDBACK DURING NORMAL BRAKING AS WELL AS DURING BACK-UP), THE FRONT BRAKES WERE COMPLETELY SHOT AT 17,000 MILES (WE DO NOT HAVE A TOW PACKAGE) THE ROTOR'S HAD TO BE MILLED, AND UPON FURTHER INVESTIGATION BY THE DEALERSHIP ( AFTER NUMEROUS COMPLAINTS BY ME) FOUND OUT THE…
Read full complaint
WE HAVE HAD NUMEROUS PROBLEMS WITH OUR ABS (ANNOYING PEDAL FEEDBACK DURING NORMAL BRAKING AS WELL AS DURING BACK-UP), THE FRONT BRAKES WERE COMPLETELY SHOT AT 17,000 MILES (WE DO NOT HAVE A TOW PACKAGE) THE ROTOR'S HAD TO BE MILLED, AND UPON FURTHER INVESTIGATION BY THE DEALERSHIP ( AFTER NUMEROUS COMPLAINTS BY ME) FOUND OUT THE REAR BRAKES WERE NOT FUNCTIONING AT ALL. I HAVE 2 SMALL CHILDREN AND I AM BECOMING MORE CONCERNED ABOUT THEIR SAFETY AS THIS SITUATION PERSISTS. I BOUGHT A FORD BECAUSE THEY HAD A BETTER SAFETY RATING AT THE TIME THEN OTHER SIMILAR MAKES
WHILE DRIVING AT 40-50MPH,ON DRY PAVEMENT, VEHICLE HIT LARGE TREE, FRONTAL IMPACT, NEITHER AIR BAG DEPLOYED. DEALER CONTACTED AND CANNOT REMEDY THE PROBLEM. NO WARRANTY. PROVIDE FURTHER INFORMATION. *AK
THIS IS A NON-RECALL FOR ABS. WHILE DRIVING 45-50 MPH ON WET PAVEMENT/SOME ICE, VEHICLE FISHTAILED ON BLACK ICE, DRIVER CORRECTED THE SLIDE. HOWEVER, ABS LOCKED UP, SENDING VEHICLE IN SPIN, RESULTING IN ROLLOVER. ONCOMING 2ND VEHICLE (SAME MODEL) TRYING TO GO AROUND, CAUSED HEAD-ON COLLISION. 2ND VEHICLE WENT UNDER THE 1ST VE…
Read full complaint
THIS IS A NON-RECALL FOR ABS. WHILE DRIVING 45-50 MPH ON WET PAVEMENT/SOME ICE, VEHICLE FISHTAILED ON BLACK ICE, DRIVER CORRECTED THE SLIDE. HOWEVER, ABS LOCKED UP, SENDING VEHICLE IN SPIN, RESULTING IN ROLLOVER. ONCOMING 2ND VEHICLE (SAME MODEL) TRYING TO GO AROUND, CAUSED HEAD-ON COLLISION. 2ND VEHICLE WENT UNDER THE 1ST VEHICLE, AND IT WAS TOTALLED. VEHICLE TOWED. PROVIDE FURTHER INFORMATION. *AK
Official recalls
609V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
00V402000 · Suspension
Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.
Consequence & remedy
Consequence: VEHICLE HANDLING COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS.
97V137000 · Structure:body:hatchback/liftgate:support Device/strut
Aug 19, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.
Consequence & remedy
Consequence: THE GAS CYLINDER BRACKET MAY NOT PROPERLY SUPPORT THE LIFTGATE INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.
97V074000 · Vehicle Speed Control
Apr 30, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Consequence & remedy
Consequence: ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.
Remedy: DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.
96V161000 · Equipment:other:labels
Aug 29, 1996
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
96V070000 · Latches/locks/linkages:doors:latch
Apr 22, 1996
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.