IllustrationMECHANISM THAT HOLDS SPARE TIRE RUSTED AND SPARE TIRE FELL OFF WHILE DRIVING.*AK
1992 Ford Explorer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1992 Ford Explorer do not stand out strongly from the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 34 of 633 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
47 crash reports63 fire reports37 injury reports
Equipment complaints
23 reportsWHILE TRAVELING ON HIGHWAY AND WITHOUT PRIOR WARNING, CABLE BROKE AND SPARE TIRE FELL FROM UNDERNEATH THE VEHICLE. DEALERSHIP IS AWARE OF PROBLEM.*AK JLG
SPARE TIRE JUST FELL OUT OF THE HOLDING ARE FOR IT WHEN I SLOWED DOWN TO HIT A BUMP IN THE ROAD, ROAD IS UNDER CONSTRUCION SO BUMP COULD NOT BE AVOIDED.
EA 00 012/SPARE TIRE WINCH CABLE: VEHICLE LOST SPARE TIRE WHILE DRIVING. NOTICED SPARE CABLE HAD BROKEN. MANUFACTURER WAS NOTIFIED. *AK *YH
THE CABLE BROKE AND THEN THE SPARE TIRE WAS RUN OVER BY A TRUCK.*AK
WHILE CONSUMER WAS UNDER VEHICLE HE NOTICED THAT SPARE TIRE WAS MISSING. SPARE TIRE ASSEMBLY CABLE HAD SNAPPED, ALLOWING TIRE AND OTHER COMPONENTS TO DISCONNECT FROM VEHICLE. *AK CONSUMER STATES THE TIME, PLACE, OR SPEED OF CABLE FAILURE IS UNKNOWN. *SLC
SMOKE A LOT OF SMOKE COMES OUT OF A/C HEATER VENTS THE SECOND TIME SO MUCH IT WAS HARD TO SEE OUT THAT WINDSHIELD SMELL OF BURNING RUBBER. *AK
PART # F77Z-1A480-AB / LFT & GR ASY-S. THE SPARE TIRE IS UNDER THE CAR IN THE REAR. THE TIRE IS ATTACHED TO A CABLE WIRE AND CRANKED UP UNDER THE CAR. THE CABLE BROKE, AND THE TIRE FELL OFF THE CAR, WHEN I DROVE OVER A RAILROAD CROSSING. THERE WAS A MODERATE BUMP. I WAS DRIVING APPROX 35 MPH.
CABLE HOLDING THE SPARE TIRE BROKE AND TIRE FELL OFF, CABLE WAS FRAYED. ALSO THE FRONT LOCKING HUB OF THE WHEEL DRIVE ENGAGED WITHOUT WARNING, TRUCK PULLED HARD TO THE RIGHT, FORCING THE TRUCK OFF THE ROAD.
THE CABLE THAT HOLDS THE SPARE TIRE IN PLACE UNDER THE REAR OF MY 1992 FORD EXPLORER SNAPPED WHILE THE VEHICLE WAS MOVING. THIS CAUSED THE FULLY INFLATED, FULL SIZE TRUCK TIRE TO DROP TO THE HIGHWAY IN TRAFFIC. IT BOUNCED UPRIGHT AND BEGAN ROLLING INTO THE TRAFFIC FOLLOWING MY VEHICLE. UPON INSPECTION OF THE CABLE, IT APPEARS…
Read full complaint
THE CABLE THAT HOLDS THE SPARE TIRE IN PLACE UNDER THE REAR OF MY 1992 FORD EXPLORER SNAPPED WHILE THE VEHICLE WAS MOVING. THIS CAUSED THE FULLY INFLATED, FULL SIZE TRUCK TIRE TO DROP TO THE HIGHWAY IN TRAFFIC. IT BOUNCED UPRIGHT AND BEGAN ROLLING INTO THE TRAFFIC FOLLOWING MY VEHICLE. UPON INSPECTION OF THE CABLE, IT APPEARS TO HAVE RUSTED TO THE POINT IT COULD NO LONGER HOLD THE WEIGHT OF THE TIRE. THERE WAS NO WARNING THAT THE CABLE WAS ABOUT TO SNAP.
