NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
97 reportsClear category filterMileage unknown · Sep 11, 2000
Service Brakes, Hydraulic
CONSUMER FEELS THE ANTI-LOCK BRAKING SYSTEM IS INFERIOR TO STANDARD BRAKES ESPECIALLY WHILE ON SNOW, ICE, WET OR SLICK PAVEMENT, OR IF A VEHICLE RUNS OFF THE ROAD ONTO GRASS OR DIRT SURFACES, THE CONSUMER HAS DONE MANY SELF TESTS WHICH RESULTED IN THE USE OF ANTI-LOCK BRAKES IN 4-WHEEL DRIVE HAVING A BETTER STOPPING DISTANCE IN …
Read full complaint
CONSUMER FEELS THE ANTI-LOCK BRAKING SYSTEM IS INFERIOR TO STANDARD BRAKES ESPECIALLY WHILE ON SNOW, ICE, WET OR SLICK PAVEMENT, OR IF A VEHICLE RUNS OFF THE ROAD ONTO GRASS OR DIRT SURFACES, THE CONSUMER HAS DONE MANY SELF TESTS WHICH RESULTED IN THE USE OF ANTI-LOCK BRAKES IN 4-WHEEL DRIVE HAVING A BETTER STOPPING DISTANCE IN SNOW CONDITIONS COMPARED TO THE USE OF ANTI-LOCK BRAKES NOT IN 4-WHEEL DRIVE, CONSUMER ALSO HAD DRUMS TURNED AT 71837 MILES AND A COMPLETE FRONT AND REAR BRAKE JOB. *SLC
NHTSA ODI #558457
Mileage unknown · Jul 20, 2000
Service Brakes, Hydraulic
RECALL 96V024000; WHEN DRIVING AND UPON DEPRESSING BRAKE PEDAL TO MAKE A GRAUDAL STOP, BRAKE PEDAL TRAVELED TO THE FLOORBOARD, CAUSING EXTENDED STOPPING DISTANCE. EMERGENCY PARKING BRAKE WAS ENGAGED TO STOP VEHICLE. CONSUMER HAS CONTACTED THE DEALER. DEALER STATED THAT AIR BRAKE BOOSTER ASSEMBLY WAS BAD AND SHOULD BE REPLAC…
Read full complaint
RECALL 96V024000; WHEN DRIVING AND UPON DEPRESSING BRAKE PEDAL TO MAKE A GRAUDAL STOP, BRAKE PEDAL TRAVELED TO THE FLOORBOARD, CAUSING EXTENDED STOPPING DISTANCE. EMERGENCY PARKING BRAKE WAS ENGAGED TO STOP VEHICLE. CONSUMER HAS CONTACTED THE DEALER. DEALER STATED THAT AIR BRAKE BOOSTER ASSEMBLY WAS BAD AND SHOULD BE REPLACED. *AK THE VEHICLE HAD POWER BRAKE ASSEMBLY REPLACED IN MARCH 1966 DUE TO RECALL ON THIS PART. SO, THE CURRENT FAILURE IS DUE TO THE IMPROPER FIXING BY THE DEALER AT RECALL FIXING. *YH
NHTSA ODI #865769
Mileage unknown · Jun 6, 2000
Engine And Engine CoolingService Brakes, Hydraulic
AFTER PURCHASING THIS UV FROM A DEALER.PAYING TOP DOLLAR FOR THIS EDDIE BAUER UV,I HAVE HAD NOTHING BUT PROBLEMS WITH THE VEHICLE. COULD NOT GO MORE THAN 60 MILES AN HIUR,UV WAS SHAING SO BAD. OIL LEAKING ,BRAKES BAD. IT WAS BANDAIDED T SELL I AM SURE. A 8 YEAR OLD CAR WITH ONLY 52,000MILES AND IN THIS HORRIBLE REPAIR CONDITION,…
Read full complaint
AFTER PURCHASING THIS UV FROM A DEALER.PAYING TOP DOLLAR FOR THIS EDDIE BAUER UV,I HAVE HAD NOTHING BUT PROBLEMS WITH THE VEHICLE. COULD NOT GO MORE THAN 60 MILES AN HIUR,UV WAS SHAING SO BAD. OIL LEAKING ,BRAKES BAD. IT WAS BANDAIDED T SELL I AM SURE. A 8 YEAR OLD CAR WITH ONLY 52,000MILES AND IN THIS HORRIBLE REPAIR CONDITION,IS ALMOST SUSPECT TO INQUIRE Y OF A ODOMETER TURN BACK, LUCKILY I BOUGHT INS, TOOK TO A FORD DEALERAND HAD REPAIRS TOTOALLING ALMOST $2500.OF WHICH I HAD TO PAY $800. OUT OF MY OWN POCKET. THE BRAKES NEEDED TO BE WORKED ON, THER WERE 3 RECA;LLS WHICH WERE TAKEN CARE OF. THE ENGINE WAS NEEDING SEALS AND MUCH MORE . THE DRIVER SEAT BELT IS BROKE,NOW AND THE ENGINE IS NOW LEAKING AGAIN AND I HAVE TO PUT A QT. OF OIL EVERY WEK. THE CAR IS BASICALLY UNSFAE TO DRIVE,BETWEEEN THE BRAKES AND THE ENGINE LEAKING OIL,WHICH I WAS TOLD IF IT GOT INTO THE GEAR BOX,IT WOULD START A FIRE. THIS WAS THE WORDS OF THE FORD DEALER.WHRE I HAD THE UV SERVICED. RECENTLY I NOTICED AN ARTICLE IN THE NEWSPAPER COMMENTING ONTHE FROD GASKET FLAW.I HAVE BEEN TRYING FRO DAYS TO CALL THEIR TOLL FREE NUMBER FOR INFROMATION LINE ALWAYS BUSY. THEY DO RECALL SOME OF THIS MODEL.IDONT KNOW WHERE TO TURN TO ANY MORE I HAVE 3 CHILDREN AND AM CONCERNED ABOUT THEIR SAFTEY,A SINGLE MOTHER WITH NO INCOME OTHER THAN 900.. AMONTH FROM WORKMASN COMP. CANT AFFORD ANYMORE REPAIRS NEEED HELP TO WHERE I NEED TO GO, I FEEL THE UV IS NOT SAFE AND I FEEL THAT THE ODOMETER MAY HAVE BEEN SET BACK, THE DEALERS WHERE I PURCHASED ARE TIRED OF HERING MY COMPLAINTS. THEY WORKED ONTHE UV ONCE, BUT NEVER GAVE ME A LIST OF WHAT WORK THEY DID AFTER HAVING THE CAR IN THEIR SHOP FOR 10 DAYS. I WOULD LIKE MY MONEY BACK,BUT I WILL HAVE TO PROVE THE CAR IS NOT SAFE . TELL ME WHAT I CAN DO. I CAN FGAX YOU ALL THE COPIES OF REPAIR WORK THAT WAS SERVICED ON THIS CAR IN FEB. IF YOU NEED THEM IT MAY HELP U MAKE A DESICION AS TO WHERE I TURN TO NEXT. PLEASE RESPOND WHAT DO I DO??*AK
NHTSA ODI #723657
Mileage unknown · May 3, 2000
Service Brakes, HydraulicSteeringWheels
WHEN DRIVING AT 30 MPH LEFT REAR WHEELS SHEARED OFF, CAUSING LOSS OF BRAKES AND STEERING CONTROL. ALSO, WHEN DRIVING BETWEEN 15-20 MPH AND UPON DEPRESSING THE BRAKE PEDAL TO MAKE A GRAUDAL STOP, RIGHT REAR WHEELS SHEARED OFF, CAUSING LOSS OF STEERING CONTROL AND LOSS OF BRAKES. CONSUMER HAS CONTACTED THE DEALER. DEALER HAS RE…
Read full complaint
WHEN DRIVING AT 30 MPH LEFT REAR WHEELS SHEARED OFF, CAUSING LOSS OF BRAKES AND STEERING CONTROL. ALSO, WHEN DRIVING BETWEEN 15-20 MPH AND UPON DEPRESSING THE BRAKE PEDAL TO MAKE A GRAUDAL STOP, RIGHT REAR WHEELS SHEARED OFF, CAUSING LOSS OF STEERING CONTROL AND LOSS OF BRAKES. CONSUMER HAS CONTACTED THE DEALER. DEALER HAS REPLACED PARTS. *AK
NHTSA ODI #861318
Mileage unknown · Apr 21, 2000
Power TrainService Brakes, Hydraulic
WOULD SHIFT VEHICLE INTO REVERSE & APPLIED GAS, AND IT WOULD TAKE TOO LONG TO KICK INTO REVERSE. ALSO, BRAKES WOULD MAKE A CLUNKING NOISE WHEN THIS HAPPENED. *AK
NHTSA ODI #860730