Official recalls
497V235001 · Structure:body:roof And Pillars
Dec 18, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH FACTORY INSTALLED SUNROOF. THE SUNROOF GLASS PANEL ASSEMBLY CAN SEPARATE WHILE THE VEHICLE IS MOVING DUE TO INCORRECT HINGE ENGAGEMENT. THIS WAS CAUSED BY IMPROPER SUNROOF INSTALLATION OF THE GLASS PANEL.
Consequence & remedy
Consequence: UNEXPECTED SEPARATION OF THE SUNROOF GLASS PANEL COULD POSSIBLY DISTRACT THE DRIVER INCREASING THE RISK OF A VEHICLE CRASH OR LOSS OF VEHICLE CONTROL.
Remedy: OWNERS WILL BE PROVIDED WITH AN INSTRUCTION BOOKLET WHICH THOROUGHLY OUTLINES, WITH ILLUSTRATIONS, THE PROPER PROCEDURES FOR THE REMOVAL, STORAGE, AND REINSTALLATION OF THE SUNROOF'S GLASS PANEL. A WARNING LABEL FOR ATTACHMENT TO THE SUNROOF'S LATCH KNOB WILL ALSO BE PROVIDED TO THE OWNERS.
97V083000 · Visibility:rearview Mirrors/devices
May 5, 1997
A SHORT CIRCUIT CONDITION CAN OCCUR IN THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AS A RESULT OF A SEPARATED PART OF THE CONTACT ASSEMBLY BRIDGING THE SWITCH POSITIVE BATTERY PAD AND ADJACENT CHASSIS GROUND PAD.
Consequence & remedy
Consequence: THE CURRENT CAN OVERHEAT THE PRINTED CIRCUIT BOARD AND OTHER PLASTIC AND ELASTOMERIC COMPONENTS OF THE SWITCH ASSEMBLY RESULTING IN SMOKE OR FIRE.
Remedy: DEALERS WILL INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.
96V024001 · Service Brakes, Hydraulic:power Assist:hydraulic
Feb 5, 1996
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
Consequence & remedy
Consequence: IF A CRACK OCCURS, IT COULD RESULT IN ONE OR BOTH STUDS FRACTURING. THE MASTER CYLINDER COULD THEN SEPARATE FROM THE VACUUM BOOSTER, WHEN THE BRAKES ARE APPLIED, PREVENTING THE SERVICE BRAKES FROM ACTIVATING INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE POWER BRAKE VACUUM BOOSTER ASSEMBLY.
95V164001 · Structure:body:hatchback/liftgate:support Device/strut
Aug 25, 1995
THE HYDRAULIC LIFT CYLINDERS ARE ATTACHED TO BRACKETS THAT ARE WELDED TO THE LIFTGATE. THE BRACKET WELDS CAN FRACTURE.
Consequence & remedy
Consequence: WITH A BROKEN BRACKET WELD, THERE IS A POTENTIAL FOR THE LIFTGATE BRACKET TO GRADUALLY BEND INWARD ALLOWING THE LIFT CYLINDERBALL STUD TO DISENGAGE.
Remedy: DEALERS WILL INSTALL REINFORCEMENT BRACKETS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
14EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96074 · Sunroof (air Roof) Shatter
Opened Dec 17, 1996 · Closed May 23, 1997
Status: closed (inferred from source dates) · Structure
THE SUNROOF SHATTERED OR WAS BLOWN OFF.IN ALL BUT ONE CASE THIS OCCURRED WHILE DRIVING.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94044 · Engine Cooling Fan Cracks
Opened Jun 10, 1994 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93004 · Auto Trans Prndl Misalign
Opened Jan 29, 1993 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE92078 · Auto Trans.prndl Misalign
Opened Sep 9, 1992 · Closed Jan 29, 1993
Status: closed (inferred from source dates) · Power Train
There is no summary currently available