Mileage unknown · Mar 19, 2000
Parking BrakeService Brakes, Hydraulic
WHILE DRIVING AT APPROXIMATELY 35MPR , BOTH THE EMERGENCY BRAKE AND ANTILOCK LIGHTS CAME ON. I PULLED OVER TO CHECK THE SITUATION. COULDN'T DETERMINE A PROBLEM SO DROVE TWO BLOCKS TO A SERVICE STATION WHERE I DETERMINED THAT I WAS LOOSING BREAK FLUID. AFTER POURING IN BRAKE FLUID AND IT CAME RIGHT OUT ON THE GROUND I LEFT THE CA…
Read full complaint
WHILE DRIVING AT APPROXIMATELY 35MPR , BOTH THE EMERGENCY BRAKE AND ANTILOCK LIGHTS CAME ON. I PULLED OVER TO CHECK THE SITUATION. COULDN'T DETERMINE A PROBLEM SO DROVE TWO BLOCKS TO A SERVICE STATION WHERE I DETERMINED THAT I WAS LOOSING BREAK FLUID. AFTER POURING IN BRAKE FLUID AND IT CAME RIGHT OUT ON THE GROUND I LEFT THE CAR TO BE WORKED ON THE NEXT DAY. THE MECHANIC FOUND THAT THE BRAKE LINE WAS SEVERED DUE TO THE MAIN SPRING SUPPORT BROKE AND CUT THE BRAKE LINE. THE CAR WAS TOWED TO ANOTHER MECHANIC WHO DID THE REPAIR. THE SECOND MECHANIC SUGGESTED THAT I REPORT THIS VERY UNUSAL FAILURE. HE DETERMINED THAT THE SPRING SUPPORT RUSTED AWAY AND THE SPRING MOVED AND CUT BRAKE LINE. HE HAD TO INSTALL SPRING SUPPORT MEMBER CUT OFF RIVETS AND REPAIR CHASSIS AND NEW BRAKE HOSE AND STEEL LINES.
NHTSA ODI #720323
Mileage unknown · Nov 5, 1999
Service Brakes, Hydraulic
WHILE DRIVING ON THE FREEWAY AND APPLYING THE BRAKES THE VEHICLE S BACK WHEELS LOCKED UP. OWNER HAD TO HAVE CAR TOWED IN ORDER TO GET IT OFF THE FREEWAY. DEALER HAS VEHICLE NOW. *AK
NHTSA ODI #852604
Mileage unknown · Oct 27, 1999
Service Brakes, Hydraulic
BRAKE MASTER CYLINDER BOOSTER SEPARATED FROM THE VEHICLE, CAUSING THE BRAKES TO FAIL. *AK
NHTSA ODI #851922
Mileage unknown · Sep 2, 1999
Power TrainService Brakes, Hydraulic
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #710863
Mileage unknown · Jun 1, 1999
Service Brakes, Hydraulic
SLOWING DOWN , COSNUMER TAPPED BRAKES AND ABS LOCKED UP, CAUSING VEHICLE TO SPIN, AND RESULTING IN LOSS OF CONTROL. *AK
NHTSA ODI #838678
NHTSA investigations
14EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96074 · Sunroof (air Roof) Shatter
Opened Dec 17, 1996 · Closed May 23, 1997
Status: closed (inferred from source dates) · Structure
THE SUNROOF SHATTERED OR WAS BLOWN OFF.IN ALL BUT ONE CASE THIS OCCURRED WHILE DRIVING.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94044 · Engine Cooling Fan Cracks
Opened Jun 10, 1994 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93004 · Auto Trans Prndl Misalign
Opened Jan 29, 1993 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE92078 · Auto Trans.prndl Misalign
Opened Sep 9, 1992 · Closed Jan 29, 1993
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
Illustration